1995 CHEVROLET ASTRO CARGO VAN automatic transmission

Downloaded from www.Manualslib.com manuals search engine Every 60,000 Miles (100 000 km)
Engine Accessory Drive Belt Inspection
Spark Plug Wire Inspection
Engine Timing Check
Fuel Tank. CaD and Lines Inspection
Schedule 11 Definition I
Follow Schedule I1 only if none of the conditions from Schedule I is true.
Sohedule I1 Intervals
Every
7,500 Miles (12 500 km)
Engine Oil and Filter Change (or every 12 months, whichever occurs first)
Chassis Lubrication (or every 12 months, whichever occurs first)
Drive Axle Service
At 7,500 Miles (12 500 km) - Then Every 15,000 Miles (25 000 km)
Tire Rotation
Every 30,000 Miles (50 000 km)
Cooling System Service (or every 24 months, whichever occurs first)
Spark Plug Replacement
Fuel Filter Replacement
Air Cleaner Filter Replacement
Front Wheel Bearing Repack (or at each brake relining, whichever occurs
first
(2WD Only)
Every 50,000 Miles (83 000 km)
Automatic Transmission Service (severe conditions)
Every 60,000 Miles (100 000 km)
Spark Plug Wire Inspection
Engine Accessory Drive Belt Inspection
Fuel Tank, Cap and Lines Inspection
7-5

Downloaded from www.Manualslib.com manuals search engine I Maintenance Schedule I I
50,000 Miles (83 000 km)
0 Change automatic transmission fluid and filter if the vehicle is mainly
driven under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly
reaches
90°F (32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, the fluid
and filter do not require changing.
DATE
SERVICED BY: ACTUAL MILEAGE
51,000 Miles (85 000 km)
0
0
0
Change engine oil and filter (or every 3 months, whichever occurs
first).
An Emission Control Service.
Lubricate the front suspension, ball joints and king pin bushings,
steering linkage and transfer case shift linkage, parking brake cable
guides, and brake pedal springs at every oil change (or every
6 months,
whichever occurs first).
Check readfront axle fluid level and add fluid as needed. Check
constant velocity joints and axle seals for leaking.**
DATE ACTUAL MILEAGE SERVICED BY:
7- 15

Downloaded from www.Manualslib.com manuals search engine I Maintenance Schedule I 1
100,000 Miles (166 000 km)
0 Change automatic transmission fluid and filter if the vehicle is mainly
driven under one or more
of these conditions:
- In heavy city traffic where the outside temperature regularly
reaches
90°F (32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, the fluid
and filter do not require changing.
DATE
SERVICED BY ACTUAL MILEAGE
7-25

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule II I
50,000 Miles (83 000 km)
0 Change automatic transmission fluid and filter if the vehicle is mainly
driven under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly
reaches
90°F (32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, the fluid
and
filter do not require changing.
DATE SERVICED BY ACTUAL MILEAGE
52,500 Miles (87 500 km)
0
0
0
Change
engine oil and filter (or every 12 months, whichever occurs
first).
An Emission Control Service.
Lubricate the front suspension, ball joints and king pin bushings,
steering linkage and transfer case shift linkage, parking brake cable
guides, and brake pedal springs at every oil change (or every
12
months, whichever occurs first).
Check readfront axle fluid level and add
fluid as needed. Check
constant velocity joints and axle seals for leaking.**
Rotate tires. See “Tire Inspection and Rotation”
in the Index for proper
rotation pattern and additional information.
DATE SERVICED BY: ACTUAL MILEAGE
7-30

Downloaded from www.Manualslib.com manuals search engine I Maintenance Schedule II I
100,000 Miles (166 000 km)
Change automatic transmission fluid and filter if the vehicle is mainly
- In heavy city traffic where the outside temperature regularly
reaches
90°F (32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
driven
under one
or more of these conditions:
If you do not use your vehicle under any of these conditions, the fluid
and filter do not require changing.
DATE
SERVICED BY: ACTUAL MILEAGE
Part 9: vwner Checks and Services
Listed below are owner checks and services which should be performed at
the intervals specified to help ensure the safety, dependability and emission
control performance
of your vehicle.
Be sure any necessary repairs are completed at once. Whenever any fluids
or lubricants are added to your vehicle, make sure they are the proper ones,
as shown
in Part D.
At Each Fuel Fill
It is important for you or a service station attendant to pegorm these
underhood checks at each fuel
fill.
Engine Oil Level
Check the engine oil level and add the proper oil if necessary. See “Engine
Oil” in the Index for further details.
7-35

Downloaded from www.Manualslib.com manuals search engine Steering Column Lock
While parked, and with the parking brake set, try to turn the key to LOCK
in each shift lever position.
The key should turn to LOCK only when the shift lever is in PARK (P).
The key should come out only in LOCK.
Parking Brake and Automatic Transmission PARK (P)
Mechanism Check
I
When you are doing this check, your vehicle could begin to I
CAUTION:
move. You or others could be injured and property could be
damaged.
Make sure there is room in front of your vehicle in
case it begins to roll. Be ready to apply the regular brake at once
should the vehicle begin
to move.
Park on a fairly steep hill, with the vehicle facing downhill. Keeping your
foot on the regular brake, set the parking brake.
0 To check the parking brake: With the engine running and transmission
in NEUTRAL (N), slowly remove foot pressure from the regular brake
pedal.
Do this until the vehicle is held by the parking brake only.
To check the PARK (P) mechanism's holding ability: Shift to PARK
(P). Then release all brakes.
Lap and Shoulder Belts Condition and Operation
Inspect belt system, including: webbing, buckles, latch plates, retractors,
guide loops and anchors. Have
a belt assembly replaced if the webbing has
been cut
or otherwise damaged.
7-38

Downloaded from www.Manualslib.com manuals search engine NOTE: Fluids and lubricants identified below by name, part number or
specification may be obtained from your GM dealer.
USAGE
Engine Oil
Engine Coolant Coolant Supplement
Hydraulic Brake System
Parking Brake Guides
Power Steering System
Automatic Transmission Key Lock Cylinders
Automatic Transmission Shift
Linkage
Chassis Lubrication
FLUID/LUBRICANT
Engine oil with the American Pe-
troleum Institute Certified For Gas-
oline Engines “Starburst” symbol
of
the proper viscosity. To determine
the preferred viscosity for your ve-
hicle’s engine, see “Engine Oil” in
the Index.
Mixture of water and a good quality
ethylene glycol base antifreeze or
an approved recycled coolant con-
forming to GM Specification
GM Part No. 3634621 or equiva-
lent. 6038-M (GM Part
NO. 1052103).
Delco Supreme
11 @ Brake Fluid
(GM Part
No. 1052535 or equiva-
lent DOT-3 brake fluid).
Chassis lubricant (GM Part No.
1052497 or equivalent) or lubricant
meeting requirements
of NLGI
Grade
2, Category LB or GC-LB.
GM Hydraulic Power Steering
Fluid (GM Part
No. 1052884 or
equivalent).
DEXRON@-I11 Automatic Trans-
mission Fluid.
Lubricate
with Multi-Purpose Lu-
bricant (GM Part
No. 12345 120) or
synthetic SAE
5W-30 engine oil.
Engine oil.
Chassis lubricant
(GM Part No.
1052497 or equivalent) or lubricant
meeting requirements of NLGI
Grade 2, Category LB
or GC-LB.
7-40

Downloaded from www.Manualslib.com manuals search engine index
A
Adding Equipment to Your Air Bag-Equipped Vehicle (See “Supplemental
Inflatable Restraint System (SIR)”)
Air Bag (See “Supplemental Inflatable Restraint System (SIR)”)
Readiness Light (See “Lights”)
Air Cleaner (See “Engine-Air Cleaner”)
Air Conditioning (See “Heater/Air Conditioning Controls”)
All-Wheel Drive (Option)
.................................... 2.27, 6.21
How to Check
................................................ 6-21
Whentocheck
............................................... 6-21
Antennacare
................................................... 3-20
Anti-Lock Brakes (See “Brakes”)
Appearance Care
................................................. 6-48
Materials Chart
............................................... 6-56
Arbitration Program (See “Better Business Bureau Mediation”)
Assist Handles
.................................................. 2-47
Care of Your Cassette Player and Tape
............................. 3-19
Care of Compact Discs
......................................... 3-20
Delco LOC II@ Anti-Theft Feature
............................... 3-17
ETR@ AM Radio
.............................................. 3-7
ETR@ AM-FM Stereo Audio Cassette System
....................... 3-9
ETR@ AM-FM Stereo Audio Cassette System with Equalizer
.......... 3-12
ETR@ AM-FM Stereo Audio Compact Disc (CD) System
............. 3-14
ETR@ AM-FM Stereo Audio System
.............................. 3-8
Understanding Radio Reception
.................................. 3-18
Audiosystems
................................................... 3-6
Automatic Transmission
( See “Transmission”)
Axle Front
....................................................... 6-21
LockingRear
................................................. 2-22
Rear
........................................................ 6-22
Battery
........................................................ 6-32
Belts (See “Safety Belts”)
Better Business Bureau Mediation
.................................... 8-3
Beveragecooler
................................................. 2-48
Blizzard (See “Driving-If You’re Caught
in a Blizzard”)
Brakes Adjustment
.................................................. 6-31
Anti-Lock (ABS)
.............................................. 4-6
Anti-Lock Warning Light (See “Lights”)
Master Cylinder
............................................... 6-29
PedalTravel
................................................. 6-31
System Warning Light (See “Lights”)
To Check Brake Fluid
.......................................... 6-30
Trailer (See “Trailer-Brakes”)
Wear
....................................................... 6-31
Parking
..................................................... 2-21
Replacingparts
............................................... 6-32
1