1998 MITSUBISHI MONTERO distributor

reset sun roof seat memory center console tire type steering gas mileage

Page 13 of 1501

$MITSUBISHI MONTERO 1998 Service Manual Fig. 16: Connecting Rod Identification Location (Montero) Courtesy of Mitsubishi Motor Sales of America. ENGINE OILING OIL PUMP SPECIFICATIONS\ \$

Page 14 of 1501

$MITSUBISHI MONTERO 1998 Service Manual Accessory Mount Stay Bolt (Montero) 8 mm Bolt .............................................. 17 (23)\ 10 mm Bolt ............................................. 36 (49)\ Cooling Fan Br$

Accessory Mount Stay Bolt (Montero)
8 mm Bolt .............................................. 17 (23)\
10 mm Bolt ............................................. 36 (49)\
Cooling Fan Bracket (Montero) ............................ 30 (41\
)
Engine Hanger (Montero) .................................. 13 (17\
)
Generator Bolt (Diamante) ................................ 15 (21\
)
Generator Bolt (Montero)
8 mm Bolt .............................................. 15 (21)\
10 mm Bolt ............................................. 38 (51)\
Generator Bracket (Diamante)
8 mm Bolt .............................................. 35 (48)\
10 mm Bolt ............................................. 17 (23)\
Generator Pivot Nut (Diamante) ........................... 32 (44\
)
Tensioner Pulley Nut ..................................... 37 (50)\
Tensioner Bracket Stay Bolt (Montero) .................... 18 (24\
)
Intake Manifold & Fuel
Bracket (Montero) ........................................ 18 (24\
)
ECT Sensor ............................................... 22 (30)\
Intake Manifold Nut ...................................... 15 (21)\
Thermostat Case .......................................... 14 (19)\
Water Inlet Fitting Bolt ................................. 14 (19)\
Water Outlet Fitting Bolt ................................ 14 (19)\
Water Passage (Montero) .................................. 14 (19\
)
Heater Pipe Bolt (Diamante) .............................. 13 (18\
)
Intake Plenum & Throttle Body
Air Intake Fitting Bolt & Nut (Montero) .................. 13 (18\
)
EGR Pipe Bolt ............................................ 13 (18)\
EGR Pipe Flair Nut ....................................... 44 (59)\
EGR Valve Bolt ........................................... 16 (22)\
Intake Manifold Plenum (Diamante) ........................ 13 (18\
)
Intake Manifold Plenum Stay Bolt
8 mm Bolt .............................................. 13 (18)\
10 mm Bolt ............................................. 27 (36)\
Water Outlet Fitting Bracket Bolt ........................ 14 (19)\
Bracket (Diamante) ....................................... 18 (24\
)
Motor Mount Brackets
Bracket
8 mm Bolt .............................................. 16 (22)\
10 mm Bolt ............................................. 30 (41)\
12 mm Bolt ............................................. 55 (75)\
Oil Pan & Oil Pump
Drain Plug ............................................... 30 (40)\
Oil Cooler By-Pass Valve (Montero) ....................... 41 (55\
)
Oil Filter Bolt (Montero) ................................ 15 (21\
)
Oil Filter Bracket
8 mm Bolt .............................................. 18 (24)\
10 mm Bolt ............................................. 30 (40)\
Oil Screen
8 mm Bolt ............................................... 14 (19)\
Plug .................................................... 33 (45)\
Piston & Connection Rod
Connecting Rod Cap Nut ................................... 38 (52)\
Rocker Arms & Camshafts
Distributor Adapter Bolt (Diamante) ...................... 17 (23\
)
Rocker Arm Shaft Bolt .................................... 23 (31)\
Spark Plug ................................................. 18 (25)\
Timing Belt
Auto Tensioner Bolt ...................................... 18 (24)\
Camshaft Sprocket Bolt ................................... 65 (88)\
Idler Pulley Bolt ........................................ 32 (44)\
Tensioner Arm Bolt ....................................... 32 (44)\
Tensioner Pulley Bolt .................................... 36 (49)\
Water Pump Bolt (Montero) ................................ 18 (24\
)

Page 20 of 1501

MITSUBISHI MONTERO 1998 Service Manual instrument panel.

(
2) - See Figs. 1 and 2.

(
3) - Engine ID is eighth character of VIN.

Page 26 of 1501

$MITSUBISHI MONTERO 1998 Service Manual �\ \ \ \ \ \ \ ABBREVIATION DEFINITION$

\
\
\
\
\
\
\

ABBREVIATION DEFINITION

\
\b\
\
\
\
\
\

B/P Backpressure

BAC By-Pass Air Control

BAP Barometric Absolute Pressure Sensor

BARO Barometric

BBDC Before Bottom Dead Center

BCM Body Control Module

BDC Bottom Dead Center

BHP Brake Horsepower

BLK Black

BLU Blue

BMAP Barometric & Manifold Absolute Pressure Sensor

BOO Brake On-Off Switch

BP Barometric Pressure sensor

BPS Barometric Pressure Sensor

BPT Backpressure Transducer

BRN Brown

BTDC Before Top Dead Center

BTU British Thermal Unit

BVSV Bimetallic Vacuum Switching Valve

Baro. Barometric

Batt. Battery

Bbl. Barrel (Example: 4-Bbl.)

Blst. Ballast

Blwr. Blower

Brkr. Breaker

\
\
\
\
\
\
\
\f

"C" ABBREVIATION TABLE
"C" ABBREVIATION TABLE\
\
\
\
\
\
\

ABBREVIATION DEFINITION

\
\b\
\
\
\
\
\

C Celsius (Degrees)

C(3) I Computer Controlled Coil Ignition

C(4) Computer Controlled Catalytic Converter

CANP Canister Purge solenoid

CARB California Air Resources Board

CAT Catalytic Converter

CB Circuit Breaker

CBD Closed Bowl Distributor

CBVV Carburetor Bowl Vent Valve

cc Cubic Centimeter

CCC Computer Command Control

CCD Computer Controlled Dwell

CCM Central Control Module

CCO Converter Clutch Override

CCOT Cycling Clutch Orifice Tube

CCW Counterclockwise

CDI Capacitor Discharge Ignition

CEC Computerized Engine Control

CFI Central Fuel Injection

CID Cubic Inch Displacement

CID Cylinder Identification sensor

CIS Continuous Injection System

CIS-E Continuous Injection System-Electronic

CKT Circuit

CLR Clear

CNG Compressed Natural Gas

Page 27 of 1501

MITSUBISHI MONTERO 1998 Service Manual CO Carbon Monoxide

CO2 Carbon Dioxide

CONV Convertible

CO Carbon Monoxide

CO2 Carbon Dioxide

CONV Convertible

CP Canister Purge

CPA Connector Position Assurance

CPS Crank Position Sensor

CTS Coolant Temperature Sensor

CV Check Valve or Constant Velocity

CVC Constant Vacuum Control

CW Clockwise

CYL or Cyl. Cylinder

Calif. California

Carb. Carburetor

Chrg. Charging

Circ. Circuit

Cntrl. Control

Comp. Compressor or Compartment

Conn. Connector

Cont. Continued

Conv. Convertible or Converter

Cu. In. Cubic Inch

Cyl. Cylinder

\
\
\
\
\
\
\
\f

"D" ABBREVIATION TABLE
"D" ABBREVIATION TABLE\
\
\
\
\
\
\

ABBREVIATION DEFINITION

\
\b\
\
\
\
\
\

"D" Drive

DBC Dual Bed Catalyst

DC Direct Current or Discharge

DDD Dual Diaphragm Distributor

DERM Diagnostic Energy Reserve Module

DFI Digital Fuel Injection

DIC Driver Information Center

DIS Direct Ignition System

DIS Distributorless Ignition System

DIST Distribution

DISTR Distributor

DK BLU Dark Blue

DK GRN Dark Green

DME Digital Motor Electronics (Motronic System)

DOHC Double Overhead Cam

DOT Department of Transportation

DP Dashpot

DRB-II Diagnostic Readout Box

DVOM Digital Volt/Ohm Meter (see VOM)

Def. Defogger or Defroster

Def. Defrost

Defog. Defogger

Diag. Diagnostic

Dist. Distributor or Distribution

Dr. Door

\
\
\
\
\
\
\
\f

"E" ABBREVIATION TABLE
"E" ABBREVIATION TABLE\
\
\
\
\
\
\

ABBREVIATION DEFINITION

Page 28 of 1501

$MITSUBISHI MONTERO 1998 Service Manual \ \b\ \ \ \ \ \ EAC Electric Assist Choke$

\
\b\
\
\
\
\
\

EAC Electric Assist Choke

EACV Electric Air Control Valve

EBCM Electronic Brake Control Module

ECA Electronic Control Assembly

ECAT Electronically Controlled Automatic Transaxle

ECM Electronic Control Module

ECT Engine Coolant Temperature Sensor

ECU Electronic Control Unit or Engine Control Unit

EDF Electric Drive Fan relay assembly

EDIS Electronic Distributorless Ignition System

EEC Electronic Engine Control

EECS Evaporative Emission Control System

EEPROM Electronically Erasable PROM

EFE Early Fuel Evaporation

EFI Electronic Fuel Injection

EGO Exhaust Gas Oxygen sensor (see HEGO)

EGR Exhaust Gas Recirculation system

EGRC EGR Control solenoid or system

EGRV EGR Vent solenoid or system

EMR Emission Maintenance Reminder Module

ESA Electronic Spark Advance

ESC Electronic Spark Control

EST Electronic Spark Timing

ETR Emergency Tensioning Retractor

EVAP Fuel Evaporative System

EVIC Electronic Vehicle Information Center

EVO Electronic Variable Orifice

EVP EGR Valve Position Sensor

EVR EGR Valve Regulator

EVRV Electronic Vacuum Regulator Valve

Elect. Electronic

Eng. Engine

Evap. Evaporative

Exc. Except

\
\
\
\
\
\
\
\f

"F" ABBREVIATION TABLE
"F" ABBREVIATION TABLE\
\
\
\
\
\
\

ABBREVIATION DEFINITION

\
\b\
\
\
\
\
\

F Fahrenheit (Degrees)

F/B Fuse Block

FBC Feedback Carburetor

FI Fuel Injector or Fuel Injection

FICD Fast Idle Control Device

FIPL Fuel Injector Pump Lever

FP Fuel Pump

FPM Fuel Pump Monitor

FPR-VSV Fuel Pressure Regulator Vacuum Switching Valve

FWD Front Wheel Drive

Fed. Federal

Ft. Lbs. Foot Pounds

\
\
\
\
\
\
\
\f

"G" ABBREVIATION TABLE
"G" ABBREVIATION TABLE\
\
\
\
\
\
\

ABBREVIATION DEFINITION

Page 255 of 1501

$MITSUBISHI MONTERO 1998 Service Manual ��\ ��\ ��\ ��\ ��\ ��\ �� Application ( 1) Basic ( 2) ( 3) ( 4) Actual$

\
\
\
\
\
\

Application ( 1) Basic ( 2) ( 3) ( 4) Actual
1.5L ............. 2-78@ 650-750 .......... 10 @ 600-800
1.8L ............. 2-8 @ 600-800 ........... 5 @ 600-800
2.0L
Non-Turbo ........... ( 5) ........................ ( 5)
Turbo .......... 2-8 @ 650-850 ........... 8 @ 650-850
2.4L ............. 2-8 @ 650-850 .......... 10 @ 650-850
3.0L ............. 2-8 @ 600-800 .......... 15 @ 600-800
3.5L ............. 2-8 @ 600-800 .......... 15 @ 600-800
( 1) - With ignition timing adjustment connector grounded or
vacuum hose (farthest from distributor) disconnected.
( 2) - With ignition timing adjustment connector ungrounded
or vacuum hose (farthest from distributor) connected.
( 3) - If vehicle altitude is more than 2300 feet above sea
level, actualtiming may be advanced (5 degrees).
( 4) - Actual ignition timing is approximate and may
fluctuate plus or minus 7 degrees.
( 5) - Ignition timing is NOT adjustable.
\
\
\
\
\
\

FUEL SYSTEM
FUEL PUMP
REGULATED FUEL PRESSURE TABLE\
\
\
\
\
\

At Idle w/Vacuum At Idle w/o Vacuum
Application psi (kg/cm) psi (kg/cm)
Eclipse 2.0L
Non-Turbo ............ ( 1) ........... 47-50 (3.3-3.5)
Turbo ............. 33 (2.3) ......... 42-45 (3.0-3.5)
3000GT Turbo ........ 34 (2.4) ......... 43-45 (3.0-3.1)
All Other Models .... 38 (2.7) ......... 47-50 (3.3-3.5)
( 1) - Information is not available from manufacturer at time
of publication.
\
\
\
\
\
\

IDLE SPEED
IDLE SPEED SPECIFICATIONS TABLE\
\
\
\
\
\

Application Curb Idle Basic Idle
1.5L & 1.8L ............ 600-800 ............... 650-750
2.0L
Non-Turbo ............ 700-900 ................... ( 1)
Turbo ................ 650-850 ............... 700-800
2.4L ................... 650-850 ............... 700-800
3.0L & 3.5L ............ 600-800 ............... 650-750
( 1) - Information is not available from manufacturer at time
of publication.
\
\
\
\
\
\

INJECTOR RESISTANCE
INJECTOR RESISTANCE TABLE

Page 332 of 1501

MITSUBISHI MONTERO 1998 Service Manual distributor.
2) Start engine and warm engine until engine temperature
coolant is 176-203
�F (80-95�C). Turn engine off. Insert a paper clip
in engine speed detection connector terminal No. 3.

Load next 8 pages

Page: 1-8 9-16 17-24 25-32 33-40 ... 48 next >

washer fluid phone android auto glove box height adjustment hood open