1997 FORD AEROSTAR wheel

255 %
*
[MC26500(ALL)01/96]
Tire Rotation
*
[MC26600(ALL)01/96]
Because your vehicle's front and rear tires
perform different jobs, they often wear
differently. To make sure your tires wear evenly
and last longer, rotate them as indicated in the
following diagram.
*
[MC26700(ALL)05/96]
For tire rotation intervals, see theMaintenance
Schedulebooklet. If you notice that the tires wear
unevenly, have them checked.
*
[MC26750(ALL)03/96]
In situations where the tires differ from front to
rear (snow/traction), simply rotate using a side
to side pattern.
*
[MC26800(ALL)01/96]
half page art:0020364-A
Tire rotation pattern
*
[MC26900(ALL)03/96]
After each rotation, adjust individual tire
pressure as specified on the Safety Compliance
Certification Label. Tighten wheel lug nuts to the
required torque specification and retighten again
after 500 miles (800 km).
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

256
*
[MC27000(ALL)03/96]
If your vehicle has aluminum wheels, you may
demount the full size, non-temporary spare
tire (if so equipped) and remount on an
aluminum wheel to rotate the spare tire into
your vehicle's rotation pattern. Rebalance the
wheel.
[MC27100(ALL)04/96]
You may discover uneven outside shoulder wear
on your vehicle's front radial tires if you drive
often in the city and turn frequently around
curbs. You can extend the life of your front tires
by remounting them so the outside of the tire
faces inside on the wheel rim.
%*
[MC27300(ALL)01/96]
Replacing the Tires
*
[MC27400(ALL)01/96]
Replace any tires that show wear bands. When
your tire shows a wear band, it has only 1/16
inch (2 mm) of tread left.
*
[MC27500(ALL)01/96]
quarter page art:0060006-A
Wear band
*
[MC27600(ALL)02/96]
Because your vehicle's tires may wear unevenly,
you may need to replace them before a wear
band appears across the entire tread.
*
[MC27700(ALL)03/96]
Your wheels and tires are match-mounted for
improved ride. Before you begin to repair a tire,
mark the wheel and tire so that they are
properly aligned when remounted. This will
ensure that the tires will continue to give you
the same ride level.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

258 [MC28100(ALL)01/96]
three fourths page art:0020366-ETire identification chart
*
[MC28700(ALL)03/96]
RWARNING
Use of aftermarket wheel assemblies may
damage your vehicle or cause accidents
resulting in serious injuries.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

259 %
*
[MC28800(ALL)03/96]
Wheel and Tire Matching
*
[MC28950(ALL)03/96]
See an authorized tire dealer for proper
servicing procedures. Wheels and tires must be
properly removed, matched and remounted to
maintain the best possible ride.
%*
[MC31100(ALL)01/96]
Snow Tires and Chains
*
[MC31200(ALL)03/96]
The tires on your vehicle have all-weather treads
that provide traction in rain or snow. However,
during the winter months in some climates, you
may need to use snow tires and occasionally
chains for your tires.
*
[MC31300(ALL)01/96]
RWARNING
Snow tires must be the same size and
grade as the tires you currently have on
your vehicle.
*
[MC31400(ALL)01/96]
Do not use chains when using a temporary
spare. For full size tires, use chains on the tires
only in an emergency or if the law requires
them where you live. When you use the tire
chains:
*
[MC31500(ALL)01/96]
q
Make sure the chains are the right size for
your tires. Use only SAE Class ªSº chains.
Other types may damage your vehicle.
*
[MC31550(ALL)01/96]
q
Tire chains may scratch or chip aluminum
wheels. IT IS RECOMMENDED THAT TIRE
CHAINS ARE INSTALLED ON STEEL
WHEELS ONLY. Be sure to remove wheel
covers (if equipped) from steel rims before
using tire chains to avoid scratches or
damage.
*
[MC31575(ALL)01/96]
q
Local regulations may prohibit or restrict the
use of tire chains. Investigate the laws and
regulations in your area before installing
chains.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

261 %
*
[MC35200(ALL)01/96]
Opening the Fuel Filler Door
[MC35300(ALL)01/96]
Fuel filler door remote release
[MC35400(ALL)05/96]
To open the fuel filler door latch, pull on the
release lever located between the driver's seat
and the door. You cannot open the fuel filler
door by pulling on the door itself.
[MC35500(ALL)01/96]
one third page art:0020353-B
Fuel filler door remote release lever
[MC35600(ALL)01/96]
If the release lever is stuck or damaged and you
cannot open the fuel filler door, you must use
the override cord located at the back of the left
rear wheelhouse. (On extended versions the
release lever is located in the stowage box.)
[MC35700(ALL)01/96]
The manual release cord is attached to a T
handle marked FUEL FILLER DOOR RELEASE
Ð MANUAL OVERRIDE. When you pull it, the
fuel filler door opens.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

281 %
*
[MC50110(ALL)01/96]
Cleaning Plastic Parts
*
[MC50120(ALL)01/96]
Some of your vehicle's exterior trim parts are
plastic. Clean with a tar and road oil remover if
necessary. Use a vinyl cleaner for routine
cleaning.
*
[MC50130(ALL)01/96]
Do not clean plastic parts with thinners, solvents
or petroleum-based cleaners.
%*
[MC50140(ALL)01/96]
If you have your vehicle rustproofed, remove
oversprayed rustproofing with a tar and road oil
remover. If rustproofing is not removed from
plastic and rubber parts, it can cause
deterioration.
%*
[MC50150(ALL)03/96]
Cleaning the Wheels
*
[MC50160(ALL)03/96]
Wash the wheels with the same detergent you
use to wash your vehicle's body. Do not use
acid-based wheel cleaners, steel wool, abrasives,
fuel, or strong detergents. These substances will
damage protective coatings. Use tar and road oil
remover to remove grease and tar.
*
[MC50170(ALL)03/96]
NOTE: Before going to a car wash, find out if
the brushes are abrasive.
*
[MC50180(ALL)03/96]
If you have whitewall tires that are difficult to
clean with regular detergent, use Ford Extra
Strength Whitewall Tire Cleaner or equivalent.
Follow the directions on the container and rinse
the tires with plenty of clean water.
%*
[MC50200(ALL)01/96]
Cleaning the Exterior Lamps
*
[MC50210(ALL)01/96]
Do not use dry paper towel, chemical solvents
or abrasive cleaners to clean the lamps, as these
may cause scratches or crack the lamps.
*
[MC50300(ALL)01/96]
Cleaning the Engine
*
[MC50310(ALL)01/96]
A clean engine is more efficient because a
buildup of grease and dirt acts as an insulator,
keeping the engine warmer than usual.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

284
*
[MC56600(ALL)01/96]
Body
*
[MC56700(ALL)01/96]
q
Wash vehicle thoroughly to remove dirt,
grease, oil, tar or mud from exterior surfaces,
rear wheel housing and underside of front
fenders.
*
[MC56800(ALL)01/96]
q
Periodically wash vehicles stored in exposed
locations.
*
[MC56900(ALL)01/96]
q
Touch-up raw or primed metal to prevent
rust.
*
[MC57000(ALL)01/96]
q
Cover chrome and stainless steel parts with a
thick coat of auto wax to prevent
discoloration. Re-wax as necessary when the
vehicle is washed.
*
[MC57100(ALL)01/96]
q
Lubricate all hood, door and trunk lid hinges
and latches with a light grade oil.
*
[MC57200(ALL)01/96]
q
Cover interior soft trim to prevent fading.
*
[MC57300(ALL)01/96]
q
Keep all rubber parts free from oil and
solvents.
%*
[MC57350(ALL)01/96]
Engine
*
[MC57400(ALL)01/96]
q
Start engine every 15 days. Run at fast idle
until it reaches normal operating temperature.
*
[MC57500(ALL)01/96]
q
With your foot on the brake, shift through all
the gears while the engine is running.
%*
[MC57600(ALL)01/96]
Fuel system
%*
[MC57700(ALL)01/96]
q
Fill fuel tank with high-quality unleaded fuel
until the first automatic shutoff of the fuel
pump nozzle.
*
[MC57900(ALL)01/96]
NOTE: During extended periods of vehicle
storage (60 days or more), fuel may
deteriorate due to oxidation. This can
damage rubber and other polymers in
the fuel system and may also clog
small orifices.
File:11cpmca.ex
Update:Fri Jun 7 14:30:56 1996

300
%*
[CS55000(ALL)01/96]
Your Vehicle Identification
Number (VIN)
*
[CS55100(ALL)04/96]
You should include your Vehicle Identification
Number (VIN) any time you write to Ford
Motor Company about your vehicle.
*
[CS55200(ALL)03/96]
The Vehicle Identification Number is attached to
your vehicle in the following places:
*
[CS55300(ALL)03/96]
q
on the metal tag attached to the top of the
instrument panel on the driver's side Ð you
can see the tag by looking through the
windshield from outside your vehicle.
*
[CS55400(ALL)03/96]
one inch art:0010558-A
Vehicle Identification Number (VIN/Serial Number)
%*
[CS55500(ALL)03/96]
q
on the Safety Compliance Certification Label
Ðthis label is attached to the left front door
lock facing or the door latch post pillar. It is
required by the National Highway Traffic
Safety Administration and is made of special
material. If someone tampers with it, it will
be destroyed and/or a destruction pattern
will appear.
*
[CS55600(ALL)01/96]
The label contains the name of the manufacturer,
the month and year of manufacture, the
certification statement and the Vehicle
Identification Number. The label also contains
Gross Vehicle Weight Rating and Gross Axle
Weight Ratings, wheel and tire data and
information codes for additional vehicle data.
For further information about the Safety
Compliance Certification Label and the
information contained on it, refer to the Index.
File:12cpcsa.ex
Update:Thu Jun 6 14:45:39 1996