2002 BMW MOTORRAD R 1150 RT check engine

i
2
Introduction
General information and con-
trols
General view, left side ........... 4
General view, right side ......... 5
Cockpit ................................. 6
Telltale and warning lights ..... 7
Ignition switch and steering
lock .................................... 8-9
Left handlebar fitting ........... 10
Right handlebar fitting ......... 11
Seats ............................. 12-13
System case .................. 14-15
Adjusting the windshield ..... 16
Hazard warning flashers ...... 17Safety check
Checklist ........................ 18-19
Engine oil ....................... 20-21
Fuel ................................ 22-23
Handlebar levers ............ 24-25
Brake system
- general ........................ 26-27
- with BMW Integral
ABS ............................ 28-31
Clutch ................................. 32
Lights ............................. 33-35
Shock absorbers ................ 36
Suspension spring
preload ............................... 37
Wheels ........................... 38-39
Loads............................. 40-41
Contents
10r22bkg3.book Seite 2 Freitag, 27. Januar 2006 12:43 12

2
19
Safety check
For this reason, check the
details in the following sections
before you start the journey:
–Fuel level
– Positions of the handlebar-
lever fittings
– Brake fluid level
– Clutch fluid level
– Brakes
– Warning lights and telltale
lights
– Lights
– shock absorber settings
and spring preload
– condition of wheels and tyres,
tread depth and tyre pres-
sures
– Load, gross weight –
Check at regular intervals as
described in the following
sections
(each time you stop for refuel-
ling):
– Engine oil level
(every second or third time
you stop for refuelling):
– Brake pads
If you encounter any problems
or difficulties, it is always best to
contact your authorised BMW
Motorrad dealer.
He will provide the necessary
advice and assistance.
Checklist
10r22bkg3.book Seite 19 Freitag, 27. Januar 2006 12:43 12

2
20
Safety check
Engine oil
Checking oil levelCheck oil level regularly each
time you stop to refuel.
Only check the engine oil when
the engine is at normal operat-
ing temperature as the oil level
can vary by up to 10 mm
(0.39 in) in a hot engine or a
cold engine at extreme outside
temperatures (-10°C).
Wait at least five minutes after
switching off the hot engine for
the oil to collect in the sump. Checking the oil level after the
engine has only been used for a
short time or is only just warm
could lead to wrong interpretati-
ons and thereby to an incorrect
oil fill because the cold, more
viscous oil takes longer to flow
back into the sump. This can
take up to 12 hours at extreme
temperatures (-10
°C).
e Attention:
To avoid damage to the engine:
– Never exceed the maximum
oil level.
Always keep the oil level above
the minimum mark.
Always check the oil level with
the motorcycle standing up-
right.
 Check the oil when the engine
is at normal operating tem-
perature
 Read the oil level at least five
minutes after switching off the
engine
 Make sure that the motorcy-
cle is upright
– ensure that the surface is
level and firm!
10r22bkg3.book Seite 20 Freitag, 27. Januar 2006 12:43 12

2
21
Safety check
1
MAXMIN
2
Engine oil

Check oil level at sight glass:
MAX Upper edge
Ring marking
MIN Lower edge
Ring marking
– The difference between the
two marks is approx. 0.5 litres
(0.88 Imp. pints)
 If necessary, unscrew the oil
filler screw 2 and top up the
engine oil through the engine
oil filler 1
 Then retighten the oil filler
screw 2
e Attention:
Warning light, engine oil pres-
sure red
p\b(b 7)\bindicates no
(or very little) oil pressure in
the lube-oil system; this light
m u s t n o t b e r e g a r d e d a s a n o i l
level check. Oil pressure
builds up after 1-2 seconds
and the warning light goes out
– the redengine oil pressure
warning light
p should re-
main off while the engine is
running
BMW recommends Castrol
10r22bkg3.book Seite 21 Freitag, 27. Januar 2006 12:43 12

2
22
Safety check
Refuelling
d Warning:
Fuel is flammable and explo-
sive. Do not smoke. Never
bring a naked flame near the
fuel tank.
The fuel expands when hot
(for instance if the fuel tank is
in the sun). For this reason,
only fill as far as the lower
edge of the filler neck!
e Attention:
Note that fuel containing lead
will destroy the catalytic con-
verter.
Do not run the fuel tank dry or
you may damage the engine or
catalytic converter.
Wipe off plastic parts immedi-
ately if they are wetted with fuel.
 Place motorcycle on centre
stand
– Make sure the ground is level
and firm.
 Open fuel filler cap
Fuel
10r22bkg3.book Seite 22 Freitag, 27. Januar 2006 12:43 12

3
46
Starting – Riding – Parking
Side stand
Placing motorcycle on
side stand
d Warning:
For safety reasons, never sit
on the motorcycle with the
side stand extended.
e Attention:
Stop the engine before using
the side stand.
Make sure the surface under
the stand is firm.
On a gradient, the motorcycle
should always face uphill;
select 1st gear. 
Switch off the ignition
 Keep both feet on the ground
 Hold the left handlebar grip
with your left hand
 Keep your right hand on the
right handlebar grip and the
handbrake lever
 Hold the motorcycle upright
and balanced
 Use your left foot at the exten-
sion pin to fold the side stand
out fully (arrow)
 Lean the motorcycle carefully
on to the stand
 Turn the handlebars to left
lock
 Check that the motorcycle
is firmly supported
10r22bkg3.book Seite 46 Freitag, 27. Januar 2006 12:43 12

3
48
Starting – Riding – ParkingPlacing motorcycle on
centre stand
d Warning:
For safety reasons, never sit
on the motorcycle with the
centre stand extended.
e Attention:
Switch off the engine before
using the centre stand.
Make sure the surface under
the stand is firm. 
Switch off the ignition
 Hold the left handlebar grip
with the left hand
 Hold the lifting handle with the
right hand
 Place the right foot on the
extension pin and press it down
until the curved shoes of the
stand touch the ground
 Place your right foot on the
tread surface of the stand
 Apply all your body weight to
the stand
 Pull the motorcycle to the rear
and upwards (arrow) until it
rests on the centre stand
 Check that the motorcycle
is firmly supported
Main (centre) stand
10r22bkg3.book Seite 48 Freitag, 27. Januar 2006 12:43 12

3
57
Starting – Riding – Parking
5
Engine oil pressureWarning light 5 goes out above
idle speed.
e Attention:
If warning light 5 comes on dur-
ing the journey, take the follow-
ing action as soon as traffic
conditions permit:
 Declutch
 Operate the kill switch
 Bring the motorcycle safely to
a halt
check engine oil level (b 21)
e Attention:
If the warning light comes on
even though the oil level is cor-
rect, you must consult a spe-
cialist workshop, preferably an
authorised
BMW motorcycle dealer.
Telltale and warning lights
10r22bkg3.book Seite 57 Freitag, 27. Januar 2006 12:43 12