1994 CHEVROLET CAMARO service

Downloaded from www.Manualslib.com manuals search engine Problems on the Road
9.
0.
Attach the cable at least 18 inches
(45 cm) away from the dead battery,
but not near engine parts that move.
The electrical connection is just
as
good there, but the chance of sparks
getting back to the battery is much
less.
Now start the vehicle
with the good
battery and
run the engine for a
while.
-. 152
1.
2.
Try to start the vehicle with the dead
battery.
If it won't start after a few tries, it
probably needs service.
Remove the cables
in reverse order
to prevent electrical shorting. Take
care that they don't touch each other
or any other metal.
A. Heavy Metal Engine Part
B. Good Battery
c. Dead Battery
A
I Towing Your Vehicle
?y to have a GM dealer or a professional
]wing service tow your Chevrolet. The
sua1 towing equipment is a sling-type
A) or a wheel-lift (B) or car carrier (C)
3w truck.
f your vehicle has been changed or
nodified since
it was factory-new by
Idding aftermarket items like fog lamps,
Lero skirting, or special tires and wheels,
hese instructions and illustrations may
tot be correct.
3efore you do anything, turn on the
lazard warning flashers.

Downloaded from www.Manualslib.com manuals search engine When you call, tell the towing service:
0 That your vehicle cannot be towed
from the front or rear with sling-type
equipment.
drive.
That your vehicle has rear-wheel
0 The make, model, and year of your
0 Whether you can still move the shift
0 If there was an accident, what was
When the towing service arrives, let the
tow operator know that this manual
contains detailed towing instructions and
illustrations. The operator may want
to
see them.
vehicle.
lever.
damaged.
153 .I I.

Downloaded from www.Manualslib.com manuals search engine Problems on the Road
When your vehicle is being towed, have
the ignition key off. The steering wheel
should be clamped
in a straight-ahead
position, with a clamping device designed
for towing service. Do not use the
vehicle’s steering
column lock for this,
The transmission should be in “Neutral”
and the parking brake released.
Don’t have your vehicle towed on the rear
wheels, unless
you must. If the vehicle
must be towed on the rear wheels, don’t
go more than 35 mph (55 km/h) or
farther than
50 miles (80 km) or your
transmission will be damaged. If these
limits
must be exceeded, then the rear
wheels have to be supported on a
dolly.
?ront Towing Hook-Ups
Ittach T-hook chains to slots in frame
*earward of front wheels on both sides.
NOTICE:
Do not attach winch cables or “J”
hooks to suspension components
when using car carrier equipment.
Always use T-hooks inserted in the
T-hook
slots.
. . .154

Downloaded from www.Manualslib.com manuals search engine Problems on the Road
NOTICE:
If your engine catches fire because
you keep driving with
no coolant,
your vehicle can be badly damaged.
The costly repairs would not be
covered by your warranty.
If No Steam Is Coming from Your
Engine:
If you get the overheat warning but see or
hear no steam, the problem may not be
too serious. Sometimes
the engine can gel
a little too hot when you:
0 Climb a long hill on a hot day.
0 Stop after high speed driving.
0 Idle for long periods in traffic.
Tow a trailer.
If you get
the overheat warning with no
sign of steam,
try this for a minute or so:
1. If you have an air conditioner, turn it
2. Turn on your heater to full hot at the
off.
highest fan speed and open
the
window as necessary.
3. Tr!
to keep your engine under load
(in a drive gear where the engine runs
slower).
[f you no longer have the overheat
warning, you can drive. Just to be safe,
drive slower for about ten minutes. If the
warning doesn’t come back on,
you can
drive normally.
[f the warning continues, pull over, stop,
and park your vehicle right away.
If there’s still no sign of steam, you can
idle the engine for two or three minutes
while you’re parked, to see if the warning
stops. But
then, if you still have the
warning, TURN
OFF THE ENGINE
AND GET EVERYONE
OUT OF THE
VEHICLE until it cools down.
You may decide not to lift the hood but to
get service help right away.
Cooling System
When you decide it’s safe to lift the hood,
here’s what you’ll see on the
V6 engine:
1. Coolant recovery tank
2. Radiator pressure cap
3. Electric engine fan
. . .158

Downloaded from www.Manualslib.com manuals search engine On the V8 engine you’ll see this:
1. Coolant recovery tank
2. Radiator pressure cap
3. Electric engine fans
A CAUTION:
An electric fan under the hood can
start up even when the engine is not
running and can injure
you. Keep
hands, clothing and tools
away from
any underhood electric fan.
II
If the coolant inside the coolant recovery
tank is boiling, don’t do anything else
until it cools down.
When
it is cool, remove the coolant
recovery tank cap and look at
the dipstick.
The coolant level should be at or above
“FULL COLD.” If it isn’t, you may have
a leak
in the radiator hoses, heater hoses,
radiator,
water pump or somewhere else
in the cooling system.
A CAUTION:
Heater and radiator hoses, and other
engine parts, can be very hot. Don’t
touch them. If you do, you can be
burned.
Don’t
run the engine if there is a
leak. If you run the engine, it could
lose all coolant. That could
cause an
engine fire, and you could be burned.
Get any leak fixed before you drive
the vehicle.
NOTICE:
Engine damage from running your
engine without coolant isn’t covered
by your warranty. I
If there seems to be no leak, check to see
if the electric engine fan is running. If the
engine
is overheating, the fan should be
running.
If it isn’t, your vehicle needs
service.
159. I

Downloaded from www.Manualslib.com manuals search engine Problems on the Road
3. Shut the engine off and replace the
pressure cap. Be sure the arrows on
the cap line up like this. 10. Then fill the coolant recovery tank
For
a complete drain, flush and refill,
see your Chevrolet dealer or a Chevrolet
Camaro Service Manual.
To purchase a
service manual, see “Service
Publications’’ in the Index.
to
the proper level.
If Q Tire Goes Flat
It’s unusual for a tire to “blow out” while
you’re driving, especially if you maintain
your tires properly. If air goes out of a
tire, it’s much more likely to leak out
slowly. But if
you should ever have a
“blowout,’’ here are a few tips about what
to expect and what to do:
If a front tire fails, the flat tire will create
a drag that pulls the vehicle toward that
side. Take your foot off the accelerator
pedal and grip the steering wheel firmly.
Steer to maintain lane position, then
gently brake to a stop well out of the
traffic lane.
A rear blowout, particularly on a curve,
acts much like
a skid and may require the
same correction you’d use in a skid. In
any rear blowout, remove your foot from
the accelerator pedal. Get the vehicle
under control by steering the way
you
want the vehicle to go. It may be very
bumpy and noisy, but you can still steer.
Gently brake to
a stop, well off the road
if possible.
If your tire goes flat,
the next section
shows how to use your jacking equipment
to change a flat tire safely.
. . ,166

Downloaded from www.Manualslib.com manuals search engine Here you will find information
about the care of your
Chevrolet
. This part begins with
service and fuel information.
and then
it shows how to check
important fluid and lubricant
levels
. There is also technical
information about your vehicle.
and a section devoted to its
appearance care
.
Part 0
Service & Appearance Care
Service .........................................................
Fuel ...........................................................
Checking Things under the Hood ....................................
HoodRelease ..................................................
EngineOil ....................................................
Aircleaner ...................................................
Automatic Transmission Fluid .....................................
Manual Transmission Fluid .......................................
Hydraulic Clutch ...............................................
RearAxle .....................................................
Enginecoolant ................................................
Power Steering Fluid ............................................
Windshield Washer Fluid .........................................
Brake Master Cylinder ...........................................
Battery .......................................................
Bulb Replacement ................................................
LoadingYourVehicle .............................................
Tires ...........................................................
Appearancecare .................................................
Appearance Care and Maintenance Materials ...........................
Vehicle Identification Number (VIN) .................................
Service Parts Identification Label ....................................
Add-on Electrical Equipment .......................................
Fuses and Circuit Breakers .........................................
Replacement Bulbs ...............................................
Capacities and Specifications .......................................
180
181
184
184
187 191
194
196
197
197
198
200
201
202
204
205
212
214
220
226
227
227
227
227
231
232
179 ...

Downloaded from www.Manualslib.com manuals search engine Service and Appearance Care
AC1 GM -
Service
Your Chevrolet dealer knows your vehicll
best and wants you to be happy with it.
We hope you’ll
go to your dealer for all
your service needs. You’ll get genuine
GM parts and GM-trained and supported
service people.
We hope you’ll want to keep your
GM
vehicle all GM. Genuine GM parts have
one of these marks.
Doing Your Own Service Work
If you want to do some of your own
service work, you’ll want to get
the
proper Chevrolet Service Manual. It tells
you much more about how to service your
Chevrolet than this manual can.
To order
the proper service manual, see “Service
Publications” in the Index.
Your vehicle has an air bag system.
Before attempting to do your own service
work, see “Servicing Your Air Bag
-
Equipped Chevrolet” in the Index.
You should keep a record with all parts
receipts and list
the mileage and the date
of any service work you perform. See
“Maintenance Record” in the Index.
. . .I80