1996 CHEVROLET TRACKER torque

Torque Lock (Automatic Transmission)
If you are parlung on a hill and you don’t shift your
transmission into PARK
(P) properly, the weight of the
vehicle may put too much force on the parking pawl in
the transmission. You may find it difficult to pull the
shift lever out of PARK
(P). This is called “torque lock.”
To prevent torque lock, set the parking brake and then
shift into
PARK (P) properly before you leave the
driver’s seat.
To find out how, see “Shifting Into
PARK (P)” in the Index.
When you are ready to drive, move the shift lever out of
PARK (P) before you release the parking brake.
If torque lock does occur, you may need to have another
vehicle push yours a little uphill to take some of the
pressure from the transmission,
so you can pull the shift
lever out
of PARK (P).
Shifting Out of PARK (P)
(Automatic Transmission)
Your Geo has a brake-transmission shift interlock. You
have to fully apply your regular brakes before you can
shift from PARK (P) when the ignition is in the ON
position. See “Automatic Transmission’’ in the Index.
If you cannot shift out of PARK (P), ease pressure on
the shift lever
-- push the shift lever all the way into
PARK
(P) and release the shift lever button as you
maintain brake application. Then press the shift lever
button and move the shift lever into the gear you wish.
If you ever hold the brake pedal down but still can’t
shift out
of PARK (P), try this:
1. Apply and hold the brake until the end of Step 6.
2. If the engine is running, shut it off. Turn the key to
ON or ACC.
3. Find the access hole cover on the driver’s side of the
console, near the shift lever.
4. Remove the screw and cover.
5. Inside you’ll see the return plate. Using your finger,
move the return plate toward the rear of the vehicle
until
it stops.
6. Move the shift lever into the gear you want.
7. Have the vehicle fixed as soon as possible.
2-23
ProCarManuals.com

A CAUTION:
Incorrect wheel nuts or improperly tightened
wheel nuts can cause the wheel to become loose
and even come
off. This could lead to an accident.
Be sure
to use the correct wheel nuts. If you have
to replace them, be sure to get new
GM original
equipment wheel nuts.
Stop somewhere as soon as you can and have
the nuts tightened with
a torque wrench to
60 lb-ft (80 N-m).
NOTICE:
Improperly tightened wheel nuts can lead to
brake pulsation and rotor damage.
To avoid
expensive brake repairs, evenly tighten the wheel
nuts in the proper sequence and to the proper
torque specification.
Storing a
B
-
lat or Spare Tire and Tools
I
Storing a jack, a tire or other equipment in the
passenger compartment
of the vehicle could
cause injury. In
a sudden stop or collision, loose
equipment could strike someone. Store all these
in the proper place.
Store your vehicle’s flat tire or spare by mounting it on
the tailgate and cover.
5-31
ProCarManuals.com

Brake Wear
Your Geo has front disc brakes and rear drum brakes.
Disc brake pads have built-in wear indicators that make a
high-pitched warning sound when the brake pads are
wor~ and new pads are needed.
The sound may come and
go or be heard all the time your vehicle is moving (except
when you are pushing
on the brake pedal firmly).
The brake wear warning sound means that sooner
or later your brakes won’t work
well. That could
lead
to an accident. When you hear the brake
wear warning
sound, have your vehicle serviced.
I NOTICE: I
Continuing to drive with worn-out brake pads
could result
in costly brake repair.
Some driving conditions or climates may cause a brake
squeal when the brakes are first applied or lightly applied.
This does not mean something is wrong with
your brakes,
Free movement of brake calipers and properly torqued
wheel nuts are necessary to help prevent brake pulsation.
When tires are rotated, inspect brake calipers for
movement, brake pads for wear, and evenly torque wheel
nuts
in the proper sequence to GM specifications.
Your rear drum brakes don’t have wear indicators, but
if
you ever hear a rear brake rubbing noise, have the rear
brake
linings inspected. Also, the rear brake drums
should be removed and inspected each time the tires are
removed for rotation or changing. When you have the
front brakes replaced, have the rear brakes inspected,
too.
Brake linings should always be replaced as complete
axle sets.
Brake Pedal Travel
See your dealer if the brake pedal does not return to
normal height,
or if there is a rapid increase in pedal
travel. This could
be a sign of brake trouble.
6-32
ProCarManuals.com

After the tires have been rotated, adjust the front and rear
inflation pressures as shown on the Tire-Loading
Information label. Make certain that all wheel nuts are
properly tightened. See “Wheel Nut Torque”
in the Index.
Rust or dirt on a wheel, or on the parts to which
it is fastened, can make wheel nuts become loose
after a time. The wheel could come off and cause
an accident. When
you change a wheel, remove
any rust or dirt from places where the wheel
attaches to the vehicle. In an emergency, you can
use
a cloth or a paper towel to do this; but be
sure
to use a scraper or wire brush later, if you
need to, to get all the rust or dirt off. (See
“Changing
a Flat Tire” in the Index.) When
It’s Time
for New Tires
One way to tell when it’s
time for new tires
is to
check the treadwear
indicators, which will
appear when your tires have
only
1/16 inch (1.6 mm) or
less of tread remaining.
You need a new tire if any of the following statements
are true:
0 You can see the indicators at three or more places
You can see cord or fabric showing through the
tire’s rubber.
0 The tread or sidewall is cracked, cut or snagged deep
enough to show cord or fabric.
0 The tire has a bump, bulge or split.
The tire has a puncture, cut or other damage that
around the tire.
can’t be repaired well because of the size or location
of the damage.
6-43
ProCarManuals.com

Capacities (Approximate)
The following approximate capacities are given in
English and metric conversions.
label under the hood and “Air Conditioning
Refrigerants” at the end of this section.
Air Conditioning?
... See the refrigerant information
Please refer to “Fluids and Lubricants” in the Index
for more information.
Automatic Transmission Drain and Refill
...... . 3.0 quarts (2.8 L)**
Overhaul
Two-Door Convertible
...... 5.4 quarts (5.1 L)
Four-Door Hardtop
........ 7.3 quarts (6.9 L)
Automatic Transmission ....... 5.5 quarts (5.2 L)
Manual Transmission
....... 5.6 quarts (5.3 L)
With Filter Change ........ 4.5 quarts (4.2 L)*
Front Differential ............ 1.1 quarts (1.0 L)
Fuel Tank
Two-Door Convertible
....... 11.1 gallons (42 L)
Four-Door Hardtop ......... 14.5 gallons (55 L)
Cooling System
Crankcase Manual Transmission
Four-wheel Drive
........ 1.6 quarts (1.5 L)**
Two-Wheel Drive .......... 2.0 quarts (1.9 L)**
Rear Differential ............. 2.3 quarts (2.2 L)
Transfer Case ............... 1.8 quarts (1.7 L)
* When changing the oil filter, additional oil may be
needed. Recheck the oil level after filling. See “Engine
Oil” in the Index.
** Recheck fluid level after filling. See “Automatic
Transmission Fluid” or “Manual Transmission Fluid” in
the Index.
Wheel Nuts
Wheel Nut Torque ............. 60 lb-ft (80 N-m)
6-63
ProCarManuals.com

Specifications. Engine ................ ....... 6-62
Speech Impaired. Customer Assistance
............... 8-3
Speedometer ................................... 2- 59
Stains, Cleaning
................................ 6-50
Starter Switch Check
............................ 7-49
Steam
...................................... 5-12
Steering
......................... . . 4-9
Column Lock Check
............. ....... 7-50
Power
.................................. . . 4-9
Storage Areas
... ... .............. 2-39
Stuck: In Sand, Mud, Ice or Snow
.................. 5-33
Sun Visors .................................... 2-41
Sunroof
....................................... 2-43
Symbols, Vehicle
............. ............. vi
In Emergencies ............................. 4- 10
Tips
........................... ... I .*. 4-9
Storage, Vehicle
.............................. 6-33
Tachometer
................................ 2-59
Tailgate
........................................ 2-5
Tailgate Lock Release ............................ 2-5
Tape Player Care
............................... 3- 18
Theft-Deterrent Feature,
CD Player ................ 3-15
Thermostat
.................................... 6-26
Third Gear, Manual Transmission
.................. 2-14
Theft
.......................................... 2-5
Tire Chains ........................... . . 6-47
Tire Loading
................................. 4-46
Tire-Loading Information Label
................... 4-46
Tires
....................................... 6.40
Alignment and Balance
................. . . 6-46
Buying New
..................... .... 6-44
Chains ............................ . . 6-47
Changing
a Flat ....................... . . 5-22
Inflation
.................................... 6-41
Inflation Check
............................... 7-47
Cleaning
.................................. 6-54
Inspection and Rotation
........................ 6-42
Loading
.................................. 4-46
Temperature
............................... 6-45
Uniform Quality Grading
....................... 6-44
Wear Indicators
.............................. 6-43
Wheel Replacement
........................... 6-46
When It’s Time for New
....................... 6-43
Pressure
. . ... ................... 6-41
Traction
...................... .......... 6-45
Treadwear
................ ............ 6-45
TopStrap
..................................... 1-38
TorqueLock ................................... 2-23
Torque, Wheel Nut
......................... 5-31, 6-63
Towing a Trailer
................................ 4-48
Towing, Recreational Vehicle
..................... 4-43
Towing Your Vehicle
............................. 5-7
9-11
ProCarManuals.com

Trailer Brakes
..................................... 4-51
Driving on Grades ............................ 4-53
Driving with
................................. 4-52
Hitches
..................................... 4-51
Maintenance
When Towing ..................... 4-55
ParkingonHills .............................. 4-54
Safety Chains
................................ 4-51
Tongueweight
............................... 4-50
Total Weight on Tires
.......................... 4-50
Turnsignals ................................. 4-53
Weight
..................................... 4-49
Transfer
Case. Manual Shift ................. 2- 18. 6-22
Transmission Fluid
Automatic
................................... 6- 15
Transportation. Courtesy .......................... 8-6
Trip
Odometer ................................. 2-59
TTYUsers
..................................... 8-3
Turn Signal and Lane Change Signals ............... 2-28
Turn Signal/Multifunction Lever
................... 2-28
Manual ..................................... 6-19
Turn Signals When Towing a Trailer ................ 4-53
Underbody Flushing Service
..................... 7-50
Underbody Maintenance
.... ............... 6-55
Vehicle Control
...................................... 4-5 Damage
Warnings
............................... v
Dimensions ................................. 6-64
Identification Number
......................... 6-57
Loading
........... .................... 4-46
Storage
....... .................... 6-33
Visors. Sun .................................... 2-41
warning Devices
............................... 5-2
Warning Lights. Gages and Indicators
............... 2-60
Washer Fluid. Windshield
........................ 6-28
Washing Your Vehicle ........................... 6-52
Weatherstrips
.................................. 6-52
Wheel
Alignment
.................................. 6-46
LockKey
................................... 5-23
Nut Torque ............................. 5-31. 6-63
Replacement
................................. 6-46
Wrench ..................................... 5-23
Window Lock
.................................. 2-27
Windows. Power
............................... 2-27
Windshield Washer
............................. 2-31
Fluid
................... I .............. 6-28. 2-31
Fluid Level Check
............................ 7-47
Rear ....................................... 2-31
Windshield Wiper
.............................. 2-30
Rear ........................... : ........... 2-31
Winter
Driving ................................. 4-39
Wrench. Wheel ................................. 5-23
Ventilation
System
............................. 3-3
. c
9-12
ProCarManuals.com