1992 VOLKSWAGEN TRANSPORTER coolant level

Downloaded from www.Manualslib.com manuals search engine
DASHBOARD
AND
CONTROLS
Warning lamps

Symbol Page Symbol
Page
Coolant temperature/
Coolant level
47

A Emergency light system
51
Engine oil pressure f^i
47

m Rear
window
heating
51

ID
Headlight
high
beams

48

to Fog lights
rear fog light 51

Turn
signals
49

Notes
((D)
Brake
system l^i

48
•
If one of the lamps marked
with
comes on when driving
stop and switch engine off. Details can be found on the pages
given

B Some of the lamps shown here are
only
on certain models or are optional extras.

£3

Alternator
49 •
If one of the lamps marked
with
comes on when driving
stop and switch engine off. Details can be found on the pages
given

B Some of the lamps shown here are
only
on certain models or are optional extras.
m Glow plugs - Diesel

49
(©)
Anti-locking brake system (ABS)

49


Trailer turn signals

49
6
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND EQUIPMENT

2
-
Coolant temperature
—
~~s
gauge starts
to
work
when ignition
is
=
.vitched on,
but it
takes some time before
~e needle reaches
its
final position.
-en ignition
is
switched
on the
warning
c~ip flashes
for a few
seconds
as a
func-

•
:nal check.

5
- Cold

-. Did
high
engine speeds and
do not
work

r-gine
too
hard
yet.

:
- Normal

nen
the
vehicle
is
driven normally
the

~eedle
should settle
down
in
this zone.
-en engine
is
working hard and the ambi-

r~t
temperature
is
high,
the
needle
may
-ove
a
long
way up. This is not serious as long as the
warning lamp does not flash.
Warning lamp
If
the lamp flashes when driving, check first
the indicated coolant temperature.

If the
needle
is in the
normal zone,
top the

coolant
up at the
next
opportunity.

If
the reading
is
in the upper zone, either the
coolant level
is too low or the
coolant tem­
perature
is too
high.
Stop,
switch
en­
gine off
and
try to
find cause
of
trouble
-

see
page 47.

Notes

•
Additional
lights
in
front
of the cooling air intake interfere
with
the

flow
of cooling air. At
high
ambient
temperatures and
full
throttle
there is a danger that the engine
will
then
overheat.
3
-
Digital clock
*

To
set the
time there
are two
buttons
on
lower left
of
instrument cluster.
The
hours
are
set
with
the
upper button
(h) and the
minutes
with
the
lower one
(min):

•
If
pressed briefly, preferably
with
a ball
pen,
the time changes one hour
or
one min­

ute.
•
If
pressed continuously the hours
or
min­
utes
change continuously.

With
the minute button the clock can be set exactly
to the
second:

•
Press button until time shown
by
clock
is
one minute before time
to be set.

•
Press button
at the
moment when
the
seconds
indicator
of an
accurate clock
shows a full minute
or
when the time signal
is
heard
on the
radio.
41
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

Warning
lamps

~ne layout of the warning lamps depends on
:ne model and the engine fitted. The sym-
: ols shown here are also on the actual warn-ng lamps.
|- Coolant temperature/ coolant level 47
1- Engine oil pressure 47
I- High beams 48
-- Turn signals 48

5-
Brake system 48
V Alternator 49
" Glow plugs 49 Coolant
temperature/

Coolant level1'

This
lamp flashes for a few seconds as a
functional check when ignition is switched
on.

If the lamp does not go out afterwards or

flashes
when driving, either the coolant
temperature is too high orthe coolant level1'
too low:
Stop,
switch
engine
off and check

level.
Add coolant if necessary.
11 Only on vehicles
with
automatic coolant level monitor(see page 102).
Attention

• Be
careful
when
opening the

coolant
expansion
tank!
When
the
engine
is hot the cooling
sys­

tem is
under
pressure -
Danger
of scalding!
Therefore
let
engine
cool
down
before
unscrewing

the cap.
• Do not
touch
the fan. The fan can
switch
on suddenly -
even

when
ignition
is
switched
off.

For
further details see pages 102 and 103.
If the coolant level is in order the trouble
may be due to failure of the radiator fan.

Check
radiator fan fuse and renew if
necessary-seepage
122.
If the warning lamp does not go out al­
though coolant level and fan fuse are in order, do not
drive
on - call in expert as­

sistance.

If the trouble is only caused by the fan and

assuming
coolant level is in order and tem­ perature warning lamp is out - one can drive
on to the nearest Volkswagen dealer. In
order to make good use of the air stream for

cooling,
do not let engine idle or drive very
slowly.
2 - Engine oil pressure -7
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
GENERAL
MAINTENANCE
nere are two marks
with
which the oil level
:an be
checked.

• Outside on container (Fig.) • Inside on dipstick attached to the cap. ~he oil level should always be between the
MAX."
and "MIN" marks. When the level

"as
dropped down below the "MIN" mark

:^e
power assisted steering should be
:necked
at a Volkswagen dealer. It is not
sufficient merely to top up
with
hydraulic oil.

Note
f the power assisted steering fails at any
: me or when engine is not running (vehicle on tow) the vehicle remains fully steerable cut more force must be used to
turn
the
steering wheel. Cooling
system

Under
normal conditions the cooling
sys­

tem is almost maintenance-free.
The vehicle is
fitted
with
a hinged radiator
which can be folded forward when required
- see page 104.
The cooling system is filled at the factory
with
a permanent coolant which is not

changed.
The coolant consists of water and

a
40 % concentration of our coolant additive
G
11 V8B (anti-freeze on glycol basis
with

anti-corrosion additives). This mixture not
only gives the necessary frost protection
down to -25 degrees C but also protects the
alloy parts in the cooling system against cor­
rosion.
In addition it prevents scaling and ra­
ises
the boiling point of the coolant.
The concentration of the coolant therefore must not be reduced in the summer or in
warm countries, by topping up
with
plain
water. The
coolant
additive
propor­

tion
must
be at
least
40 %.
If greater protection against frost is re­
quired, the proportion of G 11 V8B additive

can
be increased, but only up to 60 % other­
wise the anti-freeze protection is reduced
and furthermore the cooling effect is im­
paired.
Vehicles
for export to cold countries -s~a .
have frost protection down to -35 decrees

C.

Only
our G 11 V8B or an additive v/rs :~e

specification
TL-VW 774 B (markea or
container) should be added to the coolant.
The additives can be obtained from
Volks­

wagen dealers.

Other
additives
can be
very
detri­

mental
to the
anti-corrosion
effect
in
particular.

The
subsequent
corrosion
damage
can
lead
to
coolant
loss
resulting
in

major
engine
damage.
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
GENERAL
MAINTENANCE

Checking
coolant
level

The
expansion tank
is in the
engine
com­
partment on the bulkhead
-
see Fig.

The
correct coolant level
is
essential
to
the satisfactory operation
of
cooling system.
For
this reason, the coolant level should
be

checked
regularly,
and
this
is
best done
when refueling.

The
level
can
only
be
checked properly
when engine
is
not running.

The
coolant level must be between the MIN
and
MAX marks
on the
expansion tank
when engine
is
cold
and can be
slightly
above
the MAX mark when
it
is warm.
When
the
coolant level
is too low on ve­

hicles
with
an automatic coolant level moni­
toring device,
it is
indicated by the coolant
temperature/coolant level warning lamp
flashing continuously (see page 47).

Coolant
losses

Coolant
loss normally indicates leaks in the

system.
In
this
case
the
cooling system
should
be checked by a Volkswagen dealer

without
delay.
It is
not sufficient merely
to

add
coolant.
In
a
sealed system
losses
can only occur
if

the boiling point
of
the coolant is exceeded
as
a
result
of
overheating, and coolant
is

forced out
of
the system.
Overheating can occur
if:

• the flow
of
cooling air is reduced, e.g.
by
a
radiator
muff,
very
dirty
radiator fins
(leaves,
dust, insects)
or
additional driving
lights
in
front
of
the cooling air intake.
• the boiling point
of
the coolant has been lowered by an incorrect mixture
-
see previ­

ous
page.
•
the
radiator
fan is not
working
- see
"Fan"
on next page
-
or, • the vehicle
is
driven up
a
long hill
in too

low a gear
with
engine speed very high and
at very high ambient temperatures
-
see
"Fan"
on
next page.
If
the
cause
of the
overheating cannot
be

found
and
eliminated, contact
a
Volks­
wagen dealer
as
soon
as
possible other­

wise
serious damage may
be
done
to the
engine.

Topping
up
coolant
Switch
engine
off
and let
it
cool down. Then

cover
expansion tank cap
with
a
cloth and

turn
cap carefully
to
the
left
and remove.

Attention
Do
not
remove
expansion
tank

cap
when
engine
is
hot
-
Danger
of scalding.

System
is
under
pressure.

If, in an
emergency only water
can be

added,
the
correct mixture concentration must be restored
with
the specified coolant
additive (see previous page)
as
soon
as
possible.

•02
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
ALPHABETICAL
INDEX

A
Acceleration
figures 142

Accessories
117 Activated charcoal
filter
138
Additional heater 62
Additional water heater 67
Adjusting brake pressure regulator . . 155
Adjusting headlights 128 Adjusting washer
jets
108

Air
cleaner 100

Air
conditioner 57

Air
distribution 55

Alloy
wheels 91

Analog
clock 46

Anti-dazzle
inside mirror 13
Anti-freeze 101 Anti-locking brake system (ABS) .... 30
Arduous operating conditions 115
Armrests 21

Ashtrays
73
ATF
99
Automatic gearbox 32
Automatic wash plants 88
Auxiliary heater 63
Axle
loads 148

B

Battery 106
Belt height adjustment 16
Blower
55
Bonnet 94
Brake
fluid
104
Brake
servo 30

Brake
system 104

Brake
warning lamp 48
Brakes
29, 139
c

Capacities
153

Capacity
141

Care
of body 88
Care
of car 88

Catalyst
137

Cavity
preservation 92
Central
locking system 8

Cetane
Number 87
Changing
bulbs 124

Changing
front
turn
signal bulb 125

Changing
wheels 120

Chassis
number 154
Checks
when
filling
the
tank
160

Child
safety 18

Child
seats 18
Child-proof catch 9 Cigarette lighter 73

Cleaning
and anti-corrosion
treatment
of engine compartment 91

Clock
46

Cold
starting aid 38

Combined
weight 151

Compression
ratio
141
Consumption figures 143

Coolant
additive 101
Coolant
level 47, 102
Coolant
temperature - Gauge 41

Cooling
system 101

Cruise
control system 53
D
Dash
panel 4

Dashboard
and controls 4
Defrosting windows 56, 58

Diesel
fuel 87
Dimensions
152
Dip lever 52
Dipstick - Automatic gearbox 99
- Engine 97
Direction indicators 48
Do-it-yourself 118

Door
locks 9

Doors
9 Drawbar weight 83
Driver's seat 20
Driving abroad 115
Driving on holiday 115
Driving safely 78 Driving tips 76

E

Electric
socket 73

Electric
window
lifters
12

Emergency
lights 51
Emergency
starting 130

Emission
control system 137
56
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
ALPHABETICAL
INDEX

Engine
-Code
letters 154

-Data
141
- Intervals of oil change 93

-Number
154

-Oil
96 - Oil capacity
1
53
- Oil change intervals 98
- Oil consumption 97
- Oil level 97
- Oil pressure 47
- Starting/stopping 37

Engine
compartment 95

Engine
compartment
light
72
Engine
number 154 Environment
- Activated charcoal
filter
738

-Battery
707
- Brake
fluid
705 - Care of car 88
- Coolant 103
- Driving environment consciously 79 - Driving
with
low emissions/noise 79
- Emission
control
system 737
- Engine oil 98
- Filling the
tank
85
-Fuel 86 - Maintenance 93
-Old oil 98 - Old
tyres
712 - Petrol vapour accumulator .... 738
-
Tyre
pressure
7
70
- Tyres 7 72
- Unleaded
fuel
86
- Washing the vehicle 89

F

Fan
103

Filling
the tank 85

Filter
preheating 87

First
aid kit 118

Fog
lights 51, 125
Folding
seat 25

Foot
mats 29

Fresh
air ventilation 56
Front axle load 148 Front seats 20

Fuel
86

-Additives
86, 87

-Consumption
79,143
- Filter 116
- Filter preheating 87 - Gauge 46
- Saving 79

Fuses
122

G

Gear
change marks 40, 77

Gear
lever 31

Gearbox
oil 99

Glove
box 74
Glow
plugs 38
H

Handbrake
31
Head
restraints 19

Headlight
beam control 50

Headlight
flasher 52

Headlight
washer system 54

Heated
rear window 51

Heating
55, 57

High
beams 48

Horn
4
I
Identification data 154
Ignition
lock 36

Increased
payload 149

Inertia
reel belts 16 Inside mirror 13
Inspection intervals 98
Installing seat 22

Instrument
lighting 50
Instruments 40
Interior
lights 72, 126
Intervals of inspection 93
Intervals of oil change 93

J
Jack
120

Jacking
points 120

Jumper
cable 130

157
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
ROUTINE
CHECKS
WHEN
FILLING
THE TANKS
n order to ensure
that
your vehicle remains ready for the road at all
times between Inspections you should carry out a few checks reg-
jlarly
- preferably when filling the tank.
Attention

Take
particular
care
when
working
in the
engine
compartment
- see
page
95.

We
have listed the most important points to be checked here. How
to open the bonnet is explained on page 94. 1 -
Coolant
reservoir
(expansion
tank)

Attention
Do not
open
expansion
tank
when
engine
is hot -

danger
of scalding!
If the level is below the min. mark, top it up
with
coolant additive G 11 V 8 B and water - see page 101. When unavoidable plain water

can
be used temporarily.
2 -
Brake
fluid
reservoir

The fluid level must always be between the min. and max. marks

-see
page 104.
3 - Engine oil
level
Every
engine
uses
a certain amount of oil. If the level is too low it

can
lead to serious engine damage. For this reason the level must be checked regularly - see page 97.
4- Engine oil
filler
opening

The approved types of oil are given on page 96.
5 -
Windscreen
washer
container

Always
fill
with
water and a glass cleaner. Think about frost precau­
tions in winter.
6 -
Tyre
inflation
pressures
Check
the pressures at least once a month. The pressures are given
on page 147 and on a sticker on the driver's door lock pillar. For

further
information, see page 110.
60
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans