1997 GMC SIERRA radiator

Composite Headlamps
1. Remove the two screws
at the top
of the
radiator support.
2. Pull the headlamp lens assembly out.
3. Unplug the electrical connector.
4. Turn the bulb
counterclockwise and remove it.
5. Put the new bulb into the lens assembly and turn it to
6. Plug in the electrical connector.
the
right until it
is tight.
7. Put the headlamp lens assembly back into the
vehicle. Install and tighten
the two screws.
ProCarManuals.com

Short TripKity Maintenance Schedule =- Gasoline Engines
100,000 Miles (166 000 km) (Continued)
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, the fluid and filter do not
require changing.
Manual transmission fluid doesn’t
require change.
valve.
An Emission Control Service.
0 Inspect Positive Crankcase Ventilation (PCV)
DATE ACTUAL MILEAGE SERVICED BY:
I I I I
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system
(or every
60 months since last service,
whichever occurs first). See “Engine
Coolant’’ in the Index for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test cooling
system and pressure cap.
An Emission Control Service.
7-30
ProCarManuals.com

Long Tripmighway Maintenance Schedule -- Gasoline Engines
100,000 Miles (166 000 km) (Continued)
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, the fluid and.filter do not
require changing.
Manual transmission fluid doesn’t
require change.
0 Inspect Positive Crankcase Ventilation
(Pcv) valve. An Emission Control Service.
DATE ACTUAL MILEAGE
~~
SERVICED BY
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system
(or every
60 months since last service,
whichever occurs first). See “Engine
Coolant” in the Index for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test the cooling system and pressure cap.
An Emission Control Service.
1
DATE ACTUAL MILEAGE SERVICED BY
-
ProCarManuals.com

Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall). You should let your GM dealer’s
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found
in a GM service manual. See “Service and Owner
Publications’’
in the Index.
Steering and Suspension Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines
and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system.
Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which could
cause
a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. See “Engine Exhaust”
in the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed.
Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding,
and for damaged or missing parts. Replace parts as
needed. Replace any cables that have high effort
or
excessive wear. Do not lubricate accelerator and cruise
control cables.
ProCarManuals.com

Garage Door Opener ............................ 2-52
GAWR
....................................... 4-41
Gear Positions. Automatic Transmission
............. 2- 15
Gear Positions. Manual Transmission .......... 2- 19. 2-20
GloveBox
.................................... 2-52
Gross Axle Weight Rating
........................ 4-41
Gross Vehicle Weight Rating ...................... 4-41
Guide
en Fransais 11
GVWR ....................................... 4-41
.. .................................
Halogen Bulbs ................................ 6-39
Hazard Warning Flashers
.......................... 5-2
Head Restraints
................................. 1-6
Headlamps .................................... 2-43
Bulb Replacement
....................... 6.40. 6.41
HigWLow Beam Changer
...................... 2-37
OnReminder
................................ 2-44
Wiring
..................................... 6-70
Hearing Impaired. Customer Assistance
.............. 8-4
Heating
........................................ 3-4
High-Beam Headlamps
.......................... 2-37
Highway Hypnosis
.............................. 4-35
Hill and Mountain Roads
......................... 4-35
Hitches. Trailer
................................. 4-53
Hood Checking Things Under
......................... 6-8
Release
...................................... 6-9
Hydraulic Clutch Fluid
........................... 6-26
Hydroplaning
.................................. 4-3 1
Horn
......................................... 2-35 Ignition
Positions
.............................. 2-11
Ignition Transmission Lock Check
................. 7-48
Illuminated Entry
............................... 2-46
Inflation. Tire
.................................. 6-51
Inside Daymight Rearview Mirror
................. 2-48
Inspections
.................................... 7-49
Brake System
................................ 7-50
DriveAxle
.................................. 7-50
Exhaust Systems
............................. 7-49
Radiator and Heater Hose
...................... 7-49
Steering
.................................... 7-49
Suspension
.................................. 7-49
Throttle Linkage
.............................. 7-49
Transfer Case (Four-wheel Drive)
............... 7-50
Instrumentpanel
............................... 2-62
Cleaning
.................................... 6-63
Cluster
..................................... 2-64
FuseBlock
.................................. 6-71
Intensity Control
............................. 2-46
Interior Lamps
................................. 2-46
.................................... J ack. Tire 5-23
Jump Starting
................................... 5-3
Key Lock Cylinders Service
..................... 7-46
Key Release Button
............................. 2-12
Keyless Entry System
............................ 2-7
Keys
.......................................... 2-2
9-5
ProCarManuals.com

Methanol ...................................... 6-4
Mirrors
....................................... 2-48
Convex Outside
.............................. 2-51
Electrochromic Daymight Rearview
.............. 2-48
Inside Daymight Rearview
..................... 2-48
Manual
..................................... 2-51
Power Remote Control
......................... 2-5 1
MMT ......................................... 6-4
Model Reference
................................. vi
MountainRoads ................................ 4-35
New Vehicle Break-In
.......................... 2- IO
Nightvision ................................... 4-28
Noise Control System
........................... 6- 14
Normal Maintenance Replacement Parts
............. 6-77
Odometer
.................................... 2-65
Odometer. Trip
................................. 2-65
Off-Road Driving
.............................. 4- 14
Off-Road Recovery
............................. 4- I 1
Oil. Engine .................................... 6-15
Opener. Garage Door
............................ 2-52
Overheating Engine
............................. 5- 1 I
Owner Checks and Services ....................... 7-45
Owner Publications. Ordering
................ 8- I I. 8- 12
Paint Spotting. Chemical ........................ 6-67
Park. Shifting Into
.............................. 2-28
Park. Shifting Out of
............................ 2-30
Parking
AtNight
.................................... 2-10 Brake
...................................... 2-27
Brake Mechanism Check
....................... 7-48
Lots
....................................... 2-10
Over Things That Burn
........................
Passenger Position .............................. 1-23
Passing
....................................... 4-12
Periodic Maintenance Inspections
.................. 7-49
Power Accessory Outlet
............................. 2-61
DoorLocks
................................... 2-6
Driver’sSeat
................................. 1-3
Option Fuses ................................ 6-70
Remote Control Mirror
........................ 2-51
Steering
..................................... 4-9
Steering
Fluid ................................ 6-33
Take-0
ff .................................... 4-59
Winches
.................................... 4-59
Windows ................................... 2-33
Pregnancy, Use of Safety Belts
.................... 1-22
Problems on the Road
............................ 5-1
PTO ......................................... 4-59
Publications, Service and Owner
.............. 8- 1 1, 8- 12
Radiator ..................................... 5-18
Radiator Pressure Cap
........................... 6-32
Radio Reception ................................ 3-23
Radios
........................................ 3-7
Rain, Driving
In ................................ 4-29
ReadingLamps
................................ 2-46
9-7
ProCarManuals.com