1996 VOLVO 850 lights

1996 Volvo 850
l Check condition of drive belts.
l Check state of charge of battery.
l Examine tires carefully (the spare tire as well), and replace those th\
at are worn. Check tire pressures.
l The brakes, front wheel alignment, and steering gear should be checked b\
y your Volvo retailer only.
l Check all lights, including high beams.
l Reflective warning triangles are legal requirement in some countries.
l Have a word with your Volvo retailer concerning engine adjustments if yo\
u intend to drive in
countries where it may be difficult to obtain correct fuel.
l Consider your destination. If you will be driving through an area where \
snow or ice are likely to
occur, consider snow tires.




Contents | Top of Page
file:///K|/ownersdocs/1996/1996_850/96850_412.htm (10 of 10)12/30/2006\
9:59:35 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

1 - Plastic cover, 2 - Bulb HB4/9006
3 - Bulb HB3/9005, 4 - Connector

Headlight bulb replacement

1. Turn the plastic cover counter-clockwise and remove it.
2. Turn the bulb and connector (one unit) 1/4 turn counter-clockwise a\
nd remove.
3. Disconnect the wiring from the bulb unit.
4. Connect a new bulb unit into the wiring without touching the bulb its\
elf.
5. Re-insert the bulb into the headlight housing and turn 1/4 turn clock\
wise until the unit seats properly.
The unit has three guide lugs to ensure proper seating.
6. Reinstall the plastic cover.

Headlight adjustment

The height of the headlight beams can be adjusted according to vehicle l\
oad. The headlights should be re-
aimed if heavy loads are carried in the trunk/cargo area or rear seat, o\
r when towing a trailer.
To adjust the headlights:
l Park the car on a level surface and open the hood.
l The headlights are equipped with a level which can be seen by looking th\
rough the clear "window" on
the top of the headlight lens.
l Turn the height adjustment knob (A) until the bubble in the level alig\
ns with the "0" marks or within
the dark marking lines.
file:///K|/ownersdocs/1996/1996_850/96850_605.htm (2 of 13)12/30/2006 \
9:59:43 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
2. Brake light
3. Tail light
4. Back-up light
5. Tail light / Rear fog light (left side only)

All the bulbs in the tail light unit are replaced from inside the cargo \
space as follows:
l Turn the ignition key to position 0 and switch off the lights.
l Remove the upper panel of the tail light unit by using a screwdriver and\
/or the lower panel by first
removing the side floor cover and then the panel.
l Press in the plastic catches (A or B) and take out the bulb holder.
l Remove the speaker (optional) from the upper section of the tail light\
unit.
l Leave the connector and cables connected to the bulb holder.
l Remove the bulb by pressing it inwards and turning it slightly counter-c\
lockwise.
l Insert a new bulb into the bulb holder and reinstall the holder in the t\
ail light assembly.
l Check that the bulb works. Reinstall the cover.
pg. 6:9 Replacing bulbs Depress the catches (sedans)

Press sides and pull out/down (wagons)

file:///K|/ownersdocs/1996/1996_850/96850_605.htm (6 of 13)12/30/2006 \
9:59:43 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Brake lights mounted in spoiler (certain models)

l Switch off the lights.
l Unscrew the three screws.
l Insert the screwdriver and turn gently to loosen the glass lens to gain \
access to the bulb holder.
l Replace the bulb(s) and reinstall the bulb holder and glass lens.


Insert screwdriver and turn

Trunk light (sedans)/Rear courtesy light (wagons)

l Switch off the lights.
l Press in the catch with a screwdriver and remove the bulb holder.
l Replace the bulb and reinstall the bulb holder.

file:///K|/ownersdocs/1996/1996_850/96850_605.htm (8 of 13)12/30/2006 \
9:59:43 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Phillips-head screwdriver for glass lens

License plate lights (sedans and wagons)

l Switch off the lights.
l Unscrew the two screws.
l Insert the screwdriver and turn gently to loosen the glass lens.
l Replace the bulb and reinstall the glass lens.
pg. 6:11 Replacing bulbs

Insert screwdriver, turn and pull downward

Front courtesy lights

l Switch off the ignition.
l Insert a screwdriver and turn carefully to loosen the glass lens.
file:///K|/ownersdocs/1996/1996_850/96850_605.htm (9 of 13)12/30/2006 \
9:59:43 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
l Replace the bulb and press the glass lens back into place.


Insert a screwdriver and turn

Rear reading lights

l Switch off the ignition.
l Insert a screwdriver and turn to loosen the lamp unit.
l Replace the bulb and press the lamp unit back into place.


Insert a screwdriver and turn

Vanity mirror

l Switch off the ignition.
l Insert a screwdriver under the lower edge and turn to loosen the glass l\
ens.
l Push out the bulb and replace it.
l Press the lower edge of the lens into place above the four catches.
l Press the upper edge of the lens into place.
file:///K|/ownersdocs/1996/1996_850/96850_605.htm (10 of 13)12/30/2006\
9:59:43 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
pg. 6:12 Replacing bulbs

Insert the screwdriver and turn gently (rear door)

Door warning lights

Front
l Slide the lamp unit upward and lift it out.
l Twist off the bulb holder.
l Pull the bulb straight out.
l Replace the bulb.
l Reinstall the holder and lamp unit in reverse order.

Rear
l Insert a screwdriver and turn carefully to loosen the glass lens.
l Pull the bulb straight out.
l Replace the bulb.
l Press the lens back into place.

file:///K|/ownersdocs/1996/1996_850/96850_605.htm (11 of 13)12/30/2006\
9:59:43 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Insert a screwdriver and turn

Door step courtesy lights

l Insert a screwdriver and turn carefully to loosen the glass lens.
l Withdraw the lamp unit, bend back the tabs and remove the plate.
l Replace the bulb.
l Reinstall the plate.
l Press the lamp unit back into place.

NOTE: Other bulbs may be difficult for the owner to replace. Let your Vo\
lvo retailer replace these bulbs
if necessary.


Front fog lights in spoiler

Front fog lights (option)

l Switch off the lights.
file:///K|/ownersdocs/1996/1996_850/96850_605.htm (12 of 13)12/30/2006\
9:59:43 AMClassic Cars & Cycles www.ClassicCycles.org