1993 CHEVROLET TRACKER oil

Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
ITEM
NO. SERVICE
16 Emission System Hoses Inspection* - Inspect at
60,OOO mile (lo0 OOO km) intervals.
17 Catalytic Converter Inspection* - Inspect at
100,OOO mile (166 OOO km) intervals. At each oil
change, inspect the entire exhaust system for leaks
and loose fittings, especially if the vehicle is used
off-road.
*An Emission Control Service.
9 9 294
ITEM
NO. SERVICE
18 Power Steering System Inspection - Check the
power steering gear box, pump and hose connections
for leaks
or damage. Check the fluid level on the
dipstick.
See “Power Steering Fluid” in the Index.
Check the drive belt for cracks, fraying and wear.
Check belt tension. There should be
0.24”-0.35”
(6-9 mm) deflection when you press your thumb
midway between the pulleys. Adjust or replace belt
as needed.
ProCarManuals.com

NO.
1
2
3
SERVICE
Wheel Bearings Inspection - Inspect every
15 months, or at 15,000 mile (25 OOO km) intervals.
Inspect for wear and proper adjustment. Relubricate
the bearings
if grease is contaminated.
Propeller Shafts and U-Joints
Inspection
- Inspect for looseness and damage. Do
this every 15 months, or at 15,000 mile (25 000 km)
intervals, or more frequently if used off-road or
pulling a trailer. Tighten U-Joint flange bolts if
necessary.
Clutch (Manual Transmission Only) - At each oil
change, inspect for correct free play and positive
engagement. See “Clutch Adjustment’’
in the Index.
Maintenance Schedule
Uther Nun-Emissun Related Maintenance
Service
ITEM
4 Tire and Wheel Inspection and Rotation - For
proper wear and maximum tire life, rotate your tires
at
7,500 miles (12 500 km) and then every
15 ,OOO miles (25 OOO km). See “Tires, Inspection
and Rotation”
in the Index. Check the tires for
uneven wear or damage. If you see irregular or
premature wear, check the wheel alignment. Check
for damaged wheels also.
While the tires and wheels are removed for rotation,
perform
the brake system inspection described in
Section C.
ProCarManuals.com

5
6
Brakes - Tire rotations are a convenient
opportunity
to inspect the braking system. See
“Brake System Inspection”
in Section C.
Locking Front Hubs Inspection (If Equipped) -
At each oil change, inspect the locking front hubs
for correct operation. Repair or replace
if necessary.
(Both hubs must operate correctly for the front axle
to power
the front wheels.)
7 Steering and Suspension - At each oil change,
inspect the steering linkage and suspension for leaks
and damage. Repair or replace damaged or worn
parts.
ProCarManuals.com

Maintenance Schedule
Section B: Owner Checks and Services
Listed below are owner checks and services which should be
performed at the intervals specified to help ensure the
safety, dependability and emission control performance of
your vehicle. Be
sure any necessary repairs are completed at once.
Whenever any fluids or lubricants are added to your vehicle,
make sure they are the proper ones, as shown
in Section D.
Af Each Fuel fj// (It is important for you or a service station attendant to perform these underhood checks at \
each fuel fill.)
1
CHECK
1 OR SERVICE I WHAT TO DO
I Engine Oil Level Check the engine oil level and add the proper oil if necessary. See “Engine Oil” in the Index for
further details.
I
I Engine Coolant Level Check the engine coolant level in the coolant recovery tank and add the proper coolant mix if
1 necessary. See “Coolant” in the Index for further details.
Windshield Washer
Fluid Level
Hood Latch
Operation Check
the windshield washer fluid level in the windshield washer tank and add the proper fluid if
necessary. See “Windshield Washer Fluid” in the Index for further details.
Pull the primary hood latch release handle inside the vehicle. The secondary latch should keep
hood from opening all the way when the primary latch is released. Make sure the hood closes
firmly. See
“Hood Release” in the Index for further details.
... 298
ProCarManuals.com

Maintenance Schedule
Section D: Recommended Fluids and Lubricants
Note: Fluids and lubricants identified below by name, part number or specification may be obtained from your GM dealer.
USAGE
Engine Oil
Engine Coolant
Hydraulic Brake
System
Parking Brake Guides
Power Steering System
Automatic Transmission
Wheel Bearings
FLUID/LUBRICANT
GM Goodwrench Motor Oil or equivalent for API service SG Energy Conserving I1 oils of the
recommended viscosity. The SG designation may be shown alone or in combination with others,
such as
SG/CC, SG/CD, or SF, SG, CC, etc. To determine proper viscosity for your vehicle’s
engine, see
‘ ‘Engine Oil” in the Index.
50/50 mixture of water (preferably distilled) and good quality ethylene glycol base antifreeze
(GM Part
No. 1052753) conforming to GM Specification 6038M or approved recycled coolant
conforming to GM Specification 6038M.
Delco-Supreme 1
l@ Brake Fluid (GM Part No. 1052535) or equivalent DOT-3 brake fluid.
~~
Chassis lubricant meeting requirements of NLGI Grade 2, Category LB or GC-LB (GM Part No.
1052497 or equivalent).
DEXRONB-I1 Automatic Transmission Fluid (GM Part
No. 1051855) or equivalent.
DEXRON*-I1 Automatic Transmission Fluid (GM Part
No. 1051855) or equivalent.
3.
-
-
305 9 -
Wheel bearing grease meeting requirements of NLGI Grade 2, Category GC or GC-LB (GM Part
No. 105 1344 or equivalent).
ProCarManuals.com

Maintenance Schedule
Section D: Recommended Fluids and Lubricants (Cont.)
USAGE FLUID/LUBRICANT
I Manual Transmission I SAE 75W-90 GL-4 (GM Part No. 12345871 Castrol@ Syntorq GL-4 or equivalent). I
Manual Transmission Chassis lubricant meeting requirements of NLGT Grade 2, Category LB or GC-LB (GM Part No.
Shift Linkage 1052497 or equivalent).
Key Lock Cylinders Lubricate with Multi-Purpose Lubricant (GM Part
No. 12345120) or synthetic SAE 5W-30 engine oil
or silicone lubricant (GM Part No. 1052276 or 1052277).
Automatic Transmission Engine oil.
Shift Linkage
Clutch Linkage Pivot Lithium base grease.
Points
Floor Shift Linkage Engine oil.
~~ ~ ~ ~~~
Chassis Lubrication Chassis lubricant meeting requirements of NLGI Grade 2, Category LB or GC-LB (GM Part No.
Windshield Washer Sol- GM Optikleen@ Washer Solvent (GM Part No. 1051515) or equivalent.
vent
Rear Axle (All)
SAE 75W-90 GL-5 Hypoid Gear Lubricant (GM Part No. 12345977).
Front Axle (Four-wheel
Drive) 1052497
or equivalent).
ProCarManuals.com

USAGE
Transfer Case (Four-wheel Drive)
Hood Latch Assembly
a. Pivots and Spring
b. Release Pawl
Anchor
Hood, Door,
and
Liftgate Hinges, Rear Folding Seat,
Fuel Door
Hinge, Rear Compart-
ment Lid Hinges
Weatherstrips Constant Velocity
Universal Joint
FLUID/LUBRICANT
SAE 75W-90, GL-4 gear lubricant (GM Part No. 12345871).
a. Engine oil.
b. Chassis lubricant meeting requirements
of NLGI Grade 2, Category LB or GC-LB
(GM Part No.
1052497 or equivalent).
Engine oil.
Dielectric Silicone Grease (GM Part
No. 12345579) or equivalent.
Chassis lubricant meeting requirements
of NLGI Grade 2, Category LB or GC-LB (GM Part No.
1052497 or equivalent).
See “Replacement Parts” in the Index for recommended replacement filters, valves and spark plugs.
307
ProCarManuals.com

In Mud. Sand. Snow. or Ice ...... 155
In the Rain
.................... 160
In Water ...................... 156
Long Distance
................. 167
On Curves
.................... 132
On Grades (With a Trailer)
....... 184
On Off-Road Hills.
............. 145
On Snow or Ice
................ 174
On the Freeway
................ 165
Suggestions.
A Few More Night . . 159
Uphill
........................ 147
Winter
....................... 173
With a Trailer
................. 182
Drunken Driving
................ 123
Easy Entry Seats
................. 14
Electrical Equipment. Add-on
...... 272
Emergencies. Braking
in .......... 132
Emergencies. Steering
in ......... -134
Engine
Coolant
...................... 240
Coolant Temperature Gage
........ 85
Exhaust
....................... 64
Identification
.................. 272
Oil
.......................... 229
Oil Pressure Light
............... 86
Overheating
................... 200
Specifications
................. 277
Starting Your
................... 49
Through
Deep Standing Water
..... 50 Environment.
Your Vehicle and the
. 282
Exhaust. Engine
.................. 64
Extender. Safety Belt
.............. 39
Fabric Protection
.................... 264
Using Solvent-Type Cleaner on
... 263
Features and Controls
.............. 43
Filling Your Tank (Fuel)
.......... 226
Filter Replacement. Air
........... 234
Flashers. Hazard Warning
......... 190
Flat Tire. Changing a
............. 208
Flat. If a Tire Goes
............... 208
Fluid Using Foam-Type
Cleaner on
..... 263
Five-Speed Manual Transmission
.... 54
Flow-Through Ventilation System
... 106
Automatic Transmission
......... 234
Manual Transmission
........... 237
Recommended
............ 27 1. 305
Windshield Washer
............. 244
Fog. Tips
on Driving in ........... 163
Folding Rear Seats
................ 15
Following Distance (With
a Trailer)
..................... 183
Foreign Countries. Fuels
in ........ 225
Four-wheel Drive
........... .57. 239
Power
Steering
................ 243
Fog. Mist and Haze. Driving
in ..... 162
Foreign Material Paint Damage
..... 269 Four-Wheel-Drive
Vehicle.
Freeway Off-Road
Driving with Your Geo
. . 140
Driving
...................... 165
Driving on the
................. 165
Entering the
................... 165
Leaving the
................... 165
Free-Wheeling Hubs
.............. 58
Automatic
..................... 59
Manual
........................ 59
Fuel
........................... 223
FuelGage
....................... 83
Fuel Tank Filling
................ 226
Fuels
in Foreign Countries ......... 225
Fuse Block. Instrument Panel
...... 275
Fuse Block. Main
................ 274
Fuses and Circuit Breakers
......... 273
Gage. Engine Coolant Temperature
. . 85
Gage. Fuel
...................... 83
Gages and Indicators. Warning
Lights
......................... 82
Gasolines for Cleaner Air
.......... 224
Glass Cleaning
.................. 266
GloveBox
....................... 75
GM Participation
in Better
Business Bureau Mediation/
Arbitration Program
............ 315
Grips. Passenger Assist
............ 76
Guidelines. Utility Vehicle Driving
. . 140
327 9
ProCarManuals.com