1994 CHEVROLET TRACKER air condition

Maintenance Schedule
S ection A: Scheduled Maintenance Services (Cant.)
Schedule 11
Follow Schedule I1 ONLY if none of
the drivinp conditions specified in
Schedule
I apply.
* An Emission Control Service.
t The US. Environmental Protection Agency
or the California Air Resources Board has
determined that the-failure to pevform this
I I I
WHAT TO SERVICE
See “Explanation of Scheduled
Schedules
I and II.
ITEM NO. Maintenance Services” following
WHEN TO PERFORM
Miles (kilometers) or Months
(whichever occursFrst).
1 Engine Oil and Filter Change* Every 7,500 miles (12 500 km) or 7.5 months.
2 Tire and Wheel Rotation and Inspection Every 7,500 miles (12 500 km).
maintenance item will not nuh& the emission
warranty or limit recall liability prior to the
completion
of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be pevformed at the
indicated intervals and the maintenance be
recorded in “Section
E: Maintenance
Record.
’’
I.. 210
ProCarManuals.com

Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
&planation of Scheduled
Maintenance Services
?allowing are explanations of the services
isted in Schedule
I and Schedule II.
he proper fluids and lubricants to use are
.isted
in Section D. Make sure whoever
rervices your vehicle uses these. All parts
should be replaced and all necessary
repairs done before you or anyone else
~ives the vehicle.
NOTE: To determine your engine’s
displacement and code, see
“Engine Identification” in the
Index.
ITEM
NO. SERVICE
1 -e Oil and Filter Change* -
Always use SH or SG Energy
Conserving
II oils of proper
viscosity. The
“SH” or “SG”
designation may be shown
alone, or in combination with
others, such as “SHKD,”
“SH,
SG, CD,” “SG/CD,” etc.
* An Emission Control Service.
ITEM
NO. SERVICE
2
3
4
To determine the preferred
viscosity for your vehicle’s
engine (e.g.,
SAE 5W-30 or SAE
10W-30), see “Engine Oil” in
the Index.
Tire Wheel Rotation and
Jnspectioq
- For proper wear and
maximum tire life, rotate your
tires following the instructions
in this manual. See
“Ties,
Inspection and Rotation’’ in the
Index. Check the tires for
uneven wear or damage.
If you
see irregular or premature wear,
check the wheel alignment.
Check for damaged wheels also.
Fan (Water Pump) Drive Belt
Servk
- Inspect and adjust if
necessary at
30,000 mile
(50 000 km), or 30 month
intervals. Replace the belt at
60,000 miles (100 000 km) and
120,000 miles (200 000 km).
-shaft Timin? Belt
Replacemeat”
- Replace every
60,000 miles (100 000 km) and
ITEM NO.
SERVICE
then inspect after 30,000 miles
(50 000 km).
Drain, flush and refill the system
with new or approved recycled
coolant conforming to
GM
Specification 182SM. Keep
coolant at the proper mixture
as
specified. See “Coolant” in the
Index. This provides proper
freeze and boil protection,
corrosion inhibitor level and
maintains proper engine
operating temperature.
Inspect hoses and replace
if
they are cracked, swollen or
deteriorated. Tighten screw-type
hose clamps. Clean the outside
of the radiator and air
conditioning condenser. Wash
the pressure cap and neck.
To help ensure proper operation,
we recommend a pressure test
of
both the cooling system and the
nressure cap.
5 Coolin? Sys&nSemice* -
. . ,214
ProCarManuals.com

ITEM
NO. SERVICE
6 Wheel Bearin? InsDection -
Inspect for wear and proper
adjustment. Relubricate the
bearings if grease is
contaminated.
7 Transmission (All) and
Transfer Case Differential
(Four-wheel Drive) Service
-
For the manual transmission and
transfer case differential, check
the fluid level every time the
oil is changed. See “Manual
Transmission Fluid” and
“Transfer Case” in the Index.
Inspect for damage and leaks
and change the fluid every
15,000 miles
(25 000 km) or
15 months for Schedule
I
conditions and every 30,000
miles (50 000 km) or 30 months
for Schedule
II conditions.
For the automatic transmission,
check the fluid level every time
the oil is changed. See
“Automatic Transmission
Fluid” in the Index. Inspect for
damage and leaks and change
ITEM
NO. SERVICE
8
9
the fluid every 15,000 miles
(25 0o0 km) or 15 months for
Schedule
I conditions and
100,000 miles ( 166 000 km) for
Schedule
I1 conditions. Replace
the automatic transmission cooler hoses every
45,000 miles
(75 000 km).
Propeller Shafts and U-Joints
Inspection
- Inspect for
looseness and damage.
Do this
every,.l5 months, or at 15,000
mile
(25 000 km) intervals, more
frequently if used off-road
or for
pulling a trailer. Tighten U-joint
flange bolts if necessary.
Freewheeling Hubs InsDection
/If Equipped) - Inspect the
locking front hubs for correct
operation. Repair or replace if
necessary. (Both hubs must
operate correctly for the front
axle to power the front wheels.)
ITEM
NO. SERVICE
10
11
Spark Plug Replacement” -
Replace spark plugs with the
proper type. See “Replacement Pans” in the Index.
Spark Plup Wire Replacement”
-
Replace wires. Check the boot fit
at the distributor and
at the spark
plugs. Operation in extreme cold
and/or on salted roads may require
more frequent replacement.
* An Emission Control Service.
t The U.S. Environmental Protection Agency
or the California Air Resources Board has
determined that the failure to perform this
maintenance item will not null@ the emission
warranty
or limit recall liability prior to the
completion
of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be pegormed at the
indicated intervals and the maintenance be
recorded
in “Section E: Maintenance
Record.
’’
215 ...
ProCarManuals.com

Maintenance Schedule
Section C: Periodic Maintenance Inspections
Listed below are inspections and services which should be performed at least twice a year (for instance, each spring and fall).
You should let your GM dealer’s service dep,artment or other qualified service center do these jobs. Make sure any necessary
repairs are completed at once.
‘7mi-
OR SERVICE
Restraint Systems
Steering, Suspension
and Front-Wheel-Drive Axle Boot and Seal
Inspection
Exhaust System
Inspection
I
Throttle Linkage
InsDection
I
WHAT SHOULD BE DONE I
Now and then, make sure all your belts, buckles, latch plates, retractors, anchorages and
reminder systems are working properly. Look for any loose parts or damage. If
you see anything
that might keep a restraint system from doing its job, have it repaired.
Inspect the froht and rear suspension and steering system for damaged, loose or missing parts,
signs of wear, or lack of lubrication. Inspect the power steering lines and hoses for proper
hookup, binding, leaks, cracks, chafing, etc. Clean and
then inspect the drive axle boot seals for
damage, tears or leakage. Replace seals if necessary.
Inspect the complete exhaust system. Inspect the body near the exhaust system.
Look for broken,
damaged, missing
or out-of-position parts as well as open seams, holes, loose connections, or
other conditions which could cause a heat build-up in the floor pan or could let exhaust fumes
into the vehicle. See “Engine Exhaust’’ in
the Index.
Inspect
the throttle linkage for interference or binding, and for damaged or missing parts.
Replace parts as needed.
I
223. I
ProCarManuals.com

Maintenance Schedule
Section C: Periodic Maintenance Inspections (cont.)
INSPECTION
OR SERVICE
Rear Axle (All) and
Front Axle (Four-
Wheel Drive) Service
Brake System
Inspection
Clutch System Service
WHAT SHOULD BE DONE
Check the gear lubricant level and add if needed. See “Rear Axle” and “Four-Wheel Drive” in
the Index. A fluid loss may indicate a problem. Check the system(s), and repair the system(s) if
needed. Refer to “Scheduled Maintenance Services,” earlier in
this part, to determine when to
change the lubricant.
Inspect the complete system. Inspect brake lines and hoses for proper hookup, binding, leaks,
cracks, chafing, etc. Inspect disc brake pads for wear and rotors for surface condition. Also
inspect
drum brake linings for wear and cracks. Inspect other brake parts, including drums,
wheel cylinders, calipers, parking brake, etc. Check parking brake adjustment. You may need to
have your brakes inspected more often if your driving habits or conditions result in frequent
braking.
NOTE: A low brake fluid level can indicate worn disc brake pads which may need to be serv-
iced. Also,
if the brake system warning light stays on or comes on, something may be wrong
with either the regular or rear wheel anti-lock brake system, or both systems. See “Brake System
Warning Light” in the Index.
Check clutch pedal free travel and adjust
as necessary. See “Clutch Adjustment” in the Index. ..
. . .224
ProCarManuals.com

Cu.stomer Assistance Information
0 Up to $30 maximum daily CAB,
BUS, or OTHER public transportation
allowance
in lieu of rental for any
overnight warranty repair up to
5 days.
OR
0 Up to $10 daily FUEL allowance for
rides provided by another person (i.e.,
friend, neighbor, etc.) in lieu
of rental
or other public transportation for
any overnight warranty repair up to
5 days.
Note: All Courtesy Transportation
arrangements
will be administered by
your ChevroletIGeo dealership service
management.
Claim amounts should
reflect all actual costs.
0 ChevroletlGeo Courtesy
Transportation is not
part of the
BUMPER TO
BUMPER New Vehicle
Limited Warranty. Chevrolet‘Geo
reserves the right to make any
changes or discontinue Courtesy
Transportation at any
time without
notification.
For additional program details, contact
your ChevroletlGeo dealer.
In Canada, please consult your GM
Dealer for information on courtesy
transportation.
. . .238
Service Publications
[nformation on how to obtain Product
Service Publications (PSP’s) and Indexes
3s described below is applicable only in
$e
fifty U.S. states (and the District of
Columbia) and only for cars and light
trucks with GVWR less than 10,000
pounds
(4 536 kg).
[n Canada, information pertaining to
Product Service Bulletins and Indexes
can be .obtained by writing to:
General Motors of Canada Limited
Service Publications Department
1908 Colonel Sam Dr.
Oshawa, Ontario L1H 8W
Chevrolet/Geo regularly sends its
dealers useful service bulletins about
ChevroletlGeo products. ChevroletlGeo
monitors product performance
in the
field. We then prepare bulletins for
servicing our products better. Now, you
can get these bulletins too.
Bulletins cover various subjects. Some
pertain to the proper use and care
of your
vehicle. Some describe costly repairs.
Others describe inexpensive repairs
which, if done on time with the latest
parts, may avoid future costly repairs.
Some bulletins tell a technician how
to
:epair a new or unexpected condition.
3thers describe a quicker way to fix your
vehicle. They can help a technician
service your vehicle better.
Most bulletins apply to conditions
affecting a small number of cars or trucks.
Your Chevrolet/Geo dealer or
a qualified
technician may have to determine if a
specific bulletin applies
to your vehicle.
[ndividual PSP’s
If you don’t want to buy all the PSP’s
issued by ChevroletlGeo for all car
or
truck models in the model year, you can
buy individual PSP’s, such as those which
may pertain
to a particular model. To do
this, you will first need to see our
index of PSP’s. It provides
a variety of
information. Here’s what you’ll find in
the index and how you can get one:
What You’ll Find in the Index:
0 A list of all PSP’s published by
ChevroletlGeo in
a model year (1 990
or later). PSP’s covering all models
of ChevroletlGeo cars or light trucks
(less than
10,000 pounds (4 536 kg)
GVWR) are listed in the same index.
ProCarManuals.com

A bout Driving Your Tracker ..... 3
ABS ......................... 103
Adding Coolant ................ 171
Additives. Engine
Oil ............ 165
Adjustment. Clutch
............. 169
Air Cleaner .................... 165
Air Conditioner Controls
......... 85
Air Filter Replacement
........... 166
Air Intake Lever ................ 84
Airflow Lever
.................. 84
Alignment and Tire Balance
.
Wheel ...................... 187
Aluminum Wheels
.............. 193
AM/FM Stereo
................ 88
With Cassette Tape and Compact
Disc Player
................ 93
With Cassette Tape Player ...... 89
Antenna
...................... 98
Anti-Lock Brakes
.............. 103
To Use ..................... 103
Appearance Care ............... I89
Appearance Care and Materials
.... 195
Appearance Care. Service and
..... 155
Approaching
a Hill .............. 1 10
Ashtrays and Lighter ............ 62
Ashtray. Front
................. 63
Ashtray. Rear .................. 63
Assist Grips. Passenger .......... 62
Add-on
Electrical Equipment
..... 196
Adjustable Steering Column
...... 53
Audio Systems ................. 87
Audio Systems. Comfort
Controls and
................. 83
Automatic
Freewheeling Hubs
........... 47
Transmission
................ 42
Transmission Fluid ............ 167
Axle. Front
.................... 170
Axle
. Rear .................... 169
Babies. Smaller Children
and (Safety Belts)
............. 26
Balance. Wheel Alignment
and Tire
.................... 187
Battery
....................... 176
BBB Auto Line
- Alternative Dispute
Resolution Program. GM
Participation
in ............. 235
Before Leaving
on a Long Trip .... 120
Belt. Lap-Shoulder .............. 20
Bi-Level ...................... 84
Bin. Coinholder and ............. 61
Bins. Instrument Panel ........... 61
Blizzard. If You’re Caught in a ... 124
Box. Glove
.................... 60
Brakes
Adjustment
.................. 176
Anti-Lock (ABS)
............. 103
Fluid ....................... 1 74
Master Cylinder
.......... 174
Parking
......... 48 Brakes
Pedal Travel
................. i76
System Parts. Replacing ........ 176
System Warning Light
......... 69
Trailer ...................... i27
Wear ...................... 175
Braking (Control of
a Vehicle) ..... 102
Braking
in Emergencies .......... 104
“Break.In. .. New Vehicle ........ 39
Bright Metal Parts. Protecting
Exterior
.................... 192
Brightness Control
.............. 57
Bulb Replacement .............. 177
Stoplight .................. 181
Headlights .................. 177
Rear Combination
............ 180
Rear Sidemarker
.............. 179
Sidemarker ......... . .179
Bulbs. Halogen
............... 177
Bulbs. Replacement
............. 199
Canadian Roadside Assistance ... 237
Canvas Top
Preparing for Storage
.......... 80
Special Care for
.............. 193
Capacities and Specifications
...... 200
Carbon Monoxide .............. 51
Center High-Mounted
Front Parking and Turn Signal
... 178
Removing and Installing Your
... 76
243 ...
ProCarManuals.com

Index
Care Appearance
................. 189
Canvas Top
.................. 193
Cassette Tape Player .......... 97
Compact Discs
............... 98
Safety Belts
................. 191
Case. Transfer ................. 47
Case. Transfer (Service)
.......... 170
and Cornpact Disc Player
..... 94
Player
.................... 90
AM/FM Stereo with ........... 93
Stereo with ................ 89
ofYour
..................... 97
Certification/Tire Label .......... 18 1
Chains. Tire ................... 188
Changing a Flat Tire
............. 146
Charging System Light
.......... 70
Check Engine Light
............. 71
Cassette
Tape. To Play a
AM/FM Stereo with Cassette Tape
AM/FM Stereo with Cassette Tape
Cassette Tape and Compact Disc Player.
Cassette Tape Player. AM/FM
Cassette Tape Player. Care
Checking Things under the
Hood
....................... 159
Checking Your Restraint Systems . . 33
Chemical Paint Spotting
.......... 194
Chevrolet/Geo Roadside Assistance Program
.................... 237
... 244
Chevrolet/Geo Service Publications
(Ordering Information)
........ 240
Child Restraints
.............. 27
Rear Seat
.............. . 28
Right Front Seat
............ 30
Top Strap
................... 28
Where to Put the
.............. 27
Children (Safety Belts)
........... 26
Children. Larger (Safely Belts)
.... 32
Cigarette Lighter ............... 62
Circuit Breakers. Fuses and ....... 196
City Driving ................... I19
Cleaner. Air ................. 165
Cleaning
Aluminum Wheels
........ 193
Canvas Top
.................. 193
Fabric
...................... I90
Glass
....................... 191
Inside of Your Geo ............ 189
Instrument Panel. Top of
....... 19 1
Leather ..................... 19 1
Outside of Your Geo .......... 192
Problems. Special
............. 190
Vinyl
...................... 191
Clock. Setting the ............... 88
Clutch Adjustment
.............. I69
Coinholder and Bin ............. 61
Comfort Controls
............... 84
Comfort Controls and Audio Systems
.................... 83
Windshield and Wiper Blades ... 192 Compact
Disc.
To Play a ......... 95
with Cassette Tape and
......... 93
Compact Disc Player. AM/FM Stereo
Compact Discs. Care
of Your ...... 98
Compartments. Door Storage ...... 60
Compartments. Storage and ....... 60
Control of a Vehicle ............. 102
Control.
Loss of ................ 107
Controls Air Conditioner
.............. 85
Brightness .................. 57
Comfort
.................... 84
Features and
................. 35
Heater ...................... 84
Seat ........................ 10
Convertible Top
................ 72
Convex Outside Mirror
..... 59
Coolant Adding
..................... 171
Heater. Engine ............... 41
Recovery Tank
............. 142
Cooling
....................... 85
Cooling System ................ 141
Courtesy Transportation .......... 237
Cupholder
..................... 61
Curves. Driving on .............. 104
Engine
..................... 170
How to Add
to the Coolant
How to Add
to the Radiator ..... 144
Temperature Gage. Engine ...... 70
ProCarManuals.com