1994 MAZDA MX-5 belt

SEAT BELT s SEAT BELT COMPONENTS L, Removal 1 Installation Caution The ELR has a spring that will unwind if the retractor's cover is removed. The spring cannot be rewound by hand. If this occurs, the ELR will not work properly. Therefore, do not disas- semble the retractor. 1. Remove the brace bar and the quarter trim. (Refer to page S-59,84) 2. Remove in the order shown in the figure. 3. Install in the reverse order of removal. b 1. Seat belt 3. Bezel Inspection ................. page S-64 4. Buckle switch 2. Anchor cover Inspection ................. page S-64 Gartner Banana

s SEAT BELT SEAT BELT lnspection ELF? 1. Verify that the belt can be pulled out smoothly, and that d it moves smoothly when worn. 2. Verify that the retractor locks when the belt is quickly pulled. 3. Remove the retractor. 4. Hold the retractor as it would be installed. 5. Slowly incline the retractor while pulling out the belt. 6. Verify that the retractor locks at approximately 30 degrees inclination. Webbing Inspect the webbing for scars, tears, and wear and for deformation of the fittings. BUCKLE SWITCH lnspection 1. Disconnect the seat belt buckle switch connector. 2. Check for continuity between the switch terminals. I Unbuckled I Yes I Seat belt Buckled 3. If continuity is not as specified, replace the switch. Continuity No d Gartner Banana

SEAT Disassembly 1 Assembly 1. Disassemble in the order shown in the figure. (Refer to Section T for disassembly / assembly of the body sonic seat.) 2. Assemble h the reverse order of disassembly. 1. Reclining knuckle cover 2. Side cover 3. Reclining knuckle 4. Hinge cover 5. Bush 6. Belt anchor unit 7. Hog ring 8. Seatback trim 9. Pad 10. Back frame 11. Headrest speaker (if equipped) Inspection . . . . . . . . . . . . . . . . . . . Section T 12. Seat slide 13. Seat cushion Gartner Banana

CONVERTIBLE TOP s CONVERTIBLE TOP PREPARATION Tools for Repair and Replacement I Hand riveter I For installing top fabric I Ethyl alcohol I For cleaning repaired parts I Adhesive agent K180 WO 313 Repair sheet NAY1 R1 21 1 COMPONENTS Removal 1 Installation 1. Cover both sides of the rear window with thick cloth to protect the window. 2. Remove in the order shown in the figure, referring to Removal Note. 3. Install in the reverse order of removal, referring to Installation Note. For repairing top fabric For repairing top fabric Aluminum rivet $4.0 mm {$0.16 in} 1. Beltline cover 45uosx489 6. Quarter trim Drill $4.0 mm {$0.16 in) Double-sided adhesive tap 45UOSX-088 2. Beltline protector Removal Note ............. page S-60 3. Scuff plate 7. Rear package trim L/ Removal Note ............. page S-60 8. Set plate 4. Seaming welt 9. Convertible top 5. Striker (if equipped) Removal Note ............. page S-68 Installation Note ........... page S-68 For removing For installing top fabric - I For installing top fabric - Gartner Banana

s CONVERTIBLE TOP PUL BRACKET Removal Note Convertible top 1. Unlock the top latch assemblies. 2. Unzip the rear window, and lower the convertible top \- ' fully. Installation Note Convertible top 1. Insert the rain rail into the beltline molding lip, and mount it over the studs. 2. Align and install the link bracket over the studs with no clearance between the studs and the bracket. 3. Tighten the bolts to the specified torque. Tightening torque: lS--2S N.m (1.9--2.6 kgf.m, l5--18 ftlbf) Gartner Banana

CONVERTIBLE TOP S Disassembly l Assembly 1. Disassemble in the order shown in the figure, referring to Disassembly Note. 2. Assemble in the reverse order of disassembly, referring to Assembly Note. - 1. Beltline cover 13. Retainer 2. Beltline protector 14. Set plate 3. Scuff plate 15. End plate Removal 1 Installation ....... page S-59 16. Link assembly 4. Seaming welt 17. Protector 5. Striker (if equipped) 18. Link stopper 6. Quarter trim 19. Open stopper Removal / Installation ....... page S-59 20. Top fabric 7. Stopper Disassembly Note .......... page !3-70 8. Rear package trim Assembly Note ............ page S-74 9. Set plate Repair .................... page S-79 10. Top handle 21. Cable i-/ 11. Top latch assembly 22. Cable guide Adjustment ................ page S-78 23. Striker 12. Weatherstrip 24. Cab side weatherstrip Adjustment ................ page S-79 Gartner Banana

T OUTLINE OUTLINE TROUBLESHOOTING GUIDE Symptom a Speedometer does not operate or indication is incorrect a Tachometer does not operate Water temperature gauge does not operate Fuel gauge does not operate a Oil pressure gauge does not operate a Brake system warning light remains illuminated Brake system warning light does not illuminate when parking brake on a Brake system warning light does not illuminate when brake fluid in reservoir is below MIN a OID off indicator light does not illuminate when OID off switch turned on Seat belt warning light remains on six seconds after ignition switch is turned on (Timer function does not operate) Seat belt warning light does not illuminate when ignition switch is first turned on a Headlights do not illuminate Headlight does not illuminate (Right or left) Retractable headlight actuator do not operate (Both sides) Retractable headlight actuator does not operate (One side) Stoplights do not illuminate (All) Stoplight does not illuminate (One only) Turn and hazard warning functions do not operate Turn signals not operate (Hazard warning function operates normally) Hazard warning function does not operate (Turn signals function normally) Back-up lights does not illuminate Taillights, side marker lights, and license plate lights do not illuminate Daytime running lights do not illuminate Daytime running light function does not cancel lnterior lights do not illuminate Interior liahts remains illuminated (Control switch: DOOR ~osition) Horn does not sound Vehicle speed cannot be set (Cruise control unit will not hold vehicle speed) Speakers do not operate (Without headrest speakers) Speakers do not operate (With headrest speakers) Poor sound quality or noise (Radio) Poor sound quality (Cassette tape player) Cassette tape will not load Cassette tape will not play Compact disc will not load Compact disc skips No sound can be heard Some speakers do not operate Bodysonic will not play Service code table (With passenger-side air bag) Service code table (With out ~assenaer-side air baa) Reference page T-24 T-25 T-26 T-27 T-28 T-36 T-37 T-37 Gartner Banana

T WARNING LIGHT AND SENDER UNIT WARNING LIGHT AND SENDER UNlT STRUCTURAL VIEW 1. Brake system warning light 2. Seat belt warning light 3. Air bag system warning light 4. Retractor indicator light 5. Alternator warning light 6. MIL (malfunction indicator light) 7. O/D OFF indicator light 8. Antilock brake system warning light 9. Washer level indicator light 10. Rear window defroster indicator light Reference Table Warning indicator light SRS air bag system Retractor indicator light Alternator MIL (malfunction indicator light) O/D OFF Antilock brake system Washer level 45UOTX-062 T-34 Reference page or section T-154 T- 48 section G section F section K section P T- 39 J Gartner Banana