1997 CHEVROLET ASTRO head light

Downloaded from www.Manualslib.com manuals search engine This can cause deadly CO (carbon monoxide) gas
to get inside.
CO could overcome you and kill
you.
You can't see it or smell it, so you might not
know
it is in your vehicle. Clear away snow from
around the base
of your vehicle, especially any
that
is blocking your exhaust pipe. And check
around again from time
to time to be sure snow
doesn't collect there.
Open
a window just a little on the side.of the
vehicle that's
away from the wind. This will help
keep
CO out.
Run your engine only as long as you must. This saves
fuel. When you run the engine, make it go a little faster
than just idle. That is, push the accelerator slightly. This
uses less fuel for the heat that you get and it keeps the
battery charged. You will need a well-charged battery to
restart the vehicle,
and possibly for signaling later on
with your headlamps. Let the heater run for awhile.
Then, shut the engine
off and close the window almost
all the way to preserve the heat. Start the engine again
and repeat this only
when you feel really uncomfortable
from the cold. But do it as little as possible. Preserve the
fuel as long as you can.
To help keep warm, you can get
out
of the vehicle and do some fairly vigorous exercises
every half hour or
so until help comes.
4-27

Downloaded from www.Manualslib.com manuals search engine Headlamp Wiring
The headlamp wiring is protected by a circuit breaker in
the lamp switch. An electrical overload will cause the
lamps to
go on and off, or in some cases to remain off.
If this happens, have your headlamp wiring checked
right away.
Windshield Wiper Fuses
The windshield wiper motor is protected by a circuit
breaker and a fuse. If the motor overheats due
to heavy
snow, etc., the wiper will stop until
the motor cools. If
the overload is caused by some electrical problem and
not snow, etc., be sure
to get it fixed.
Power Windows and Other Power Options
Circuit breakers in the fuse panel protect the power
windows and other power accessories. When the current
load
is too heavy, the circuit breaker opens and closes,
protecting the circuit
until the problem is fixed or
goes away.
Fuses and Circuit Breakers
The wiring circuits in your vehicle are protected from
short circuits by a combination of fuses, circuit breakers
and fusible thermal links. This greatly reduces the
chance
of fires caused by electrical problems.
Look at the silver-colored band inside the fuse. If the
band
is broken or melted, replace the fuse. Be sure you
replace a bad fuse with a new one of the identical size
and rating.
Spare fuses and a fuse puller are located in the
underhood electrical center. You can remove fuses with
the fuse puller. Remember to replace
any of the spare
fuses
you use, so you will have some if you ever need
them again.
If you ever have a problem on the road and don’t have
a spare fuse,
you can “borrow” one that has the same
amperage. Just pick some feature of your vehicle that
you can get along without -- like the radio or cigarette
lighter
-- and use its fuse, if it is the correct amperage.
Replace
it as soon as you can.
There are two fuse blocks in your vehicle: one is inside
the vehicle and one is
in the engine compartment.
6-61

Downloaded from www.Manualslib.com manuals search engine FuseKircuit
Breaker
5 .........
6 .........
7 .........
8 .........
9 .........
10 ........
11 e. * e, e e.
12 ........
13 ........
14 ........
Usage
Not Used
Cruise Module, Cruise Control Switch
Power Outlets, DLC,
Subwoofer Amplifier
Starter Enable Relay
License Plate Lamp, Taillamps,
Parking Lamps, Ashtray Lamp, Panel
Lights, Trailer Taillamps, Front and
Rear Sidemarker Lamps, Door Switch
Illumination, Headlamp Switch
Illumination, Rear Seat Audio
Illumination
Air Bag System
Wiper Motor, Washer Pump,
Upfitter Relay Coil
L, MI,
M2 Blower Motor, Rear A/C
Relay Coil, Front Cont. Temp. Door
Motor, Hi Blower Relay, Defogger
Timer Coil
Cigarette Lighter, Door Lock Switches
Cluster HVAC Controls, Chime Module,
Radio Illumination, Rear Heat Switch
Illumination, Rear Wipermasher Switch
Illumination, Rear Liftgate Switch
Illumination, Remote Cassette Illumination,
OH Console
Fuse/Circuit
Breaker
15 ........
16 ........
17 ........
18 ........
19 ........
20 ........
21 ........
22 ........
23 ........
24 ........
A.........
B .........
Usage
DRL Diode
Front Turn Signals, Rear Turn Signals,
Trailer Turn Signals, Back-up Lamps,
BTSI Solenoid
Radio: ATC (Standby),
2000 Series
(Main Feed), Rear Seat Audio Controls
VCM-Ign
3, VCM- Brake, 4WAL,
Cruise Stepper Motol
Radio: ATC (Main Feed),
2000 Series (Standby)
PRNDLI Odometer, TCC Enable and
PWM Solenoids, Shift A and Shift B
Solenoids, 3-2 Downshift Solenoids
Not Used
Not Used
Rear Wiper, Rear Washer Pump
Not Used
(Circuit Breaker) Power Door Lock
Relay, 6-way Power Seat, Remote
Control Door Lock Receiver, Dutch
Door Module, Dutch Door Release
(Circuit Breaker) Power Windows
6-63

Downloaded from www.Manualslib.com manuals search engine FuseKircuit Breaker
UPFIT-BATT .......
UPFIT-IGN ........
Spare .............
Fuse Puller*
Spare
.............
Spare .............
ECM-B ............
HORN ............
A/C COMP .........
RR DEFOG ........
ENG-I ............
Usage
Upfitter Battery Power Stud,
Trailer Wiring Harness
Upfitter Ignition Relay
Not used
Not used
Not used
Fuel Pump Relay, VCM,
Oil Pressure Switch/Sender
Horn Relay
A/C Enable Relay
Heater-A/C Control Selector
Switch
Oxygen Sensors
1-4,
Camshaft Position Sensor,
Mass Air Flow Sensor,
Evaporative Emission
Canister Purge Solenoid
Valve, Linear EGR Valve
Solenoid,
VCM
FuseKircuit Breaker
IGN-E ............
ECM-I ......... ~.
LIGHTING ........
BATT .............
IGNA .............
IGN B .............
ABS ..............
A/C ...............
RR HTR/AC ........
Spare .............
Usage
A/C Enable Relay
Fuel Injectors 1-6,
Crankshaft Position Sensor,
VCM, Distributor Ignition
Control Module
Park Lamps Fuse, DRL Fuse,
Headlamp and Panel
Dimmer Switch
I/P Fuse Block Fuses, Power
Seat CB, Stop/Hazard Fuse,
Auxiliary Power Fuse,
Cigarette Lighter Fuse,
Radio, Battery Fuse
Starter Relay, Ignition Switch
Ignition Switch Brake Pressure Module Valve
Blower Motor Resistor,
Blower Relay Auxiliary Heater
A/C Relay
Not used
*A fuse puller is included in the underhood electrical
center.
You will also find spare fuses.
6-65

Downloaded from www.Manualslib.com manuals search engine Hearing Impaired. Customer Assistance .............. 8-4
Heating
........................................ 3-6
High-Beam Headlamps
.......................... 2-32
Highway Hypnosis
.............................. 4-2 1
Hill and Mountain Roads ......................... 4-22
Hitches. Trailer
................................. 4-34
Hood Checking Things Under
......................... 6-7
Prop
....................................... 6-10
Release
...................................... 6-8
Horn
......................................... 2-31
Hydroplaning
.................................. 4-17
Ignition Positions
.............................. 2. I 5
Ignition Transmission Lock Check ................. 7-46
Inflation. Tire
.................................. 6-44
Inspections
.................................... 7-47
Brakesystem
................................ 7-48
Drive Axle
.................................. 7-48
Exhaust Systems
............................. 7-47
Radiator and Heater Hose
...................... 7-47
Steering
.................................... 7-47
Suspension
.................................. 7-47
Throttle Linkage
.............................. 7-47
InstrumentPanel
............................... 2-56
Brightness Control
............................ 2-39
Cleaning
.................................... 6-54
Cluster
..................................... 2-58
FuseBlock
.................................. 6-62
Interior Lamps
.................................. 2-39
Inside
Daymight Rearview Mirror
................. 2-41 Jack.
Tire
.................................... 5-24
Jump Starting ................................... 5-3
Keyless Entry System
........................... 2-7
Key Lock Cylinders Service
...................... 7-44
Keys
.......................................... 2-2
Labels CertificationlTire
............................. 4-28
Service Parts Identification
..................... 6-60
Tire-Loading information
...................... 4-28
Vehicle Identification Number
................... 6-60
Lamps
........................................ 2-37
Courtesy
.................................... 2-39
Dome
...................................... 2-39
Interior
..................................... 2-39
On Reminder
................................ 2-38
Latches, Seatback
................................ 1-5
Leaving Your Vehicle ............................. 2-7
Leaving Your Vehicle
with the Engine Running ....... 2-25
Lighter
....................................... 2-50
Lights
Air
Bag Readiness ....................... 1-28, 2-61
Anti-Lock Brake System Warning
............ 2-64, 4-7
Brake System Warning
......................... 2-63
Charging System
............................. 2-61
CheckGages
................................ 2-68
Safety Belt Reminder
..................... 1 - 13, 2-60
Service Engine Soon
.......................... 2-65
Daytime Running Lamps Indicator
............... 2-68
9-5