1994 MAZDA MX-5 headlights

T LIGHTING SYSTEM I Symptom: Retractable headlight actuators do not operate (Both sides). I Activate the headlight switch and retractor switch and follow the approximate action. d Switch I Headlight switch ON / 'RECTOR Retractor rnotor(s) operate Retractor switch ON Step 1 1. Check RETRACTOR 30A and HEAD 30A fuses in the main fuse block. 2. If a fuse is burned, replace it. Check and repair the wire harness, if necessary. 3. If the fuses are OK, go to Step 2. Actlon Yes No Step 2 1. Disconnect the negative battery cable. 2. Retract the headlights fully by using the manual knobs. 3. Disconnect the retractable headlight actuator connec- tors. 4. Reconnect the negative battery cable. 5. Turn on the headlight switch and retractor switch. 6. Measure the voltage at the following terminal wires of the retractable headlight actuator connectors. Begin troubleshooting from Step 5 Next, turn ON retractor switch 45UOTX-087 Yes No B+: Batterv ~ositive voltage Begin troubleshooting from Step 4 Begin troubleshooting from Step 1 . . - Step 3 1. Disconnect the retractable headlight actuator connec- tors. 2. Check for continuity between the A terminal wire of the retractable headlight actuator connectors and ground. Retractable headlight actuator Left and Right I~ontinui~l headlight actuator Action Voltage (RN) Repair wiring harness (Retractable headlight actuator - GND) Left and Right Check retractable headlight actuator (Refer to oaon T-51) Action B+ Other Go to Step 3 Go to Step 4 Gartner Banana

LIGHTING SYSTEM ADJUSTMENT VERTICAL ADJUSTMENT RETRACTABLE HEADLIGHT ACTUATOR I Adjustment Headlight aiming 1. Adjust the tire air pressure to specification. 2. Turn on the retractor switch to raise the retractable head- 4 lights. 3. Position the unloaded vehicle on a flat level surface. 4. Adjust the headlights to meet local regulations by turning the two adjusting screws. Retractor hinge 1. Fully retracted the headlights. 2. Obtain the code number and deactivate the audio anti- theft function. (Refer to page T-120.) 3. Disconnect the negative battery cable. 4. Disconnect the actuator link. 5. Lower the retractor hinge until the hinge is stopped by the stop. 6. Adjust the stop so that the headlight lid is flush with the fender and hood. Gartner Banana

TECHNICAL DATA 1 Charge I 1.4 Belt 1.4 r. BODY ELECTRICAL SYSTEM 1 Air bag I 2 1 Retractor 1.4 Item Wattage (Bulb trade number) Hold Anti lock Wamlng and indicator lights 1.4 1.4 Washer Rear window defroster Beam Turn (LH and RH) Illumination Malfanction indicator Brake 1.4 1.4 I Exterior lights 3.4 3.4 3.4 x 4 1.4 1.4 Headlights Front turn signawparking lights Front side marker lights License plate lights Rear turn signal lights Rear side marker lights Stop/taillights Back-UP linhts High-mount stoplight I 18.4 (921) ACS 1 1.4 Hazard switch 1.4 60140 2718 (1 157 NA) 3.8 (1 94) 7.5 27 (1 1 56) 3.8 (1 94) 2718 {I 157) 27 (1 1561 Interior llahts - I lllumination lights I Cruise control main switch I 1.4 I 5 Ash tray U. HEATER AND AIR CONDITIONING SYSTEM I Item I Specit lcations I 3.4 Heater control switch ane el I 1.4 STANDARD BOLT AND NUT TIGHTENING TORQUE Refrigerant amount S (04 Compressor oil amount rnl {cc, fl oz) Refrigerant normal pressure MPa (kgflcm2, psi) 600 {2 1.21 130-1 70 {I 30-1 70,3.9-5.1) Low pressure: 0.154.25 (1 .5-2.5,21-361 Hiah Pressure: 1 37-1.57 (1 4--16, 199--228) Gartner Banana