1996 CHEVROLET S10 trailer

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
I Short TripKity Definition
__~
Follow the Short TripKity Maintenance Schedule if any
one
of these conditions is true for your vehicle:
0 Most trips are less than 5 to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures are below freezing.
driving
in stop-and-go traffic).
0 Most trips include extensive idling (such as frequent
0 You operate your vehicle in dusty areas or
off-road frequently.
You frequently tow a trailer.
If the vehicle is used for delivery service, police, taxi
or other commercial application.
One of the reasons you should follow this sch.edule if
you operate your vehicle under any qf these conditions
is that these conditions
cause engine oil to break
down soone):
Short TripKity Intervals
Every 3,000 Miles (5 000 km): Engine Oil and Filter
Change (or
3 months, whichever occurs first). Chassis
Lubrication (or
3 months, whichever occurs first). Drive
Axle Service (or
3 months, whichever occurs first).
At 6,000 Miles (10 000 km) -- Then Every
12,000 Miles (20 000 km): Tire Rotation.
Every 15,000 Miles (25 000 km): Air Cleaner Filter
Inspection,
if driving in dusty conditions. Front
Wheel Bearing Repack
(2WD only) (or at each brake
relining, whichever occurs first).
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement.
Fuel Filter Replacement.
Every 50,000 Miles (83 000 km): Automatic
Transmission Service (severe conditions only).
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection. Fuel
Tank, Cap and Lines Inspection.
Every 100,000 Miles (166 000 km): Cooling System
Service
(or every 60 months, whichever occurs first).
Spark Plug Wire Inspection.
Spark Plug Replacement.
Positive Crankcase Ventilation (PCV) Valve Inspection.
These intervals only sumrnurize maintenance services.
Be sure to.follow the complete maintenance schedule on
the%following pages.
7-4

Downloaded from www.Manualslib.com manuals search engine I Short Trip/City Maintenance Schedule I
The services shown in this schedule up to 100,000 miles
( 166 000 km) should be performed after 100,000 miles
(166
000 km) at the same intervals.
Footnotes
-f- The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior
to the
completion
of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
** Drive axle service:
0
0
0
Locking Differential -- Drain fluid and refill at first
engine
oil change. At subsequent oil changes, check
fluid level and add fluid as needed. If driving in
dusty areas or towing a trailer, drain fluid and refill
every 15,000 miles
(25 000 km).
Standard Differential
-- Check fluid level and add
fluid as needed at every oil change. If driving in
dusty areas or towing
a trailer, drain fluid and refill
every
15,000 miles (25 000 km).
More frequent lubrication may be required for
heavy-duty or off-road use.

Downloaded from www.Manualslib.com manuals search engine I Short TripKity Maintenance Schedule I
50,000 Miles (83 000 km)
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more of these conditions:
In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32°C) or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police or
delivery service.
If you do n.ot use your vehicle under any of
these conditions, the fluid and filter do not
require changing.
Manual transmission fluid doesn’t require change.
DATE
-
ACTUAL MILEAGE SERVICED BY
I
7-18

Downloaded from www.Manualslib.com manuals search engine I Short Trip/City Maintenance Schedule I
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one
or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32 O C) or higher.
- In hilly or mountainous terrain.
- When doing frequent, trailer towing.
- Uses such as found in 'taxi, police or
delivery service.
.*
If you do not use your vehicle under any of
' these conditions, the fluid and filter do not
require changing.
Manual transmission fluid doesn't require change.
L7 Inspect Positive Crankcase Ventilation
(Pcv) valve. An Emission Control Service.
I I
DATE ACTUAL MILEAGE
7-31

Downloaded from www.Manualslib.com manuals search engine The services shown in this schedule up to 100,000 miles
(166 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the
completion
of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance be recorded.
** Drive axle service:
0 Locking Differential -- Drain fluid and refill at first
engine oil change. At subsequent oil changes, check
fluid level and add fluid as needed.
If driving in
dusty areas or towing a trailer, drain fluid and refill
every
15,000 miles (25 000 km).
0 Standard Differential -- Check fluid level and add
fluid as needed at every engine oil change. If driving
in dusty areas or towing a trailer, drain fluid and
refill every
15,000 miles (25 000 km). ..
0 More frequent lubrication may be required for
heavy-duty or off-road use.

Downloaded from www.Manualslib.com manuals search engine I Long Tripmighway Maintenance Schedule
50,000 Miles (83 000 km)
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more
of these conditions:
In heavy city traffic where the outside
temperature regularly reaches
90 O F
(32°C) or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found
in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, the fluid and filter do not
require changing.
Manual transmission fluid doesn’t require change.
I I I 1
DATE ACTUAL MILEAGE SERVICED BY:
7-38

Downloaded from www.Manualslib.com manuals search engine =
Long Tripmighway Maintenance Schedule
100,000 Miles (166 000 km) (Continued)
0 Change automatic transmission fluid and
filter if the vehicle is mainly driven under
one or more
of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90°F
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, the fluid andfilter do not
require changing.
Manual transmission fluid doesn’t require change.
0 Inspect Positive Crankcase Ventilation
(Pcv) valve.
An Emission Control Service.
DATE ACTUAL MILEAGE SERVICED BY:
7-46

Downloaded from www.Manualslib.com manuals search engine I
Brakes Adjustment ........... ....................... '6-34
qMager Cylinder ............................... 6-31 Anti-Lock .................................... 4-6
Pedal Travel- ................................. 6-34
Replading System Parts ......................... 6-34
Trailer 4-52
Wear ....................................... 6-33
Brake-Transmission' Shift Interlock Check ........... 7-49
Braking ......................................... 4-5
......................................
BTaking in Emergencies ........................... 4-8
Break-In, New Vehicle ............................ 2-8
BTSI Check .................................... 7-49
Bulb Replacement .......................... 6-35., 6-66
Brightness Control ............................. ; 2-42
Canadian Roadside Assistance .................... 8-6
Capacities and Specifications ................. 6-66. 6-68
Cassette Tape Player ......................... 3.7. 3.9
Center High-Mounted Stoplamp Bulb Replacement .... 6-39
Center Passenger Position ........................ 1-25
Certif?cation/Tire Label ............... , ........... 4-42
Chains
Carbon Manoxide .......................... 2.30. 4.40
Care ....................................... 3-18
Safety ...................................... 4-51
Tire ......................................... 6-52 Changing a Flat Tire ............................. 5-22
Charging System Light .......................... 2-54
Check Gages Light ' ' ... ' .. 2-62 ............... ..........
Checking Your Restraint Systems .................... 1-38 Chemical Paint Spotting .......................... 6-59
ChiSd-ReStraints ........................... 1 .... 1-30
Securing in the Center Seat Position (Except W40) . . 1-31
Securing in the Right FTont Seat Position .......... 1-33
Where Not to Put
Top
Strap
................................... : 1-30.
......................... 1-32. 1-33
Cleaner, Air .............................. 6-14, 6-67
Aluminum Wheels ............................ 6-58
Inside of Your Vehicle ......................... 6-53
.
Cigarette Lighter ................................ 2-46
Circuit Breakers and Fuses ......................... 6-63
Cleaning
Fabric
........................................ 6-53
Glass 6-56
Instrument Panel ................ .'. ....... 1 ... 6-55
Leather .................. : ..................... 6-55
Outside of Your Vehicle' ........................ 6-57
Safety Belts ................................... 6-56
Stains ...................................... 6-54
Tires 6-58
.Vinyl ....................................... 6-55
Weatherstrips .................... : ............ 6-56
.......................................
........................................
Wheels ...................................... 6-58
Windshield and Wiper Blades ................... 6-56
Climate Control System ........................... 3-1
Clock, Setting ................................... 3-5
Comfort Controls ................................ 3-1 Clutch, Hydraulic ................................ 6-20
Compact Disc Care ......... I. .................... 3-18
9-2