Page 65 of 91
6-28
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
EAU00774
Autolube pump adjustmentThe autolube pump is a vital part of
the engine and requires very sophisti-
cated adjustment.
Adjusting should be left to a Yamaha
dealer who has the professional
knowledge and experience to do so.
EAU02984
Brake and shift pedal
lubricationLubricate the pivoting parts.
EAU02985
Brake and clutch lever
lubricationLubricate the pivoting parts.
Recommended lubricant:
Engine oil
Recommended lubricant:
Engine oil
3MB-9-E7 12/27/00 2:52 PM Page 64
Page 66 of 91
6-29
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
EAU02986
Sidestand lubricationLubricate the sidestand pivoting point
and metal-to-metal contact surfaces.
Check that the sidestand moves up
and down smoothly.
EW000113
wIf the sidestand does not move
smoothly, consult a Yamaha deal-
er.
Recommended lubricant:
Engine oil
EAU02939
Front fork inspectionVisual check
EW000115
wSecurely support the motorcycle
so there is no danger of it falling
over.Check for scratches or damage on
the inner tube and excessive oil leak-
age from the front fork.Operation check
1.Place the motorcycle on a level
place.
2.Hold the motorcycle in an upright
position and apply the front
brake.
3.Push down hard on the handle-
bars several times and check if
the fork rebounds smoothly.
EC000098
cCIf any damage or unsmooth move-
ment is found with the front fork,
consult a Yamaha dealer.
3MB-9-E7 12/27/00 2:52 PM Page 65
Page 67 of 91
6-30
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
EAU00794
Steering inspectionPeriodically inspect the condition of
the steering. Worn out or loose steer-
ing bearings may be dangerous.
Place a stand under the engine to
raise the front wheel off the ground.
Hold the lower end of the front forks
and try to move them forward and
backward. If any free play can be felt,
ask a Yamaha dealer to inspect and
adjust the steering. Inspection is eas-
ier if the front wheel is removed.
EW000115
wSecurely support the motorcycle
so there is no danger of it falling
over.
EAU01144
Wheel bearingsIf there is play in the front or rear
wheel hub or if the wheel does not
turn smoothly, have a Yamaha dealer
inspect the wheel bearings.
3MB-9-E7 12/27/00 2:52 PM Page 66
Page 68 of 91
6-31
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
EAU01071
BatteryCheck the level of the battery elec-
trolyte and make sure that the termi-
nals are tight.
Fill with distilled water if the elec-
trolyte level is low.1.Battery
2.Battery breather hose
EC000099
cCWhen inspecting the battery, be
sure the breather hose is routed
correctly. If the breather hose is
positioned in such a way as to
cause battery electrolyte or gas to
exit onto the frame, structural and
cosmetic damage to the motorcy-
cle can occur.
12
EW000116
wBattery electrolyte is poisonous
and dangerous, causing severe
burns, etc. It contains sulfuric
acid. Avoid contact with skin, eyes
or clothing.
ANTIDOTE:
8 8
EXTERNAL: Flush with water.
8 8
INTERNAL: Drink large quanti-
ties of water or milk. Follow
with milk of magnesia, beaten
egg, or vegetable oil. Call a
physician immediately.
8 8
EYES: Flush with water for 15
minutes and get prompt med-
ical attention.
Batteries produce explosive
gases. Keep sparks, flame, ciga-
rettes etc., away. Ventilate when
charging or using in an enclosed
space. Always shield your eyes
when working near batteries.
KEEP OUT OF REACH OF CHIL-
DREN.
3MB-9-E7 12/27/00 2:52 PM Page 67
Page 69 of 91
6-32
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9Replenishing the battery fluid
A poorly maintained battery will cor-
rode and discharge quickly. The bat-
tery fluid should be checked at least
once a month. The level should be
between the minimum level and max-
imum level marks. Use only distilled
water if refilling is necessary.
EC000100
cCNormal tap water contains miner-
als which are harmful to a battery;
therefore, refill only with distilled
water.
EW000117
wTake care not to spill battery fluid
on the chain.
Battery fluid may weaken the chain
causing shorter chain life and pos-
sibly result in an accident.
1.Maximum level mark
2.Minimum level mark
1
2
Battery storage
8When the motorcycle will not be
used for a month or longer,
remove the battery, fully charge
it and store it in a cool, dry place.
Completely recharge the battery
before reinstallation.
8If the battery will be stored for
longer than two months, check
the specific gravity of the fluid at
least once a month and fully
recharge the battery when it is
too low.
8Always make sure the connec-
tions are correct when putting
the battery back in the motorcy-
cle. Make sure the breather hose
is properly connected and is not
damaged or obstructed.
3MB-9-E7 12/27/00 2:52 PM Page 68
Page 70 of 91
6-33
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
EAU00804
Fuse replacementIf the fuse is blown, turn off the main
switch and the switch of the circuit in
question. Install a new fuse of speci-
fied amperage. Turn on the switches
and see if the electrical device oper-
ates. If the fuse immediately blows
again, consult a Yamaha dealer.1.Fuse
EC000103
cCDo not use fuses of higher amper-
age rating than those recommend-
ed. Substitution of a fuse of
improper rating can cause exten-
sive electrical system damage and
possibly a fire.
Specified fuse:
10 A
1
1
1.Bolt (´2)
EAU01158
Headlight bulb replacementIf the headlight bulb burns out,
replace the bulb as follows:
1.Remove cowling A. (See page
6-6 ~ 6-7 for removal and instal-
lation procedures.)
2.Remove the headlight unit by
removing the bolts.
3MB-9-E7 12/27/00 2:52 PM Page 69
Page 71 of 91
6-34
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
93.Remove the headlight connector
and the bulb holder cover.4.Turn the bulb holder counter-
clockwise to remove it and then
remove the defective bulb.
EW000119
wKeep flammable products and your
hands away from a bulb while it is
on, as it is hot. Do not touch a bulb
until it cools down.5.Put a new bulb into position and
secure it in place with the bulb
holder.
12
1.Bulb holder cover
2.Connector
1
1.Bulb holder
6.Install the bulb holder cover, con-
nector and headlight unit.
7.Install the cowling.
8.If the headlight beam adjustment
is necessary, ask a Yamaha
dealer to make that adjustment.
3MB-9-E7 12/27/00 2:52 PM Page 70
Page 72 of 91
6-35
PERIODIC MAINTENANCE AND MINOR REPAIR
1
2
3
4
56
7
8
9
1
2
3
1
2
3
1.Screw (´2)
2.Lens
3.Bulb 1.Screw
2.Lens
3.Bulb
EAU01095
Turn signal light bulb
replacement1.Remove the screw and the lens.
2.Remove the defective bulb by
pushing it inward and turning it
counterclockwise.
3.Install a new bulb by pushing it
inward and turning it clockwise.
4.Install the lens and tighten the
screw.
EAU01623*
Tail/brake light bulb
replacement1.Remove the screws and the
lens.
2.Remove the defective bulb by
pushing it inward and turning it
counterclockwise.
3.Install a new bulb by pushing it
inward and turning it clockwise.
4.Install the lens and tighten the
screws.
EC000108
cCDo not over-tighten the screws as
the lens may break.
3MB-9-E7 12/27/00 2:52 PM Page 71
