1996 CHRYSLER VOYAGER ignition

SWITCH SEAT
HEATED
PASSENGER
PASSENGER
HEATED
SEAT
CUSHION
PASSENGER
HEATED
SEAT
BACK
PASSENGER
HEATED
SEAT
MODULE
B (8W-63-3)
FUSIBLE
LINK
FROM
DAEFCB
AB
D
DB
AFE
ACB7
G300
FUSED
B(+)GROUNDHEATED
SEAT
DRIVERGROUND DRIVERSEAT HEATED GROUND
HS3
F35
18
RDP86
20
VTP8
20
WT/BKZ1
18
BK
Z1
18
BKZ1
14
BK
P87
18
RD/WT
P89
20
BK/RDP88
18
RD/WTZ1
18
BK
B56 HS5P1
Z1
12
BK
Z1
18
BK
HEATED
SEAT
BACK DRIVERSEAT HEATED GROUND FUSED
IGNITION
(RUN) (RUN)IGNITIONFUSED
HS4
4B56
HS5P
F20
20
WT
10A
FUSE
12
RUN A22
JUNCTION
BLOCK
7C2
HEATED
SEAT
DRIVER HEATED
SEAT
TEMPERATURE
SENSOR SWITCHSEAT HEATED PASSENGER
PASSENGER
HEATED
SEAT
SWITCH SENSOR TEMPERATURESEAT HEATED
BACKSEAT HEATED(8W-15-9) (8W-12-12)(8W-12-2) (8W-10-14)
8W - 63 - 8 8W-63 POWER SEATS
HEATEDNS/GS
J988W-3GS006308

Component Page
Fuel Injector No. 3 (3.3L/3.8L)...........8W-80-34
Fuel Injector No. 4 (2.0L/2.4L)...........8W-80-34
Fuel Injector No. 4 (3.3L/3.8L)...........8W-80-34
Fuel Injector No. 5 (3.3L/3.8L)...........8W-80-34
Fuel Injector No. 6 (3.3L/3.8L)...........8W-80-34
Fuel Pump Module...................8W-80-35
Fuel Tank Module....................8W-80-35
G200..............................8W-80-35
G300..............................8W-80-36
G301 (Diesel)........................8W-80-37
G301 (Gas).........................8W-80-37
G302..............................8W-80-38
G400..............................8W-80-38
Generator..........................8W-80-38
Glove Box Lamp.....................8W-80-39
Glow Plug Relay.....................8W-80-39
HS6D S02..........................8W-80-39
HS6P S02..........................8W-80-39
Headlamp Switch - C1.................8W-80-39
Headlamp Switch - C2.................8W-80-40
Headlamp Washer....................8W-80-40
High Note Horn......................8W-80-40
Hood Ajar Switch.....................8W-80-41
Horn/Speed Control Switch.............8W-80-41
Idle Air Control Motor.................8W-80-41
Ignition Coil Pack (2.0L/2.4L)...........8W-80-41
Ignition Coil Pack (3.3L/3.8L)...........8W-80-41
Ignition Switch - C1..................8W-80-42
Ignition Switch - C2..................8W-80-42
Ignition Switch - C3..................8W-80-42
Instrument Cluster...................8W-80-42
Intake Air Temperature Sensor..........8W-80-43
Intake Air Temperature/Manifold
Absolute Pressure Sensor............8W-80-43
J02A L15...........................8W-80-43
J03A L16...........................8W-80-43
Junction Block - C1...................8W-80-44
Junction Block - C2...................8W-80-45
Junction Block - C3...................8W-80-46
Junction Block - C4...................8W-80-47
Key-In Halo Lamp....................8W-80-48
Key-In Switch.......................8W-80-48
Knock Sensor........................8W-80-48
Left Combination Relay................8W-80-48
Left Door Speaker....................8W-80-48
Left Fog Lamp (Built-Up-Export)........8W-80-49
Left Fog Lamp (Except Built-Up-Export). . .8W-80-49
Left Front Panel Speaker..............8W-80-49
Left Front Park/Turn Signal Lamp
(Built-Up-Export)..................8W-80-49
Left Front Park/Turn Signal Lamp
(Except Built-Up-Export)............8W-80-49
Left Front Speaker...................8W-80-49
Left Front Wheel Speed Sensor..........8W-80-50Component Page
Left Headlamp (Built-Up-Export)........8W-80-50
Left Headlamp (Except Built-Up-Export) . .8W-80-50
Left Headlamp Leveling Motor
(Built-Up-Export)..................8W-80-50
Left High Headlamp (Chrysler)
(Except Built-Up-Export).............8W-80-50
Left Liftgate Flood Lamp...............8W-80-51
Left Low Headlamp (Chrysler)
(Except Built-Up-Export).............8W-80-51
Left Mid Reading Lamp................8W-80-51
Left Rear Door Ajar Switch.............8W-80-51
Left Rear Lamp Assembly
(Built-Up-Export)..................8W-80-51
Left Rear Lamp Assembly
(Except Built-Up-Export).............8W-80-51
Left Rear Pillar Speaker...............8W-80-52
Left Rear Reading Lamp...............8W-80-52
Left Rear Sliding Door Contacts.........8W-80-52
Left Rear Speaker....................8W-80-52
Left Rear Vent Motor (LHD)............8W-80-52
Left Rear Vent Motor (RHD)............8W-80-53
Left Rear Wheel Speed Sensor..........8W-80-53
Left Repeater Lamp...................8W-80-53
Left Stop/Turn Signal Relay............8W-80-53
Left Visor/Vanity Mirror Lamps.........8W-80-53
License Lamp.......................8W-80-54
Liftgate Ajar Switch..................8W-80-54
Liftgate Arm/Disarm Switch............8W-80-54
Liftgate Lock Motor...................8W-80-54
Low Coolant Level Switch..............8W-80-54
Low Note Horn......................8W-80-54
Low Washer Fluid Switch..............8W-80-54
Manifold Absolute Pressure Sensor.......8W-80-55
Memory Power Seat Switch.............8W-80-55
Memory Seat Front Vertical Motor.......8W-80-55
Memory Seat Front Vertical
Position Sensor....................8W-80-55
Memory Seat Horizontal Motor..........8W-80-55
Memory Seat Horizontal Position Sensor . .8W-80-56
Memory Seat Rear Vertical Motor........8W-80-56
Memory Seat Rear Vertical
Position Sensor....................8W-80-56
Memory Seat Recliner Motor............8W-80-56
Memory Seat Recliner Position Sensor. . . .8W-80-56
Memory Seat/Mirror Module - C1........8W-80-57
Memory Seat/Mirror Module - C2........8W-80-57
Memory Seat/Mirror Module - C3........8W-80-58
Memory Set Switch...................8W-80-58
Message Center (LHD)................8W-80-58
Message Center (RHD)................8W-80-59
Mode Door Actuator...................8W-80-59
Multi-Function Switch.................8W-80-59
Needle Movement Sensor..............8W-80-60
Output Shaft Speed Sensor.............8W-80-60
Overhead Console....................8W-80-60
8W - 80 - 2 8W - 80 CONNECTOR PIN-OUTSNS/GS

FUNCTION
-
-
-CIRCUIT
-
-
-M2 SPEED BLOWER MOTOR
M3 SPEED BLOWER MOTOR
M1 SPEED BLOWER MOTOR
GROUND
LOW SPEED BLOWER MOTOR
HIGH SPEED BLOWER MOTOR
HIGH SPEED BLOWER MOTORCAV
1
2
3
4
5
6
7
8
9
10C6 14LB
C104 12RD/WT
C5 16LG
Z1 12BK
C4 16TN
C107 12TN/BK
C7 12BK/TNBLACK
1
6 5
10
A/C HEATER
CONTROL -C2
CLUTCH COMPRESSORA/C
1BLACK2
Z1 18BK C3 18DB/BK
2 1 CAV GROUND A/C COMPRESSOR CLUTCH RELAY OUTPUT CIRCUIT
FUNCTION
* BUILT-UP-EXPORT
PANEL LAMPS FEED E2 20OR*
CONTROL - C1A/C HEATERC61 22DB DUAL ZONE A/C ACTUATOR (+/-)COMMON DOOR DRIVER C34 20DB/WT
21 10
111 BLUE
Z2 18BK/LG C57 22DB/GY C32 22GY/DB C35 22DG/YL
C33 22DB/RD D2 20WT/BK C62 22DB/PK D1 20VT/BR C61 20DB C34 22DB/WT E2 20OR V23 18BR/PK C26 22PK/DB
C21 22DB/OR C66 18BK/WT C37 22YL
C36 22RD/WT C102 22LG C103 20DG/LB
V26 22YL/WT C14 22WT/RD
21 20 19
18 17 16 15 14 13 12 11 10 9 8 7
6 5 4
3 2 1 CAV GROUND
SENSOR GROUND RECIRCULATION DOOR DRIVER MODE DOOR DRIVER
BLEND DOOR DRIVER CCD(-) DUAL ZONE A/C ACTUATOR (+/-) CCD(+) DUAL ZONE A/C ACTUATOR (+/-) COMMON DOOR DRIVER PANEL LAMPS FEED FUSED IGNITION (ST-RUN) 5 VOLT SUPPLY
A/C SWITCH SENSE WIPER DE-ICE SWITCHED GROUND MODE DOOR FEEDBACK SIGNAL
BLEND DOOR FEEDBACK SIGNAL ZONE DOOR FEEDBACK SIGNAL A/C SWITCH SIGNAL
REAR WIPER SWITCH MUX REAR DEFOGGER RELAY CONTROL CIRCUIT
FUNCTION
NS/GS8W-80 CONNECTOR PIN-OUTS 8W - 80 - 5
NSGS8005J988W-3

FUNCTION
-
-
-
-
-
-
-CIRCUIT
-
-
-
-
-
-
-FUSED IGNITION (ST-RUN)
FUSED IGNITION (RUN)
CCD BUS(+)
CCD BUS(-)
AIRBAG WARNING LAMP DRIVER
GROUNDCAV
1
2
3
4
5
6
7
8
9
10
11
12
13F14 18LG/YL
F23 18 DB/YL
D1 20VT/BR
D2 20WT/BK
R41 18BK/TN
Z2 18BK/LG
7
BLACK
FUNCTION
CIRCUIT
AMBIENT TEMPERATURE SENSOR SIGNAL
SENSOR GROUNDCAV
1
2G31 20VT/LG
G32 20BK/LB
GRAY
21
FUNCTIONCIRCUIT
GROUND
BACK-UP LAMP FEEDCAV
1
2Z1 18BK
L1 18VT/BK
GRAY
21
13
16
21GROUND
BACK-UP LAMP FEED CIRCUIT
Z1 18BK
L1 18VT/BK CAV
2 1
FUNCTION GRAY
AIRBAG
CONTROL
MODULE - C2
ALL WHEEL
DRIVE
SOLENOID - C1
(3.8L ONLY)
AMBIENT AIR
TEMPERATURE
SENSOR (3.8L ONLY) SOLENOID - C2DRIVE ALL WHEEL
NS/GS8W-80 CONNECTOR PIN-OUTS 8W - 80 - 7
NSGS8007J988W-3

FUNCTIONCIRCUIT
GROUND
BACK-UP LAMP FEEDCAV
1
2
3V23 18BR/PK
Z1 20BK
L1 20VT/BK
1
RED
2
1 7FUNCTION
CIRCUIT
GROUND
PANEL LAMPS FEEDCAV
1
2Z1 18BK
E2 18OR
P112 20YL/WT* 4
P114 20YL/BK* 5
-
6
L24 20WT/LG* 7-
BLACK
FUSED IGNITION (ST-RUN)
POWER MIRROR B(-)
POWER MIRROR B(-)
AUTOMATIC HEADLAMP SIGNAL
ASH
RECEIVER
LAMP
(LHD)
AUTOMATIC
DAY/NIGHT
MIRROR(RHD) LAMP RECEIVERASH
* EXCEPT BUILT-UP-EXPORT
- E2 18OR
2 1 CAV - PANEL LAMPS FEED CIRCUIT
FUNCTION31
3
Z1 18BK GROUND RED
8W - 80 - 8 8W-80 CONNECTOR PIN-OUTSNS/GS
J988W-3NSGS8008

Z1 20BK
L50 18WT/TN 3
61
4
BLACKBLACK
4 1
6 3
L63 18DG/RD
6 5 1Z1 18BK Z1 20BK L50 18WT/TN
L50 18WT/TN L77 20BR/LB L1 20VT/BK L63 18DG/RD L63 18DG/RD
4 3 2 CAV
- CIRCUIT
6 5 1
L77 20BR/LB L1 20VT/BK
4 3
2 CAV
- CIRCUIT
3
61
4
BLACKBLACK
4 1
6 3
Z1 20BK L78 20DG/YL L62 18BR/RD
6 4 1Z1 18WT Z1 20BK L50 18WT/TN L78 18BR
L78 20DG/YL L1 20VT/BK L62 18BR/RD L62 18BR/RD
5 3 2 CAV
- CIRCUIT
6 4 1
L50 18WT/TN L1 20VT/BK
5 3 2 CAV
- CIRCUIT
B99
(TRAILER TOW) (TRAILER TOW)B98 T08
T05
DOOR ACTUATORBLEND
2 1
BACK-UP
SWITCH
BACK-UP LAMP FEED L1 18VT/BK
2F20 20WT* FUSED IGNITION SWITCH OUTPUTFUSED IGNITION SWITCH OUTPUT F20 18WT
1 1
CAV FUNCTION CIRCUIT
* DIESEL FUNCTION
CIRCUIT
BLEND AIR DOOR DRIVER
5 VOLT SUPPLY
BLEND DOOR FEEDBACK SIGNAL
SENSOR GROUND
BLEND AIR DOOR DRIVERCAV
1
2
3
4
5C33 20DB/RD
C26 20PK/DB
C36 20RD/WT
C57 20DB/GY
C34 20DB/WTNATURAL
1 5
8W - 80 - 14 8W-80 CONNECTOR PIN-OUTSNS/GS
J988W-3NSGS8014

X3 20BK/RD
HORN RELAY CONTROL L110 22BK/YL
AUTO HEADLAMP SWITCH SENSE
BA
BLACK
40 30 20 10
31 21 11 NATURAL
1
Z1 20BK G9 20GY/BK
B A CAV GROUND RED BRAKE WARNING LAMP DRIVER CIRCUIT
FUNCTION
L308 20LG/WT V26 22YL/WT D9 22GY/BK D2 20WT/BK G6 22GY G19 20LG/OR G69 22BK/OR Z2 20BK/LG L307 20LG/OR E17 20YL/BK Z2 20BK/LG Z20 20BK/WT** E92 22OR/BK
V52 20DG/YL G2 22VT G26 20LB D1 20VT/BR M32 22BK/LB
G96 20LG/RD
40 39
38 37 36
35 34 33
32 31 30
29 28 27
26 25 24 23 22 21
20 19 18
17 16 15
14 13 12
11 10 9
8 7 6
5 4 3
2 1 CAV PARK LAMP SWITCH SENSE REAR WIPER SWITCH MUX RKE MODULE PROGRAM ENABLE CCD BUS(-) ENGINE OIL PRESSURE SWITCH SENSE ABS WARNING LAMP DRIVER VTSS LAMP DRIVER GROUND HEADLAMP SWITCH SENSE STEP DIMMER SWITCH SENSE GROUND GROUND DIMMER SWITCH SIGNAL
FRONT WIPER SWITCH MUX ENGINE TEMPERATURE WARNING LAMP DRIVER KEY-IN IGNITION SWITCH SENSE CCD BUS(+) COURTESY LAMP SWITCH SENSE RKE INTERFACE
- - - -
- - -
- - - - - -
- - - - - CIRCUIT
- - - -
- - -
- - - - - -
- - - - - FUNCTION
P136 20YL
POWER FOLDING MIRROR SWITCH SIGNAL
* BUILT-UP-EXPORT
** EXCEPT BUILT-UP-EXPORT
GAS
BODY
CONTROL
MODULE - C2
BRAKE PRESSURE
SWITCH
8W - 80 - 16 8W-80 CONNECTOR PIN-OUTSNS/GS
J988W-3NSGS8016

GROUND Z1 20BK
SWITCH
(DIESEL)CLUTCH
RED
CLUTCH SWITCH CIRCUIT FUNCTION
CAV
K119 20LG/BK
1
2
1 2
IGNITION SWITCH OUTPUT (START) T141 20YL/RD
2
1F45 20YL/RD CAV FUNCTION CIRCUIT
FUSED B(+) ENGINE STARTER MOTOR RELAY
BLACK
12
4NATURAL1
V37 20RD/LG Z2 20BK/LG X3 20BK/RD
4 3 2 1 CAV SPEED CONTROL SWITCH SIGNAL
GROUND HORN RELAY DRIVER
- CIRCUIT
- FUNCTION
12YELLOW
R45 18DG/LB R43 18BK/LB
2 1 CAV DRIVER AIRBAG LINE NO.2
DRIVER AIRBAG LINE NO.1 CIRCUIT
FUNCTION
CLOCKSPRING - C2CLOCKSPRING - C1
2 1BLACKCIRCUIT FUNCTION
CAV
1
2T141 20YL/RD IGNITION SWITCH OUTPUT (START)
CLUTCH
INTERLOCK
SWITCH
(MTX)
CLUTCH
INTERLOCK
SWITCH
JUMPER
(EATX)
T141 20YL/RD IGNITION SWITCH OUTPUT (START)
8W - 80 - 18 8W-80 CONNECTOR PIN-OUTSNS/GS
J988W-3NSGS8018