Page 49 of 106
6-5
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
EAU03541
NOTE:
8The air filter needs more frequent service if you are riding in unusually wet or dusty areas.
8Hydraulic brake service
9Regularly check and, if necessary, correct the brake fluid level.
9Every two years replace the internal components of the brake master cylinder and caliper, and change the brake
fluid.
9Replace the brake hoses every four years and if cracked or damaged.22Final gear oil¥Check vehicle for oil leakage.ÖÖÖ
¥Change.ÖÖÖ
23
*V-belt¥Replace.ÖÖ
24*Front and rear brake
switches¥Check operation.ÖÖÖÖÖÖ
25Moving parts and cables¥Lubricate.ÖÖÖÖÖ
26*Lights, signals and
switches¥Check operation.
¥Adjust headlight beam.ÖÖÖÖÖÖ NO.ITEMCHECK OR MAINTENANCE JOBODOMETER READING (´1,000 km)
ANNUAL
CHECK
110203040
5GM-9-E1(No ABS) 9/27/00 2:18 PM Page 48
Page 50 of 106
6-6
1
1
EAU03624
Removing and installing
cowlings and panelThe cowlings and panel shown above
need to be removed to perform some
of the maintenance jobs described in
this chapter. Refer to this section
each time a cowling or panel needs
to be removed and installed.1.Cowling A1.Cowling B
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
1
1.Cowling C
5GM-9-E1(No ABS) 9/27/00 2:18 PM Page 49
Page 51 of 106
6-7
1
2
2 11
1.Mat A
2.Mat B1.Screw (´4)
2.Cowling A
EAU03615
Cowling A
To remove the cowling1.Pull up the left floorboard mats
as shown.2.Remove the screws.
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
1
1.Panel A
5GM-9-E1(No ABS) 9/27/00 2:18 PM Page 50
Page 52 of 106
6-8
1
1
2
3.Pull the cowling down slightly,
and then pull it outward as
shown.To install the cowling
1.Insert the tabs on the cowling
into the slots as shown, and then
install the screws.
2.Place the floorboard mats in the
original position.
ECA00067
cCTake care not to damage the tabs
on the cowling when removing and
or installing it.
EAU03632
Cowling B
To remove the cowling1.Pull up the right floorboard mats
as shown.
1.Tab (´10)1.Mat A
2.Mat B
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
5GM-9-E1(No ABS) 9/27/00 2:18 PM Page 51
Page 53 of 106
6-9
2 1
1
1
2.Remove the screws.1.Screw (´4)
2.Cowling B1.Tab (´10)
3.Pull the cowling down slightly,
and then pull it outward as
shown.To install the cowling
1.Insert the tabs on the cowling
into the slots as shown, and then
install the screws.
2.Place the floorboard mats in the
original position.
ECA00067
cCTake care not to damage the tabs
on the cowling when removing and
or installing it.
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
95GM-9-E1(No ABS) 9/27/00 2:18 PM Page 52
Page 54 of 106
6-10
1
aa
EAU03617
Cowling C
To remove the cowling1.Remove the screws.2.Push the cowling in lightly, and
then pull it back as shown.
ECA00067
cCTake care not to damage the tabs
on the cowling when removing and
or installing it.
1.Screw (´2)a.Push.
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
5GM-9-E1(No ABS) 9/27/00 2:18 PM Page 53
Page 55 of 106
6-11
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
1
2
To install the cowling1.Insert the tabs on the cowling
into the slots as shown, and then
push the cowling in until it snaps
into place.
2.Install the screws.1.Tab (´4)
2.Slot (´4)
EAU03628
Panel A
To remove the panelRemove the bolts, and then pull the
panel out as shown.
1
2
1.Bolt (´2)
2.Panel A
5GM-9-E1(No ABS) 9/27/00 2:18 PM Page 54
Page 56 of 106
6-12
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
1
1
1.Tab (´4)To install the panelPlace the panel in the original posi-
tion, and then install the bolts.
1
To remove the spark plug
1.Remove cowling B. (See page
6-8 for cowling removal and
installation procedures.)
2.Remove the spark plug cap.1.Spark plug cap
EAU03620
Checking the spark plugThe spark plug is an important
engine component, which is easy to
check. Since heat and deposits will
cause any spark plug to slowly erode,
the spark plug should be removed
and checked in accordance with the
periodic maintenance and lubrication
chart. In addition, the condition of the
spark plug can reveal the condition of
the engine.
5GM-9-E1(No ABS) 9/27/00 2:18 PM Page 55