1996 VOLVO 850 lights

1996 Volvo 850
examine the curved metal wire to see if it is broken. If so, put in a ne\
w fuse of the same color and
amperage (written on the fuse). Spare fuses are stored in a compartmen\
t in the fuse box.

If fuses burn out repeatedly, have the electrical system tested at a Vol\
vo retailer.

If you find it difficult to remove a fuse, you will find a special fuse \
tool clipped in the fuse box. pg. 6:14 Fuses
Location * Amperage

1 Fuel injection, distributor ignition system, automatic gearbox 15A
2 Fuel pump 15A
3 Interior courtesy lights 10A
4 –
5 ECC blower (speed 4) 30A
6 Central locking system 25A
7 Audio system 15A
8 –
9 ABS 30A
10 Electrically heated rear seat 15A
11 Electrically heated rear window and side-door mirrors 30A
12 Brake lights 10A
13 Hazard warning flashers, headlight flashers 15A
14 ABS 30A
15 OBD socket, courtesy lights, open door warning lights,
remote operated central locking system 10A
16 Power antenna, electrical connector for trailer, accessories 30A
17 Key reminder, seat belt reminder 10A
18 Front fog lights 15A
19 Left high beam 15A
20 Right high beam, high beam indicator light 15A
21 Left low beam 15A
22 Right low beam 15A
23 Left parking lights, license plate lights 10A
24 Right parking lights 10A
25 Rear fog light, rear fog light indicator light 10A
26 Heated front/rear seats, power side-view mirrors 25A
27 Backup lights, direction indicators 15A
file:///K|/ownersdocs/1996/1996_850/96850_613.htm (2 of 8)12/30/2006 9\
:59:46 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
28 Cruise control, heated rear windows, seat belt reminder light,
bulb failure warning sensor, shiftlock 10A
29 ABS 15A
30 Cigarette lighter 10A
31 ECC blower (speeds 1-3), ECC, AC-compressor 25A
32 Audio system, remote controlled central locking 10A

Location * Amperage
33 Rear window wiper/washer (wagons) 15A
34 Windshield/headlight wipers/washers, horn 25A
35 Instrument panel lights, power sun roof 10A
36 –
37 Power windows, power sun roof AUT/CB **
38 –
39 Power seat (driver's side) AUT/CB **
40 Power seat (passenger's side) AUT/CB **
* Some of the equipment/systems listed may be available on certain model\
s only.
** This is an automatic circuit breaker located in the fuse box and does\
not normally need to be
replaced.

For more detailed information concerning function and location of relays\
, fuses, etc., refer to the Volvo
Service Manuals. These can be purchased directly using the Service Liter\
ature Brochure/Order Form or
through your Volvo retailer. pg. 6:15 Installation of accessories
file:///K|/ownersdocs/1996/1996_850/96850_613.htm (3 of 8)12/30/2006 9\
:59:46 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
Car care
pg. 7:1 Car care
Car care

Car care includes not only maintaining the appearance of the car, but al\
so protecting the car exterior
from the effects of air pollution, rain, mud or road salt. The rustproof\
ing compound under the car should
be checked regularly and, if necessary, damaged areas should be repaired\
. The paintwork should also be
touched up immediately, if damaged, to prevent rust formation.

7:2 Paint touch-up
7:4Washing
7:5Automatic car washing, Polishing and waxing
7:6Cleaning the upholstery
pg. 7:2 Paint touch-up
Paint touch-up

Paint damage requires immediate attention to avoid rusting. Make it a ha\
bit to check the finish regularly
- when washing the car for instance. Touch up if necessary.

Paint repairs require special equipment and skill. Contact your Volvo re\
tailer for any extensive damage.

Minor scratches can be repaired by using Volvo touch-up paint.

NOTE: When ordering touch-up paint from your Volvo retailer, use the pai\
nt code indicated on the
model plate. The plate is located on the panel above the right-side head\
lights.
file:///K|/ownersdocs/1996/1996_850/96850_701.htm (1 of 8)12/30/2006 9\
:59:48 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
Maintenance Operation thousand miles
(thousand km) 10
(16) 20
(32) 30
(48) 40
(64) 50
(80) 60
(96)
ENGINE SYSTEM MAINTENANCE
ENGINE
Fuel (Line) Filter¹
PCV Nipple (orifice)/hoses,clean I
Battery I I I I I I
BRAKES
Inspect brakes, replace components as necessary I I I I I I
Brake Fluid²
STEERING/SUSPENSION
Rotate tires/check wear (align front end if
needed.) I
I I I I I
Check power steering fluid level. I I I I I I
Grease front link arm stops L L L L L L
BODY
Power antenna (clean) I I I I I I
Trunk/hood, hinges and latches L L L L L L
1) Replace at 100,000 miles (160,000 km)
2) Brake fluid should be changed at owner request every second year (o\
nce a year if the car is driven in
mountainous areas or in areas with high humidity).

The following items should be checked weekly by the driver (it takes on\
ly a few minutes).
Engine oil level Horns
Brake fluid level Windshield wipers
Radiator coolant level Tire pressure (all five tires)
Operation of all lights Level of windshield washer fluid

The following should also be carried out at regular intervals:
Washing
Polishing
Cleaning
Rust protection
file:///K|/ownersdocs/1996/1996_850/96850_801.htm (5 of 6)12/30/2006 9\
:59:50 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
pg. 9:6 Specifications (cont.)
Electrical system

12 Volt, negative ground.
Voltage-controlled generator. Single-wire system with chassis and engine\
used as conductors.

Battery
Voltage 12 V
Capacity 520 A/100 min
(certain markets) 420 A/75 min

The battery contains corrosive and poisonous acids. It is of the utmost \
importance that old batteries are
disposed of correctly. Your Volvo retailer can assist you in this matter\
.

Generator
Rated output 1400 W
Max. current 100 A

Bulbs
Bulb US No. Power Socket No/
bulbs
Headlights
High beam
Low beam
HB3/9005
HB4/9006

70W
60W
–
–
2
2
Front parking lights/turn signals 1157 N.
A. 21/5 W/24/2.2
cp
BAY 15 d
2
Turn signals, rear – 21W BAU 15 s 2
Tail lights (sedan) 67 5 W/4cp BA 15 s 4
Tail lights (wagon) – 21/4W BAZ 15 d 4
Brake lights 1156 21W/32cp BA 15 s 2
file:///K|/ownersdocs/1996/1996_850/96850_906.htm (1 of 9)12/30/2006 9\
:59:57 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
High-mounted brake lights 1156 21W/32cp BA 15 s 1
Brake lights in spoiler – 5W W
2.1x9.5d 6
Bulb US No. Power Socket No/
bulbs
Back-up lights 1156 21W/32cp BA 15 s 2
Rear fog light (sedan) 1156 21W/32cp BA 15 s 1
Rear fog light (wagon) – 21/4W BAZ 15 d 1
Front fog lights H3 55 W PK 22 s 2
License plate light – 5 W W
2.1x9.5d 2
Door open warning light – 3 W W
2.1x9.5d 4
Door step courtesy light – 5W W
2.1x9.5d 2
Trunk light – 10 W SV 8.5 1
Glove compartment light – 2 W BA 9s 1
Vanity mirror lights – 1.2 W – 2
Instrument lighting – 3 W W
2.1x9.5d 3
Illumination, control panel
gear selector (automatic trans.)
rear ashtray –
–
– 1.2 W
1.2 W
1.2 W W 2x4.6 d
W 2x4.6 d
W 2x4.6 d –
1
1
Instrument warning/indicator
lights –
1.2 W W 2x4.6 d –
Front courtesy lights – 5 W BA 9s 2
Rear reading lights – 5 W BA 9s 2
All specifications are subject to change without notice pg. 9:7 Specifications (cont.)
Dimensions and weights
file:///K|/ownersdocs/1996/1996_850/96850_906.htm (2 of 9)12/30/2006 9\
:59:57 AMClassic Cars & Cycles www.ClassicCycles.org