1997 FORD EXPLORER brakes

Trailer weight range
The range is between zero and the
maximum trailer weight rating
found in this chapter.
Using trailer brakes
Use electric brakes or manual,
automatic or surge type hydraulic
brakes that meet Federal and local
regulations. Install and adjust
brakes according to the
manufacturer's instructions.
Do not connect a trailer's
hydraulic brake system
directly to your vehicle's brake
system. Your vehicle may not
have enough braking power and
your chances of having a
collision greatly increase.
Using safety chains
Always connect the trailer's safety
chains to the vehicle. To connect
the chains, cross the chains under
the trailer tongue and attach to the
vehicle frame or hook retainers
(not the bumper). Make sure there
is enough slack to allow the vehicle
to turn corners.
Using trailer lamps
See your local trailer retailer or
rental agency for proper
instructions and equipment for
hooking up trailer lamps.
Do not hook the trailer lights
directly into the vehicle's wiring
system. If the trailer lamps are not
uno_brakes_trailer
uno_safety_chains
uno_lamps_trailer
Driving
143

CHECKING AND ADDING
BRAKE FLUID
Brake fluid should be checked and
refilled as needed at least once
each year:
²Clean the reservoir cap before
removal to prevent dirt or water
from entering the reservoir.
²Visually inspect the fluid level.
²If necessary, add brake fluid
until the level reaches MAX. Do
not fill above this line.
²Use only a DOT 3 brake fluid
certified to meet Ford
specifications. Refer to
Lubricant specificationsin the
Capacities and specifications
chapter.
Brake fluid is toxic.
If you use a brake fluid
that is not DOT 3, you will
cause permanent damage to your
brakes.
Do not let the reservoir for
the master cylinder run
dry. This may cause the brakes
to fail.
CHECKING AND ADDING
CLUTCH FLUID (IF EQUIPPED)
The clutch on your vehicle is
self-adjusting and should not
require any routine service.
MAX
MIN
uno_checking_adding_clutch
Maintenance and care
177

CLEANING AND CARING FOR
YOUR VEHICLE
Refer to the ªCustomer Assistance
Guideº for a list of Ford-approved
cleaners, polishes and waxes.
Washing your vehicle
Wash your vehicle regularly with
cold or lukewarm water. Never use
strong detergents or soap. If your
vehicle is particularly dirty, use a
quality car wash detergent. Always
use a clean sponge, washing glove
or similar device and plenty of
water for best results. To avoid
spots, avoid washing when the
hood is still warm, immediately
after or during exposure to strong
sunlight.
During winter months, it is
especially important to wash the
vehicle on a regular basis. Large
quantities of dirt and road salt are
difficult to remove, and they also
cause damage to the vehicle.
Remove any exterior accessories,
such as antennas, before entering
a car wash.
²After washing, apply the brakes
several times to dry them.
Waxing your vehicle
The best way to determine when
the paintwork needs waxing is by
noting when water stops beading
on the surface. This could be every
three or four months, depending
on operating conditions.
Use only carnauba or
synthetic-based waxes. Remove
com_washing_vehicle.01
com_waxing_vehicle.01
Maintenance and care
215

Air bag supplemental restraint
system
and child safety seats ..............90
description ................................89
disposal ......................................94
indicator light ...........................93
passenger air bag .....................91
Air cleaner filter .......................192
replacing ..................................193
Air conditioning
manual heating and air
conditioning
system ...................28,29,30,31,32
Air suspension ...........................119
All wheel drive (AWD) .............134
Anti-theft system ........................65
arming the system ....................66
disarming a triggered system ..68
disarming an untriggered
system .......................................68
warning light .............................67
Autolamp system (see
Headlamps) .................................49
Automatic dimming mirror ...47,48
Battery .......................................188
battery saver ...........................192
servicing ....................188,189,190
Brakes
adjustment ..............................117
anti-lock ...................................117
fluid, checking and adding ....177
parking ....................................118
Break-in period .............................2
Built-in child seat .......102,107,108
Bulbs,
replacing ........208,210,211,212,213
specifications ..........................213
Capacities for refilling fluids ....225
Cargo area shade ........................64
Childproof locks ..........................55
Cleaning your vehicle ...............215
built-in child seat ...................220engine compartment ..............216
fabric ........................................219
instrument panel ....................219
plastic parts ............................218
safety belts ..............................220
tail lamps .................................218
washing ....................................215
waxing .....................................215
wheels ......................................216
Climate control system ..............28
automatic temperature
control ...................32,33,34,35,36
defrosting .............................59,60
Clutch
fluid ..........................................177
Compass, electronic ....................50
calibration .................................51
set zone adjustment .................51
Console, description ..............58,61
Control trac 4WD system .........128
Controls ..................................58,59
Coolant (see Engine coolant)
proper solution .......................181
Daytime running light system ...26
Differential fluid ........................187
Driveline universal joint and
slip yoke .............................176,187
Driving under special
conditions ..................................130
high water ...............................131
slippery roads ..................132,133
towing a trailer .......................144
Emission control system ..........206
Engine .................................228,231
service points ............170,171,172
Engine block heater .................116
Engine coolant
checking and adding .......180,183
checking hoses .......................184
disposal ....................................182
refill capacities ........................182
Index
233

Engine oil
changing oil and oil filter .......175
specifications ..........................173
Entry system
illumination ...............................66
Exhaust fumes ..........................112
Flashing the lights ......................45
Floor mats ..............................62,63
Foglamps .....................................27
Ford Extended Service Plan ....129
Four way head restraints ...........78
Four-Wheel Drive vehicles
control trac ........................38,128
driving off road .......................130
Fuel ............................................202
calculating fuel economy .......206
improving fuel economy ........146
octane rating ...........................204
quality ......................................205
safety information relating to
automotive fuels .....................202
Fuel gauge ...................................15
Fuel pump shut-off switch .......147
Fuses ..........................................148
Gauges, Mechanical
engine coolant temperature
gauge .........................................13
engine oil pressure gauge ........13
Hazard flashers ....................44,147
Head restraints ...........................78
Hitch ..........................................144
Hood ..........................................169
Identification Number, Vehicle
(VIN) ..........................................230
Ignition
positions of the ignition ...........39
Jack ..............................................63
Jump-starting your vehicle 160,162
attaching cables ......................161
disconnecting cables ..............162
Keyless entry system
autolock .....................................76keypad .......................................74
locking and unlocking doors ....74
programming entry code .........75
Lamps
instrument panel, dimming .....26
Liftgate ........................................57
Lights, warning and indicator
air bag ........................................11
anti-lock brakes (ABS) ............11
anti-theft .....................................9
brake ..........................................11
charging system ........................10
check engine ...............................9
door ajar ....................................10
four-wheel drive ..........................9
fuel reset ...................................10
high beam .................................11
overdrive off ................................8
safety belt .......................11,87,88
Luggage rack .............................146
Manual transmission
driving .......................121,125,127
fluid, checking and adding ....187
Message center ..16,17,18,19,20,52
air ride switch off .....................21
change oil soon .........................21
check air ride system ...............20
check charging system .............22
check engine temperature .......22
check exterior lamps ................22
door ajar ....................................24
low fuel level .............................24
low oil level ...............................24
low washer fluid .......................24
warning messages .....................20
Moon roof ....................................54
Motorcraft parts ........................222
Odometer .....................................14
Overdrive ................................45,46
Overhead console
storage compartment ...............52
Parking brake ..............................28
Index
234

Power door locks ........................54
Power steering
fluid, checking and adding ....184
Rear window
wiper .....................................37,38
Refill capacities for fluids ........223
Relays ..........................149,150,153
Remote entry system .................69
locking/unlocking doors ......69,70
panic alarm ...............................70
replacement/additional
transmitters ...............................73
replacing the batteries .............72
Reporting safety defects ..........232
Restraints, safety (see Safety
restraints)
head ...........................................78
Safety restraints
adjusting the safety belts ....86,87
energy absorbing sew
pattern ..................................88,89
for children ...............................95
proper use ..................83,84,85,86
Safety seats for children
attaching with tether straps ..101
automatic locking mode
(retractor) ............................97,98
Seats ............................................79
adjusting the seat, power ........80
bench (60-40 split) ..................79
Servicing your vehicle ..............165
precautions when servicing ...165
servicing when you tow .........145
Snowplowing .................................4
Special notice ................................3
ambulance conversions ..............3
utility-type vehicles ....................3
Specification chart, lubricants .225
Speed control ..............................40
indicator light ........................8,43
Speedometer ...............................14
Starting your vehicle ................110preparing to start your
vehicle .....................................112
starting a warm engine ..........115
Steering wheel
tilting .........................................44
Storage compartments
overhead storage
compartment .............................52
Tachometer
mechanical cluster ...................15
Tires
changing ..................................156
checking the pressure ............197
inspection and maintenance ..195
replacing ..................................199
rotating ....................................198
snow tires and chains ............201
spare tire .................................156
tire grades ...............................195
treadwear ................................196
Traction-lok rear axle ...............119
Trailer towing ............................138
safety chains ...........................143
tips ....................................139,144
trailer brakes ...........................143
trailer lamps ............................143
Transfer case (see Differential
fluid) ..........................................188
Transmission
fluid, checking and adding
(automatic) .............................186
Trip odometer .............................14
Turn signal
indicator lights ............................9
Two step lock ..............................54
Vehicle dimensions ...................228
Vehicle headlamp aiming
device (VHAD) .........................214
Vehicle Identification Number
(VIN) ..........................................230
Ventilating your vehicle ...........111
Index
235