2002 HONDA PASSPORT wheel

222Care and Maintenance
Front (4WD Only) and Rear
Propeller Shaft
Lubricate the sliding yoke with
EP chassis grease. Lubricate
universal joints with grease
containing MoS
2 (molybdenum
disulfide-type grease) at the
intervals shown in the
Maintenance Schedule. Also
check the propeller shaft
flange-to-pinion bolts for proper
torque of 64 N⋅ m (46.3 lb-ft).
Most lubrication recommendations
and procedures for four-wheel drive-
equipped vehicles are the same
for the corresponding components
in conventional drive vehicles.
Exhaust System
Check the complete exhaust
system and nearby body areas for
damaged, missing, or
mispositioned parts, open seams, holes, loose connections, or other
deterioration that could allow
exhaust fumes to seep into the
passenger compartment or cause
heat build-up in the floor pan. Any
necessary corrections should be
made immediately. For continued
safety, exhaust system pipes and
resonators rearward of the muffler
must be replaced whenever a new
muffler is installed.
Fuel Line and Fuel Tank/Cap
Inspect the fuel tank, cap and lines
for damage that could cause
leakage. Inspect the fuel cap and
gasket for correct sealing ability
and indications of physical
damage. Replace any damaged or
malfunctioning parts.
Drive Belt
Check the belt driving the
alternator, power steering pump,
and air conditioning compressor.
Look for cracks, fraying, and
wear. Replace as necessary.
Timing Belt
The timing belt should normally
be replaced at the intervals shown
in the Maintenance Schedule.
Valve Clearance
Incorrect valve clearance will
result in increased engine noise
and lower engine output, thereby
adversely affecting engine
performance.

224Care and Maintenance
Wheel Alignment
Proper wheel alignment improves
tire mileage. Your vehicle’s
suspension parts should be
inspected often and aligned when
needed (see the “Technical Data”
section). Improper alignment will
cause the front tires to roll at an
angle that will result in faster tire
wear.
Proper tire balancing provides the
best riding comfort and helps
reduce tire tread wear.
Out-of-balance tires can cause
annoying vibration and uneven
tire wear such as cupping and flat
spots.
Washing Your Vehicle
The best way to preserve your
vehicle ’s finish is to keep it clean by
frequent washings. Wash the vehicle
with lukewarm or cold water.
Do not use hot water or wash in
direct sunlight. Do not use strong
soap or chemical detergents. All
cleaning agents should be promptly
flushed from the surface and not
allowed to dry on the finish.
Polishing and Waxing
Your Vehicle
Polishing is recommended to
remove accumulated residue and
eliminate any “weathered”
appearance.
Your Honda dealer offers several
polishes and cleaners that have
proven to maintain the original
finish appearance and durability.
Protection of Exterior
Bright Metal Parts
Bright metal parts should be cleaned
regularly to keep their luster.
Washing with water is all that is
usually needed. However, chrome
polish may be used on chrome or
stainless steel trim, if necessary. A
coating of wax, rubbed to a high
polish, is recommended for all bright
metal parts.
Care of Aluminum Wheels
Aluminum wheels have a
clear-coat finish similar to paint.
Use a chamois skin, sponge or
other soft material when washing
the wheels.
Foreign Material Deposits
Calcium chloride and other salts,
ice melting agents, road oil and
tar, tree sap, bird droppings,
Exterior

238Technical Data
Front Suspension
Independent wishbone arms, torsion bar springs with
stabilizer bar.
Front Wheel Alignment
Toe-in2

2 mm (0.08 in.)–
Camber0°
30No more than 30 
side-to-side variation
Caster2
30 
45No more than 30 
side-to-side variation
Rear Suspension
5-link, coil spring type with stabilizer bar and direct
double-acting shock absorbers.
Rear Wheel Alignment
Toe-in0
5 mm (0.2 in.)
Camber0°
1°
Toe-Axis
1

Steering
Rack and pinion.
Service Brake
Hydraulic Front: Disc brake.
Rear: Self-adjusting drum brake, leading-trailing (2
WD model).
Disc brake (4
WD model).
Parking Brake
Mechanical, operating on rear wheels (2
WD model).
Mechanical, drum in disc, duo-servo, manual-adjusting,
operating on rear wheels (4
WD model).
Battery
Voltage (V)12
Cold-cranking performance (Amp)600
Reserve capacity (Min.)125
BCI group no.24

Technical Data239
Rear Axle
Models2WD4WDModels2WD4WD
Gear ratio4 3004 300Gear ratio4.3004.300
Lubricant capacity1.87 U.S. quarts(1.77 liters)
Front Axle (4WD Model)
Gear ratio4.300
Lubricant capacity1.6 U.S. quarts (1.5 liters)
Shift-on-the-Fly System
Lubricant capacity0.13 U.S. quarts (0.12 liters)
Wheels and Tires
Tire size225/75R16245/70R16
Wheel size16 x 7 JJ16 x 7 JJ
Tire pressure29 psi (200 kPa)26 psi (180 kPa)
Wheel nut
tightening torque87 lb.ft (118 N.m )

Technical Data243
Light Bulbs
ApplicationBulb No.QuantityRating
Candlepower
Front Lights
Headlight – Halogen
Fog
Turn signal & Parking light
Sidemarker9004
10342
2
265/45 watts
55 watts 21/5
Rear LightsBack-up
License
Tail, Stop & Sidemarker
Turn signal
High-mounted stop light1156
–
1157
1156 –2
2
2
2
427 watts
5 watts
27/8 watts
27
5 watts
Interior Illumination A/C-heater cont.
Dome light
Instrument cluster
Stop light
Luggage light
Step light74
–
158/74 –
–
–1
1
3/6 or 2 2
1
41.4
7 watts 2/1.4
5 watts
5 watts
5 watts
Dimensions and Weights
Model2WD4WD
Wheelbase–106.4 in. (2,702 mm)
Overall
Spare tire:
under floor178.2 in. (4,525 mm)OverallLengthSpare tire: tailgate184.2 in. (4,678 mm)
OverallLX, EX70.4 in. (1,784 mm)OverallWidthEX-L71.1 in. (1, 805 mm)
OverallHeightP225/75R1668.6 in. (1,743 mm)Height
(At curb Wt.)P245/70R1668.8 in. (1,748 mm)
Tread Front59 6 in (1 515 mm)Tread Front59.6 in. (1,515 mm)
Tread Rear59 8 in (1 520 mm)Tread Rear59.8 in. (1,520 mm)
GVWR–4,950 lb
(2,250 kg)5,200 lb
(2,360 kg)
Note: GVWR—Gross Vehicle Weight Rating

251Owner Assistance
Treadwear
The treadwear grade is a
comparative rating based on the
wear rate of the tire when tested
under controlled conditions on a
specified government test course.
For example, a tire graded 150
would wear one-and-a-half
(1-1/2) times as well on the
government course as a tire
graded 100. The relative
performance of tires depends
upon the actual conditions of their
use, however, and may depart
significantly from the norm due to
variation in driving habits, service
practices and differences in road
characteristics and climate.
Traction – AA, A, B, C
The traction grades from highest
to lowest are AA, A, B, and C.
Those grades represent the tire’sability to stop on wet pavement as
measured under controlled
conditions on specified
government test surfaces of
asphalt and concrete. A tire
marked C may have poor traction
performance.
Warning: The traction grade
assigned to this tire is based on
straight-ahead braking traction
tests, and does not include
acceleration, cornering,
hydroplaning, or peak traction
characteristics.
Temperature – A, B, C
The temperature grades are A (the
highest), B and C, representing
the tire’
s resistance to the
generation of heat and its ability
to dissipate heat when tested
under controlled conditions on a specified indoor laboratory test
wheel. Sustained high temperature
can cause the material of the tire
to degenerate and reduce tire life
and excessive temperature can
lead to sudden tire failure. The
grade C corresponds to a level of
performance which all vehicle
tires must meet under the Federal
Motor Vehicle Safety Standard
No. 109. Grades B and A
represent higher levels of
performance on the laboratory test
wheel than the minimum required
by law.
Warning: The temperature grade
for this tire is established for a tire
that is properly inflated and not
overloaded. Excessive speed,
underinflation, or excessive
loading either separately or in
combination, can cause heat
build-up and possible tire failure.

257

Controls Near
the Steering Wheel
Hazard Warning
76. . . . . . . . .
Headlights
72. . . . . . . . . . . . .
Illumination Control
73. . . . .
Rear Window Defogger
74. . .
Steering Wheel Adjustment
115
Turn Signals75. . . . . . . . . . . .
Windshield Wiper/Washer
70.
Rear Window Wiper/ Washer
74. . . . . . . . . . . .
Coolant Adding
218. . . . . . . . . . . . . . . .
Capacity
236. . . . . . . . . . . . . . .
Checking
217. . . . . . . . . . . . . .
Proper Solution
218. . . . . . . . .
Temperature Gauge
60. . . . . .
Corrosion Protection
225. . . . . . .
Courtesy Lights
112. . . . . . . . . . . Crankcase Emissions
Control System
249. . . . . . . . . .
Cruise Control Operation
147. . . .
Customer Relations Information
246. . . . . . . . . . . . .
D
DANGER, Explanation ofiv. . . .
Dashboard
56. . . . . . . . . . . . . . .
Defects, Reporting Safety
248. . .
Defogger, Rear Window
74. . . .
Defrosting the Windows
122. . . .

\b 153
\b\b\b\b\b\b\b\b\b\b\b\b\
\b\b\b
Dimensions243. . . . . . . . . . . . . .
Dimming the Headlights
72. . . .
Dipstick, Engine Oil
200, 213. . .
Directional Signals
75. . . . . . . . . Disc Brake Wear Indicators
162. .
Dome Light
111. . . . . . . . . . . . . .
Door Locks
9. . . . . . . . . . . . . . . .
Power
104. . . . . . . . . . . . . . . . .
Doors, Close and Lock
10. . . . . .
DOT Tire Quality Grading
251. . .
Downshifting, 5-Speed Manual Transmission
84. . . . .
Drive Belts
222. . . . . . . . . . . . . . .
Driving, On-Road Fuel Economy
170. . . . . . . . . .
In Bad Weather
168. . . . . . . . .
In Foreign Countries
173. . . . .
On Slippery Surfaces
162. . . . .
E
Economy, Fuel170. . . . . . . . . . . .
EGR System
250. . . . . . . . . . . . . .
Emergency Brake
86. . . . . . . . . .

262
Owner Assistance245. . . . . . . . .
Owner Safety Checks
208. . . . . . .
P
Panel Brightness Control73. . . .
Park Gear Position
77. . . . . . . . .
Parking Brake and Brake System Light
61, 86. . . . .
Parking Over Things That Burn
159. . . . . . . . . . . . . . .
Polishing and Waxing
224. . . . . .
Power Drive Indicator
69, 81. . . .

\b\f

\b
 117
\b\b\b\b\b
Power Steering Belt.
See Drive Belts
!"\b 
\b\

9
\b\b\b\b\b
Pregnancy, Using Seat Belts16.
Proper Seat Belt Usage
13. . . . .


\b
\f
 10
\b\b\b\b\b\b\b\b\b\b\b\b\


 \b 
\b \f
 17
\b\b\b\b\b\b\b\b
Adjust the Front Seat10
. . . . . .
Adjust the Head Restraints12 .
Adjust the Seat-Backs11
. . . . .
Adjust the
Steering Wheel
15
. . . . . . . . . .
Advice for Pregnant Women16
Close and Lock the Doors1 #
. .
Fasten and
Position the Seat Belt
s $%
. . . .
Protecting Children18
. . . . . . . . . .
Additional
Safety Precaution
s21 . . . . . . .
All Children
Must Be Restrained
18
. . . . . .
Children Should
Sit in the Back Seat
19
. . . . . .
General Guidelines for
Using Child Seats
22
\b\b\b\b\b\b\b\b
If a Child Requires
Close Attention
21
\b\b\b\b\b\b\b\b\b\b
If You Must Drive
With Several Children
20
. . . .
Passenger ’s Airbag Poses
Serious Risks to Childre
 19
\b
Protecting Infants26
\b\b\b\b\b\b\b\b\b
Protecting Larger Children34
\b
Protecting Small Children31
\b\b
Using Child Seats
With Tethers
38
\b\b\b\b\b\b\b\b\b\b\b\b\
R
Radiator Overheating190. . . . . . .
Radio/Cassette Sound System
125. . . . . . . . . . .
Radio/Cassette/CD Sound System
133. . . . . . . . . . .
Rear Lights, Bulb Replacement
243. . . . . . . .