1996 FORD RANGER transmission

326
*
[SV51485(ALL)09/95]
OBD II Drive Cycle
*
[SV51490(ALL)06/95]
The following steps must be run in the order shown. If any
steps are interrupted, repeat the preceding step. Any safe
driving mode is acceptable between steps.
*
[SV51495(ALL)06/95]
Always drive vehicle in safe manner according to traffic
conditions and obey all traffic laws.
*
[SV51500(ALL)07/95]
The engine must be warmed up and at operating temperature
before proceeding with the drive modes of the following OBD II
Drive Cycle.
*
[SV51505(ALL)06/95]1.
Start the engine. Drive or idle (in neutral) the vehicle for 4
minutes.
[SV51510(ALL)05/95]2.
Idle the vehicle in drive (neutral for automatic transmissions)
for 40 seconds.
[SV51515(ALL)05/95]3.
Accelerate the vehicle to 45 mph (72 km/h) (for manual
transmissions upshift from 1st to 5th gear, but hold in 2nd
for at least 5 seconds) at 1/4 to 1/2 throttle for 10 seconds.
*
[SV51520(ALL)05/95]4.
Drive the vehicle with a steady throttle at 45 mph
(72 km/h) (manual transmissions use 5th gear) for 30
seconds.
*
[SV51525(ALL)08/95]5.
Idle the vehicle in drive (neutral for manual transmissions)
for 40 seconds.
File:15unsvr.ex
Update:Wed May 1 13:56:18 1996

Servicing Your Ranger
327
*
[SV51530(ALL)05/95]6.
Continue to drive the vehicle in city traffic at speeds
between 25 and 40 mph (40-64 km/h) (manual transmissions
primarily drive vehicles in 3rd and 4th gear when possible)
for 15 minutes. During the 15 minute drive cycle the
following modes must be achieved:
[SV51535(ALL)05/95]
a. at least 5 stop and idle modes at 10 seconds each.
[SV51540(ALL)05/95]
b. acceleration from idles at 1/4 to 1/2 throttle position, and
[SV51545(ALL)05/95]
c. choose three different speeds to do 1.5 minute steady state
throttle drives.
[SV51550(ALL)06/95]7.
Accelerate the vehicle up to between 45 and 60 mph
(72-97 km/h) (manual transmissions upshift to 5th gear).
This should take approximately 8 seconds.
*
[SV51555(ALL)05/95]8.
Drive vehicle and hold the throttle steady at the selected
speed between 45 and 60 mph (72-97 km/h) (manual
transmissions use 5th gear) for approximately 5 minutes.
*
[SV51560(ALL)05/95]9.
Drive the vehicle for 5 minutes at varying speeds between 45
and 60 mph (72-97 km/h) (manual transmissions use 5th
gear).
*
[SV51565(ALL)05/95]10.
Bring the vehicle back to idle. Idle in drive (manual
transmissions use 5th gear) for 40 seconds.
*
[SV51570(ALL)07/95]11.
OBD II drive cycle has been completed. Vehicle can be
turned off when convenient.
File:15unsvr.ex
Update:Wed May 1 13:56:18 1996

350
Audio system (see Electronic sound system)....... 127
Autolamp system (see Headlamps)............ 82
Automatic transmission
driving an automatic overdrive............ 158
fluid, adding.................... 301
fluid, checking................... 300
fluid, specification.................. 331
Axle
lubricant specifications................ 331
traction lok...................186, 289
B
Backing up...................... 157
Basic vehicle warranty.................. 3
Battery
acid, treating emergencies............219, 298
battery saver.................... 107
charging system warning light............. 62
disconnecting.................... 222
how to service................... 297
jumping a disabled battery.............. 219
maintenance-free.................. 297
proper disposal, recycling.............. 298
replacement, specifications.............. 330
servicing...................... 297
voltage gauge.................. 62,64
when storing your vehicle.............. 336
Brake fluid
brake warning light.................. 56
checking and adding................ 304
description..................... 304
specifications.................... 331
Brakes
adjustment..................... 177
anti-lock...................... 177
applying the brakes................. 182
brake warning light.................. 56
File:unixr.ex
Update:Wed May 1 13:58:05 1996

354
D
Dashboard (see Instrument panel)............. 73
Daytime running light system.............. 82
Defects, reporting................... 247
Defrost, windshield................. 77,80
Dipstick
automatic transmission fluid...........299, 301
engine oil..................... 276
power steering fluid................. 305
Disabled vehicle (see Towing)............. 234
Dispute Settlement Board............... 243
Doors......................... 99
lubricant specifications................ 331
Driveline universal joint and slip yoke......... 303
Driving under special conditions
bad weather.................... 185
heavy load..................... 188
high speed..................... 185
high water..................... 187
slippery roads................... 185
tips for safe driving................. 184
towing a trailer................... 191
E
Electrical system
fuses......................308, 314
operating when the engine is off............ 41
power point outlet................. 126
relays....................... 315
Electronic sound system
accessory delay.................... 41
radio reception................... 152
tuning the radio................130, 146
warranty and service information........... 154
Electronic stereo cassette radio (see Electronic
sound system)................. 129
Electronic stereo radio (see Electronic sound system) . . . 129
File:unixr.ex
Update:Wed May 1 13:58:05 1996

362
M
Maintenance schedule and record (see separate
Maintenance Schedule and Record booklet)..... 3
Maintenance (see Servicing).............. 257
Manual transmission
clutch.....................161, 302
fluid, checking and adding.............. 302
lubricant specifications................ 331
shifting gears.................... 162
shift speeds..................... 164
Master cylinder, brakes................ 304
Methanol in fuel................... 271
Mileage, calculating fuel economy............ 273
Mirrors
dual electric remote control............. 122
rearview...................... 122
side view mirrors.................. 122
side view mirrors (power).............. 122
Motorcraft parts.................... 330
N
National Highway Traffic Safety Administration..... 247
New vehicle break-in.................. 5
O
Octane rating..................... 269
Odometer
description...................... 70
trip odometer..................... 71
Off road driving, 4-wheel drive............. 174
Oil filter.....................277, 330
Oil (see Engine oil).................. 275
Oil viscosity..................... 275
File:unixr.ex
Update:Wed May 1 13:58:05 1996

368
Transfer case
fluid checking................... 302
lever operated................... 167
Transmission
automatic operation................. 156
fluid, checking and adding (automatic)........ 300
fluid, checking and adding (manual)......... 302
lubricant specifications................ 331
Transmission control switch.............. 158
Transmitter (see Remote entry)............. 103
Trip odometer..................... 71
Tune-up specifications (VECI)............. 325
Turn signal
indicator lights.................... 87
lever......................... 87
U
Used engine oil, disposal............258, 278, 301
V
Variable interval wipers................. 88
VECI (Vehicle Emission Control Information) decal.... 325
Vehicle Identification Number (VIN).......... 242
Vehicle loading.................... 192
calculating the load................. 198
understanding loading information.......... 188
Vehicle storage.................... 334
Ventilating your vehicle (see Climate control)....... 74
Viscosity (see Engine oil)................ 275
Voltmeter (see Battery voltage gauge)......... 62,64
File:unixr.ex
Update:Wed May 1 13:58:05 1996