1996 TOYOTA T100 mirror

Downloaded from www.Manualslib.com manuals search engine MA002−05
MA−2
− MAINTENANCEINSIDE VEHICLE
37 Author: Date:
1996 TOYOTA T100 (RM449U)
INSIDE VEHICLE
GENERAL MAINTENANCE
These are maintenance and inspection items which are considered to be the owner’s responsibility.
They can be done by the owner or they can have them done at a service shop.
These items include those which should be checked on a daily basis, those which, in most cases, do not
require (special) tools and those which are considered to be reasonable for the owner to do.
Items and procedures for general maintenance are as follows.
1. GENERAL NOTES
Maintenance items may vary from country to country. Check the owner’s manual supplement in which
the maintenance schedule is shown.
Every service item in the periodic maintenance schedule must be performed.
Periodic maintenance service must be performed according to whichever interval in the periodic main-
tenance schedule occurs first, the odometer reading (miles) or the time interval (months).
Maintenance service after the last period should be performed at the same interval as before unless
otherwise noted.
Failure to do even one item can cause the engine to run poorly and increase exhaust emissions.
2. LIGHTS
(a) Check that the headlights, stop lights, taillights, turn signal lights, and other lights are all working.
(b) Check the headlight aim.
3. WARNING LIGHTS AND BUZZERS
Check that all warning lights and buzzers function properly.
4. HORN
Check that it is working.
5. WINDSHIELD GLASS
Check for scratches, pits or abrasions.
6. WINDSHIELD WIPER AND WASHER
(a) Check operation of the wipers and washer.
(b) Check that the wipers do not streak.
7. WINDSHIELD DEFROSTER
Check that air comes out from the defroster outlet when operating the heater or air conditioner.
8. REAR VIEW MIRROR
Check that it is mounted securely.
9. SUN VISORS
Check that they move freely and are mounted securely.
10. STEERING WHEEL
Check that it has the specified freeplay. Be alert for changes in steering condition, such as hard steering,
excessive freeplay or strange noises.
11. SEATS
(a) Check that the seat adjusters operate smoothly.
(b) Check that all latches lock securely in any position.
(c) Check that the head restraints move up and down smoothly and that the locks hold securely in any
latch position.
(d) For fold−down seat backs, check that the latches lock securely.
12. SEAT BELTS
(a) Check that the seat belt system such as the buckles, retractors and anchors operate properly and
smoothly.
(b) Check that the belt webbing is not cut, frayed, worn or damaged.

Downloaded from www.Manualslib.com manuals search engine MA0055
MA014−01
− MAINTENANCEBRAKE
MA−7
42 Author: Date:
1996 TOYOTA T100 (RM449U)
BRAKE
INSPECTION
1. INSPECT BRAKE LINE PIPES AND HOSES
HINT:
Inspect in a well−lighted area. Inspect the entire circumference
and length of the brake hoses using a mirror as required. Turn
the front wheels fully right or left before inspecting the front
brake.
(a) Check all brake lines and hoses for:
Damage
Wear
Deformation
Cracks
Corrosion
Leaks
Bends
Twists
(b) Check all clamps for tightness and connections for leak-
age.
(c) Check that the hoses and lines are clear of sharp edges,
moving parts and the exhaust system.
(d) Check that the lines installed in grommets pass through
the center of the grommets.
2. INSPECT FRONT BRAKE PADS AND DISCS
(2WD: See page BR−22)
(4WD: See page BR−25)
HINT:
If a squealing or scraping noise occurs from the brake during
driving, check the pad wear indicator.
If there are traces of the indicator contacting the disc rotor, the
disc pad should be replaced.
3. INSPECT REAR BRAKE LININGS AND DRUMS
(2WD: See page BR−42)
(4WD: See page BR−48)

Downloaded from www.Manualslib.com manuals search engine PP0G5−01
− PREPARATIONMAINTENANCE
PP−1
50 Author: Date:
1996 TOYOTA T100 (RM449U)
MAINTENANCE
EQUIPMENT
MirrorBrake hose
Torque wrench

Downloaded from www.Manualslib.com manuals search engine BE – BODY ELECTRICAL

BODY ELECTRICAL SYSTEM BE-1
POWER SOURCE BE-10
IGNITION SWITCH AND KEY UNLOCK
WARNING SWITCH BE-11
HEADLIGHT AND TAILLIGHT SYSTEM BE-14
TURN SIGNAL AND HAZARD
WARNING SYSTEM BE-22
INTERIOR LIGHT SYSTEM BE-24
BACK-UP LIGHT SYSTEM BE-26
STOP LIGHT SYSTEM BE-29
WIPER AND WASHER SYSTEM BE-31
COMBINATION METER BE-35
POWER WINDOW CONTROL SYSTEM BE-46
POWER DOOR LOCK CONTROL
SYSTEM BE-50
POWER MIRROR CONTROL SYSTEM BE-56
AUDIO SYSTEM BE-59
ANTENNA BE-81
CLOCK BE-83

Downloaded from www.Manualslib.com manuals search engine − BODY ELECTRICALBODY ELECTRICAL SYSTEM
BE−9
1996 TOYOTA T100 (RM449U)
POWER DOOR LOCK CONTROL SYSTEM
SymptomSuspect AreaSee page
”Door lock control system” does not operate (All)
1. GAUGE Fuse (Junction Block No.1)
2. POWER WINDOW Fuse (Junction Block No.1)
3. Door Lock Control Relay
4. Wire Harness
5. Other PartsBE−50
BE−50
BE−51
−
−
Malfunction in Door Lock / Unlock
(Using door manual switch)
1. Door Lock Manual Switch
2. Wire Harness
3. Door Lock Control Relay
4. Other PartsBE−51
−
BE−51
−
Mulfunction in Door Lock / Unlock
(Using door manual switch and key)1. Wire Harness
2. Other Parts−
−
Mulfunction in Door Lock / Unlock
(Using Key)
1. Door Key Lock and Unlock Switch
2. Wire Harness
3. Door Lock Control Relay
4. Other PartsBE−51
−
BE−51
−
Fault in 2 − Operation unlock function of Driver’s side door key
Lock and Unlock switch
1. Door Key Lock and Unlock Switch
2. Wire Harness
3. Door Lock Control Relay
4. Other PartsBE−51
−
BE−51
−
Fault in key confine prevention operation
1. Key Unlock Warning Switch
2. Door Courtesy Switch
3. Door Lock Switch
4. Wire Harness
5. Door Lock Control Relay
6. Other PartsBE−12
BE−25
BE−51
−
BE−51
−
Only one door lock does not operate1. Door Lock Motor
2. Wire HarnessBE−51
−
POWER MIRROR CONTROL SYSTEM
SymptomSuspect AreaSee page
Power mirror on each side does not operate at all
1. RADIO Fuse (Junction Block No.1)
2. Mirror Switch
3. Mirror Motor (Up/Down or Left/Right Control)
4. Wire HarnessBE−56
BE−57
BE−57
−
Left or Right power mirror does not operate at all
1. Mirror Switch
2. Mirror Motor (Up/Down or Left/Right Control)
3. Wire HarnessBE−57
BE−57
−
Up/Down Control of left or right power mirror does not operate1. Mirror Motor (Up/Down Control)
2. Wire HarnessBE−57
−
Left/Right control of left or right power mirror does not operate1. Mirror Motor (Left/Right Control)
2. Wire HarnessBE−57
−

Downloaded from www.Manualslib.com manuals search engine Z15842
Outer Rear View Mirror
 Mirror Motor
Junction Block No.1
 RADIO Fuse
Mirror Switch
BE03G−04
BE−56
− BODY ELECTRICALPOWER MIRROR CONTROL SYSTEM
1856 Author: Date:
1996 TOYOTA T100 (RM449U)
POWER MIRROR CONTROL SYSTEM
LOCATION

Downloaded from www.Manualslib.com manuals search engine BE03H−03
Z09299
Left/Light
Adjustment
Switch
Control Switch
Z04379
Z04380
− BODY ELECTRICALPOWER MIRROR CONTROL SYSTEM
BE−57
1996 TOYOTA T100 (RM449U)
INSPECTION
1. INSPECT MIRROR SWITCH CONTINUITY
Left side:
Switch positionTester connectionSpecified condition
UP3 − 4
1 − 8Continuity
DOWN1 − 3
4 − 8Continuity
LEFT3 − 4
1 − 7Continuity
RIGHT1 − 3
4 − 7Continuity
Right side:
Switch positionTester connectionSpecified condition
UP3 − 4
1 − 5Continuity
DOWN1 − 3
4 − 5Continuity
LEFT3 − 4
1 − 6Continuity
RIGHT1 − 3
4 − 6Continuity
If continuity is not as specified, replace the switch.
2. INSPECT MIRROR MOTOR OPERATION
(a) Connect the positive (+) lead from the battery to terminal
3 and negative (−) lead to terminal 1. Check that the mirror
turns to left side.
(b) Remove the polarity, check that the mirror turns to right
side.

Downloaded from www.Manualslib.com manuals search engine Z04654
Z04382
BE−58
− BODY ELECTRICALPOWER MIRROR CONTROL SYSTEM
1996 TOYOTA T100 (RM449U)
(c) Connect the positive (+) lead from the battery to terminal
2 and the negative (−) lead to terminal 1. Check that the
mirror turns upward.
(d) Reverse the polarity, that the mirror turns downward.
If operation is not as specified, replace the mirror assembly.