1998 PONTIAC GRAND AM cooling

Fuse
HVAC BLO
MOT
PCM BATT
CLG FAN
HDLP
STOP LPS
PWR ACC
RR DEFG
ABS
IGN SW
Usage
Heater/Air Conditioner-High
Blower, Generator-Voltage Sense
Powertrain Computer
Engine Cooling
Fan
Lighting Circuits
Power Accessories,
Stop Lamp Circuits,
Rear Window Defogger
Anti-Lock Brakes, Variable
Effort Steering
Ignition Switch Circuits
Steering Wheel Controls (If Equipped) Fuse Panel
Your steering wheel radio controls are protected by
fuses.
For service, contact your service department.
Replacement Bulbs
OUTSIDE LAMPS ..................... BULB
Back-up Lamps ......................... 2057
Front Parking/Turn Signal Lamps ........ 2057 NA
Halogen Headlamps Center High-Mounted Stoplamp
............. 9 12
Low-Beam ................... - _. . 9006
High-Beam ........................... 9005
Stop/Tail/Turn Signal Lamps ............... 2057
INSIDE LAMPS ....................... BULB
Dome Lamp ............................. 16 1
6-64

Capacities and Specifications
Engine Crankcase
2.4L Engine ............... 4.0 quarts (3.8 L)
3 100 Engine ................ 4.5 quarts (4.3 L)
Automatic Transaxle
Pan Removal and Replacement . . 6.0 quarts (5.7 L)
After Complete Overhaul ...... 8.0 quarts (7.6 L)
When draining or replacing torque converter, more fluid may be needed.
Manual Transaxle
Cooling System
Complete Drain and Refill . - . - - 2.0 quarts (1.9 L)
2.4L Engine ................ 11.3 quarts (10.7 L)
3100 Engine .............. 13.6 quarts (12.9 L)
Refrigerant, Air Conditioning ..... See refrigerant
charge label under hood.
Fuel Tank ............... 15.2 gallons (57.5 L)
Information label on driver’s door.
Wheel Nut Torque .......... 100 lb-ft (140 Nnm)
Tire Pressures, Sizes ........... See Tire-Loading
Note:
All capacities are approximate. When adding, be
sure to fill to the appropriate level or as recommended in
this manual. See “Recommended Fluids and Lubricants”
in the Index.
2.4L Engine Specifications
VIN Engine Code ........................... T
Firing Order
.......................... 1-3-4-2
Thermostat Temperature
........... 180°F (82°C)
Horsepower ............... .......... 150
3100 Engine Specifications
VIN Engine Code ........................... M
Horsepower ............................. 155
Firingorder
...................... 1-2-3-4-5-6
Thermostat Temperature
......... 195°F (91 “C)
Air Conditioning Refrigerants
Not all air conditioning refrigerants are the same.
If the air conditioning system in your vehicle needs
refrigerant, be sure the proper refrigerant is used.
If you’re not sure, ask your dealer.

Maintenance Schedule
I Short TripKity Definition I
Follow the Short TripKity Maintenance Schedule if any
one
of these conditions is true for your vehicle:
Most trips are less than 5 to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures are below freezing.
0 Most trips include extensive idling (such as frequent
driving in stop-and-go traffk).
Most trips are through dusty areas.
You frequently tow a trailer or use a carrier on top of
your vehicle. (With some models, you should never
tow a trailer.
See “Towing a Trailer” in the Index.)
If the vehicle is used for delivery service, police, taxi
One of the reasons you should follow this schedule if
you operate your vehicle under any of these conditions
is that these conditions cause engine
oil to break
down sooner.
or other commercial application.
Short TripKity Intervals
Every 3,000 Miles (5 000 km): Engine Oil and Filter
Change (or 3 months, whichever occurs first).
Every 6,000 Miles (10 000 km): Chassis Lubrication
(or
6 months, whichever occurs first). Tire Rotation.
Every 15,000 Miles (25 OOO km): Air Cleaner Filter
Inspection, if driving in dusty conditions.
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Fuel Tank, Cap and Lines Inspection.
Every 50,000 Miles (83 0oO km): Automatic Transaxle
Service (severe conditions only).
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection.
Every 100,000 Miles (166 000 km): Spark Plug Wire
Inspection. Spark Plug Replacement.
Every 150,000 Miles (240 000 km): Cooling System
Service (or every
60 months, whichever occurs first).
These intervals only summarize maintenance services.
Be sure to follow the complete maintenance schedule
on
the following pages.
7-5

Maintenance Schedule
Long Tripmighway Definition
Follow this maintenance schedule only if none of the
conditions from the Short TripKity Maintenance
Schedule is true.
Do not use this schedule if the vehicle
is used for trailer towing, driven in a dusty area
or used
off paved roads. Use the Short TripKity schedule for
these conditions.
Driving a vehicle with a fully warmed engine under
highway conditions causes engine oil to break
down slower:
Long Tripmighway Intervals
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change (or every
12 months, whichever occurs first).
Chassis Lubrication (or
every 12 months, whichever
occurs first). Tire Rotation.
Every 30,000 Miles (50 OOO km): Air Cleaner Filter
Replacement. Fuel Tank, Cap and
Lines Inspection.
Every 50,000 Miles (83 OOO km): Automatic Transaxle
Service (severe conditions only).
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection.
Every 100,OOO Miles (166 0oO km): Spark Plug Wire
Inspection. Spark Plug Replacement.
Every 150,000 Miles (240 000 km): Cooling System
Service
(or every 60 months, whichever occurs first).
These intervals only summarize maintenance services.
Be sure to follow the complete maintenance schedule
on
the following pages.

I Short Trip/City Maintenance Schedule I
100,000 Miles (166 000 km) (Continued)
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, the fluid and
filter
do not require changing.
Manual transaxle fluid doesn’t require change.
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system (or every 60 months since last service,
whichever occurs first). See “Engine Coolant” in the Index for what to use.
Inspect hoses. Clean radiator, condenser, pressure cap and neck.\
Pressure test
I I
cooling system and pressure cap.
An Emission Control Service.
7-20

I Long Trip/Highway Maintenance Schedule I
0 Change automatic transaxle fluid and filter if the vehicle is mainly driven
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly reaches 90°F
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, the fluid and
filter
do not require changing.
Manual transaxle fluid doesn’t require change.
150,000 Miles (240 000 km)
Cl Drain, flush and refill cooling system (or every 60 months since last service,
whichever occurs first).
See “Engine Coolant” in the Index for what to use.
Inspect hoses. Clean radiator, condenser, pressure cap and neck.\
Pressure test
the cooling system and pressure cap.
An Emission Control Service.
MILEAGE
7-29

Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall). You should let your dealer’s service
department or other qualified service center do these
jobs. Make sure
any necessary repairs are completed
at once.
Proper procedures to perform these services may
be
found in a service manual. See “Service and Owner
Publications” in the Index.
Steering, Suspension and Front Drive Axle
Boot
an.d Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose
or missing parts, signs of
wear or lack
of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc. Clean and then inspect
the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing
or out-of-position parts as well as open seams,
holes, loose connections or other conditions which could
cause a heat build-up
in the floor pan or could let
exhaust fumes into the vehicle. See “Engine Exhaust”
in
the Index.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes, fittings
and clamps; replace as needed. Clean the outside of the
radiator
and air conditioning condenser. To help ensure
proper operation, a pressure test of the cooling system and
pressure cap is recommended at least once
a year.
Throttle System Inspection
Inspect the throttle system for interference or binding, and for damaged or missing parts. Replace
parts as
needed. Replace any components that have high effort
or excessive wear. Do not lubricate accelerator and
cruise control cables.
7-34

Tires ............ ....... .......... 6-56
Wheels ..................................... 6-55
Windshield and Wiper Blades ................... 6-53
Climate Control System ........................... 3-2
Clock, Setting the ................................ 3-7
Clutch Fluid. Hydraulic .......................... 6-24
Clutch. Hydraulic ............................... 6-24
Comfort Controls ................................ 3-2
Compact Disc Adapter Kit ................... 3-12. 3-15
Compact Disc Care ............................. 3-25
Compact Disc Player ............................ 3-16
Compact Spare Tire ............................. 5-33
Control of a Vehicle .............................. 4-6
Convenience Net ............................... 2-49
Convex Outside Mirror .......................... 2-47
Coolant ....................................... 6-25
Adding ...................... ..... 5-18. 6-28
Checking ................................... 6-27
Heater. Engine ............................... 2-19
SurgeTank .................................. 5-18
Surge Tank Pressure Cap ....................... 6-29
Cooling System ................................ 5- 16
Courtesy Transportation ........................... 8-8
Cruise Control ................................. 2-38
Cupholder ..................................... 2-49
Customer Assistance for Text Telephone Users ......... 8-5
Customer Assistance Information ................... 8-3
Customer Satisfaction Procedure . . .............. 8-3
Damage. Finish ............................... 6-56
Damage. SheetMetal ............................ 6-56
Vinyl ........................... ........ 6-52
Climate Control System with Air Conditioning ......... 3-2
Daytime Running Lamps ..................... 2-43
Dead Battery ................................... 5-3
Defects. Reporting Safety ........................ 8-10
Defensive Driving ............................... 4-2
Defogger. Rear Window .......................... 3-5
Defogging ..................................... 3-4
Defrosting ..................................... 3-4
Dimensions. Vehicle ............................ 6-66
Dolby B Noise Reduction ................... 3.11. 3.14
Dome Lamp Bulb Replacement .................... 6-41
DoorLocks ..................................... 2-4
DriverPosition ................................. 1-13
Driving
Backing Up
When Towing a Trailer ............ 4-39
City ........................................ 4-21
Defensive .................................... 4-2
Drunken ..................................... 4-3
Freeway .................................... 4-22
InaBlizzard ................................. 4-28
In Foreign Countries ........................... 6-5
IntheRain .................................. 4-18
Making Turns When Towing a Trailer ............. 4-40
Night ...................................... 4-16
OnCurves .................................. 4-11
On Grades While Towing a Trailer ............... 4-41
On Hill and Mountain Roads .................... 4-24
On Snow and Ice ............................. 4-27
Passing When Towing a Trailer .................. 4-39
Throughwater ............................... 4-20
WetRoads .................................. 4-18
Winter ...................................... 4-26
WithaTrailer ................................ 4-39
DrunkenDriving ................................ 4-3
Following Distance When Towing a Trailer ........ 4-39
9-3