1997 CHEVROLET CAVALIER power steering

Downloaded from www.Manualslib.com manuals search engine Engine Compartment Fuse Block
P
The engine compment fuse block is located on the
driver’s side of the engine compartment. Lift off the
cover to check the fuses.
Fuse
IGN
BATT
1
BATT 2
ABS
Usage
Ignition Switch Circuits
Power ACC/Stoplamp Circuits
Lighting Circuits
Electronic Variable Orifice Steering, Anti-Lock Brake System
COOLING FAN Engine
Cooling Fan
BLO Heater and A/C Blower
PCM Powertrain Control Module
AIC A/C Compressor
ABS/EVO Anti-Lock Brake System
GEN Gen Voltage Sensor (2.2L Engine)

Downloaded from www.Manualslib.com manuals search engine Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall).
You should let your GM dealer’s
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a
GM service manual. See “Service and Owner
Publications” in the Index.
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs
of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc. Clean and then inspect the drive axle boot seals for damage, tears or leakage. Replace
seals if necessary.
I
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system.
Look for broken, damaged,
missing
or out-of-position parts as well as open seams,
holes, loose connections or other conditions which could
cause a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. See “Engine Exhaust’’
in the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed.
Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding,
and for damage or missing parts. Replace parts as
needed. Replace any cables that have high effort or
excessive wear.
Do not lubricate accelerator and cruise
control cables.

Downloaded from www.Manualslib.com manuals search engine Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from your
GM dealer.
FLUID/LUBRICANT
Engine oil with the American
Petroleum Institute Certified For
Gasoline Engines “Starburst”
symbol
of the proper viscosity. To
determine the preferred viscosity
for your vehicle’s engine, see
“Engine Oil” in the Index.
50/50 mixture of clean water
(preferably distilled) and use only
GM Goodwrench@ DEX-COOL
TM
or Havoline@ DEX-COOL TM
coolant. See “Engine Coolant”
in
the Index.
USAGE
Coolant
Supplement
Sealer
Hydraulic Brake
System
Hydraulic Clutch
System
Power Steering System
Manual
Transaxle
Automatic
Transaxle
FLUID/LUBRICANT
GM Part No. 3634621 or
equivalent with a complete flush
and refill.
Delco Supreme 11
@ Brake Fluid
(GM Part
No. 12377967 or
equivalent DOT-3 brake fluid).
Hydraulic Clutch Fluid (GM
Part
No. 12345347 or equivalent
DOT-3 brake fluid).
GM Power Steering Fluid
(GM Part
No. 1052884 - 1 pint,
1050017
- 1 quart, or equivalent).
Synchromesh Transmission Fluid
(GM Part
No. 12345349
or equivalent).
DEXRON@-I11 Automatic
Transmission Fluid.

Downloaded from www.Manualslib.com manuals search engine Jack. Tire .................................... 5-25
Jump Starting
................................... 5-3
Key Lock Cylinders Service
..................... 7-43
Key Release Button
............................. 2-14
Keyless Entry System
............................ 2-6
Keys
.......................................... 2-2
Labels
....................................... 4-33
Certification
................................. 4-34
Service Parts Identification
..................... 6-58
Tire-Loading Information ...................... 4-33
Vehicle Identification Number
................... 6-58
Lamps
........................................ 2-41
Exterior
.................................... 2-41
Fog
........................................ 2-43
FrontReading
................................ 2-45
Interior
..................................... 2-44
Map
....................................... 2-45
OnReminder
................................ 2-42
Latches. Seatback
................................ 1-5
Leaving Your Vehicle
............................. 2-6
Leaving Your Vehicle with the Engine Running
....... 2-28
Lighter
....................................... 2-50
Lights Air Bag Readiness
..... i ................. 1-23. 2-68
Anti-Lock Brake System Warning
............ 2.70. 4.7
Brake System Warning
......................... 2-69
Charging System
............................. 2-69
CheckEngine
................................ 2-73
Enhanced Traction System Active
............ 2.72. 4.9
Enhanced Traction System Warning Light
..... 2.71. 4.9
CheckGages
................................ 2-77
ETS Active .............................. 2.72. 4.9
ETS Warning
............................ 2.71. 4.9
Interior
..................................... 2-44
Low Coolant Warning
......................... 2-73
Oil Pressure Warning
.......................... 2-76
Passlock
TM Warning ........................... 2-77
Safety Belt Reminder
...................... 1.8. 2.68
Loading Your Vehicle
........................... 4-33
Locks Cylinders
................................... 7-43
Door
........................................ 2-4
Key Lock Cylinder Service
..................... 7-43
Power Door
.................................. 2-5
Rear Door Security ............................. 2-5
Steering Column Lock Check
................... 7-44
Trunk
...................................... 2-10
Low Coolant Warning Light
...................... 2-73
Lowering the Convertible Top Manually
............. 2-59
Lowering Your Convertible Top
................... 2-52
Lubricants and Fluids
............................ 7-48
Lubrication Service. Body
........................ 7-43
Maintenance.
NO~Z~I Replacement parts ........... 6-64
Maintenance Record
............................ 7-50
Maintenance Schedule
............................ 7-1
Long Trip/Highway Definition
................... 7-6
Long TripMighway Intervals
..................... 7-6
Owner Checks and Services
..................... 7-41
Periodic Maintenance Inspections
................ 7-46
Recommended Fluids and Lubricants
............. 7-48
Scheduled Maintenance Services
.................. 7-3
Short TripKity Definition
....................... 7-5
Short TripKity Intervals
........................ 7-5
Up-Shift
............................... 2.25. 2.77

Downloaded from www.Manualslib.com manuals search engine Maintenance. Underbody ......................... 6-56
Maintenance When Trailer Towing
................. 4-43
Malfunction Indicator Lamp
...................... 2-73
Manual Front Seat
............................... 1-2
Manual Lumbar Support
.......................... 1-3
Manual Remote Control Mirror .................... 2-47
Manual Transaxle Check
...................................... 7-42
Fluid
....................................... 6-22
Gear Positions
............................... 2-23
Operation
................................... 2-23
Shifting
..................................... 2-23
Starting Your Engine
.......................... 2-14
Methanol
...................................... 6-5
Mirrors
....................................... 2-46
Convex Outside
.............................. 2-48
Inside Daymight Rearview
..................... 2-46
Manual Remote Control
........................ 2-47
Power Remote Control
......................... 2-47
MountainRoads
................................ 4-24
Multifunction Lever
............................. 2-33
Neutral. Automatic Transaxle
.................... 2-20
Neutral. Manual Transaxle
........................ 2-24
New Vehicle “Break-In”
......................... 2-12
Nightvision
................................... 4-17
Odometer
.................................... 2-66
Odometer. Trip
................................. 2-66
Off-Road Recovery
............................. 4- 12
Oil. Engine
.................................... 6-12
Oil Pressure Warning Light
....................... 2-76
Overdrive. Automatic Transaxle
................... 2-22 Overheating Engine
............................. 5-14
Owner Checks and Services
....................... 7-41
Owner Publications. Ordering
..................... 8-12
Paint Spotting. Chemical
........................ 6-56
Park
Automatic -:ansaxle
.......................... 2-19
Shifting Into
................................. 2-27
Shifting Out of
............................... 2-29
Parking AtNight
.................................... 2-11
Brake
...................................... 2-26
Brake Mechanism Check
....................... 7-45
Lots
....................................... 2-11
Over Things That Burn
........................ 2-30
With a Trailer
................................ 4-42
Your Vehicle. Manual Transaxle
................. 2-29
Passenger Position
.................... 1-22. 1-28. 1-33
Passing
....................................... 4-13
With a Trailer ................................ 4-40
Passlock
” .................................... 2-11
Periodic Maintenance Inspections
.................. 7-46
Power
DoorLocks
................................... 2-5
Option Fuses
................................ 6-59
Remote Control Mirror
........................ 2-47
Steering
............................... 4.10. 6.29
Windows
................................... 2-32
Pregnancy. Use of Safety Belts
.................... 1-21
Problems on the Road
............................ 5-1
Publications. Service and Owner
................... 8-12
Passlock”
Warning Light
........................ 2-77
Steering Fluid
................................ 6-29
9-7

Downloaded from www.Manualslib.com manuals search engine Safety Defects. Reporting ........................ 8-10
Safety Warnings and Symbols
....................... vi
Scheduled Maintenance Services .................... 7-3
Seatback Latches
...................................... 1-5
Reclining Front
............................... 1-4
Seats EasyEntry
................................... 1- 6
Manual Front
................................. 1-2
Manual Lumbar Support
........................ 1-3
Rear
........................................ 1-6
Restraint Systems
.............................. 1 - 1
Seatcontrols ................................. 1-2
Securing a Child Restraint
...................... 1-39
Second Gear. Automatic Transaxle
............ 2-21. 2-22
Second Gear. Manual Transaxle
................... 2-24
Security System
................................ 2- 11
Bulletins, Ordering
............................ 8- 12
Manuals, Ordering
............................ 8- 12
Parts Identification Label
....................... 6-58
Publications, Ordering
......................... 8- 12
Work, Doing Your Own
......................... 6-2
Service and Appearance Care
...................... 6-1
Service and Owner Publications
................... 8- 12
Publications. Ordering in Canada
................ 8-1 1
Service Publications ............................. 8- 12
Servicing Your Air Bag-Equipped Chevrolet
......... 1-27
Sheet Metal Damage
............................ 6-55
Shift Lever
............................... 2- 19, 2-23
Shiftspeeds
................................... 2-25
Shifting Automatic Transaxle
.......................... 2- 19
Service ........................................ 6-2 Into
Park (P)
................................. 2-27
Manual Transaxle
............................. 2-23
OutofPark
.................................. 2-29
Shoulder Belt Height Adjuster
..................... 1-16
Signaling Turns
................................ 2-34
Skidding
...................................... 4-14
Sound Equipment. Adding
........................ 3-23
Spare Tire. Compact
............................. 5-34
Specifications. Engine
........................... 6-64
Speech Impaired. Customer Assistance
............... 8-4
Speedometer
................................... 2-66
SRS
......................................... 1-22
Stains. Cleaning
................................ 6-50
Starter Switch Check
............................ 7-43
Starting Your Engine
.................. 2-14.2-15. 2- 16
Steam
........................................ 5-14
Steering
...................................... 4-10
In Emergencies
............................... 4-11
Power
................................. 4-10, 6-29
Tips
........................................ 4-10
Wheel, Tilt
.................................. 2-33
Storage Compartments
........................... 2-48
Storage, Vehicle
................................ 6-35
Stuck: In Sand, Mud, Ice or Snow
.................. 5-35
Sunvisors
.................................... 2-50
Sunroof
....................................... 2-51
Supplemental Restraint System
.................... 1-22
Surge Tank, Coolant
............................. 5-16
Surge Tank Pressure Cap
......................... 6-28 ...
Specifications and Capacities ...................... 6-63
Symbols, Vehicle
................................ vm