1996 CHEVROLET TRACKER headlamp

Bulb Replacement
See “Replacement Bulbs” in the Index to check the size
and type of bulb you need to use.
Halogen Bulbs
Halogen bulbs have pressurized gas inside and
can burst,if you drop or scratch the bulb. You or
others could
be injured. Be sure to read and
follow the instructions on the bulb package.
Headlamps
To replace the headlamp bulb:
1. Open the hood.
2. Push in on both sides of the electrical connector.
Then
pull up and rearward, to disconnect it from the
bulb. The plastic clip on the electrical connector may
need to be lifted gently with a screwdriver.
I
I
6-34
ProCarManuals.com

3. Turn the lock ring counterclockwise to release
the
bulb.
4. Pull the lock ring and the headlamp straight out.
Save the lock ring and
use with the new bulb.
5. Reverse the steps with a new bulb.
6-35
ProCarManuals.com

Wheel Alignment and Tire Balance
The wheels on your vehicle were aligned and balanced
carefully at the factory
to give you the longest tire life
and best overall performance.
In most cases, you will not need to have your wheels
aligned again. However, if you notice unusual tire wear
or your vehicle pulling one way or the other, the
alignment may need
to be reset. If you notice your
vehicle vibrating when driving
on a smooth road, your
wheels may need
to be rebalanced.
Wheel Replacement
Replace any wheel that is bent, cracked, or badly rusted
or corroded.
If wheel nuts keep corning loose, the wheel,
wheel bolts
and wheel nuts should be replaced. If the
wheel leaks
air, replace it (except some aluminum
wheels, which
can sometimes be repaired). See your
Geo dealer if any of these conditions exist.
Your dealer will know the kind
of wheel you need.
Each new wheel
should have the same load-carrying
capacity, diameter, width, offset
and be mounted the
same way as
the one it replaces.
If you need to replace any of your wheels, wheel bolts
or wheel nuts, replace them only with new
GM original
equipment parts. This way, you will be sure to have the
right wheel, wheel bolts and wheel nuts for your
Geo model.
Using the wrong replacement wheels, wheel bolts
or wheel nuts on your vehicle can be dangerous. It
could affect the braking and handling of your
vehicle, make your tires lose air and make
you lose
control.
You could have a collision in which you or
others could be injured. Always use the correct
wheel, wheel bolts and wheel nuts for replacement.
NOTICE:
The wrong wheel can also cause problems with
bearing life, brake cooling, speedometer or
odometer calibration, headlamp aim, bumper
height, vehicle
ground clearance and tire or tire
chain clearance to the body and
chassis.
~~
See “Changing a Flat Tire” in the Index for more
information.
6-46
ProCarManuals.com

Your vehicle has an air bag system. Before attempting to
add anything electrical to your
Geo, see “Servicing Your
Air Bag-Equipped Geo” in the Index.
Fuses and Circuit Breakers
The wiring circuits in your vehicle are protected from
short circuits
by fuses, circuit breakers and thermal links
in the wiring itself. This greatly reduces the chance of
fires caused by electrical problems.
Look at the silver-colored band inside the fuse. If the
band is broken or melted, replace the fuse. Be sure you
replace a bad fuse with a new one of the correct size.
If you ever have a problem on the road and don’t have a
spare fuse,
you can borrow one. Just pick some feature
of your vehicle that you can get along without -- like the
radio or cigarette lighter
-- and use its fuse, if it is the
size you need. Replace it as soon as you can.
Before replacing
a fuse, turn every vehicle electrical
switch
off.
There are two fuse blocks in your vehicle: the
instrument panel fuse block and the engine compartment
fuse block.
Instrument Panel Fuse Block
This fuse box is under the left side of the instrument
panel.
The fuses here protect each separate circuit
including headlamps.
If you have electrical failure,
check here first.
ProCarManuals.com

Main Fuse Block
The main fuse box in your engine compartment protects
all electrical loads.
For access
to the main fuses, pull off the cover. A spare
fuse is
also inside the fuse box.
Fuse
BATT ......
ABS .........
Usage
............ All Electrical Load
....... Anti-Lock Brake System
LAMP
...
IG . . ................. Ignition, Lighter, Radio,
Wiperwasher, Rear Defogger,
Turn Signals, Backup Lamps, Heater
Stop Lamps, Horn, Hazard Lamps
H/L, R ................... Right Side Headlamp
H/L, L ................. Left Side Headlamp
FI ....... .......... Fuel Injection System
A/C
.... ... ........ Air Conditioning
......... Taillamps, Dome Lamps,
6-60
ProCarManuals.com

Replacement Bulbs
Bulb Number
Back-up ............................... 1156
Dome
................... GM Part No. 9605 1559
or equivalent
Front Parking and
Turn Signal ........... 1157 NA
Headlamp (Halogen) ..................... 9004
GM Part
No. 9441731
or equivalent
Headlamp, High-Beam
...... GM Part No. 9433184
or equivalent
Turn Signal ... . . GM Part No. 9433 184
or equivalent
Center High-Mounted Stop ................. 921
Bulb
License Plate . .
Number
................... 194
GM Part
No. 96053203
or equivalent
Rear Hazard and
Turn Signal ............. 1156
GM Part
No. 9605 1557
or equivalent
GM Part
No. 96051558
or equivalent
Sidemarker
............................ 194
GM Part
No. 96053293
or equivalent
Rear Parking and Stop .................. 1157
ProCarManuals.com

Flash-to-Pass Feature .....
Flat Tire. Changing ...............
Fluid Capacities ......................
Fluids and Lubricants ................
Fourth Gear. Manual Transmission . .
Four-wheel Drive .............
French Language Manual . .
Front Axle ................
Foreign Countries. Fuel ...........
..... 2-30
..... 5-22
... 6-63
..... 7-53
...... 6-4
........ 2-14
..... 2.16. 6.22
.......... 6-23
.. ............. 11
Front Seat Side Pockets .......................... 2-39
Front Sidemarker Lamp Bulb Replacement
........... 6-37
FrontTowing
................................... 5-9
Fuel .......................................... 6-2
Front
Turn Signal Lamp Bulb Replacement
.......... 6-36
Canada
...................................... 6-3
DoorLock
................................... 6-5
Filling
Your Tank ............................... 6-4
Gage
....................................... 2-69
.Fuses and Circuit Breakers
....................... 6-58
In Foreign Countries ........................... 6-4
Gages Engine Coolant Temperature
............ ... 2-64
..................................... Fuel 2-69
GAWR ....................................... 4-46
Gear Positions, Automatic Transmission ............. 2- 10 Gear
Positions. Manual Transmission
............... 2-14
GloveBox
.................................... 2-39
Gross Axle Weight Rating
.... ................ 4-46
Guide en FranGais
, 11
GVWR ................ .................. 4-46
Gross Vehicle Weight Rating ...................... 4-46 .. ......... .....................
Halogen Bulbs ..................... .... 6-34
Hazard Warning Flashers
.............. . . 5-1
Head Restraints
..................... ....... 1-3
Headlamps
....................... ......... 2-29
High/Low Beam Changer
.................... 2-29
Highway Hypnosis
.............................. 4-37
Bulb
Replacement
............ ......... 6-34
Hearing Impaired, Customer Assistance
.............. 8-3
Heating ........................................ 3-3
Hill and Mountain Roads
......................... 4-37
Hitches, Trailer
........ ..................... 4-51
Hood Checking Things Under
............... ....... 6-6
Prop
..................... ............... 6-7
Release
...................................... 6-6
Horn
......................................... 2-28
Hubs. Freewheeling ............................. 2-17
Hydroplaning
.................................. 4-33
9-5
ProCarManuals.com