1990 VOLVO 240 oil change

Volvo 1990 240 Model
Cars equipped with limited slip differentials should use oils with prope\
r additives.



Power steering fluid

Capacity: 0.8 US qts = 0.75 1iters
Fluid type: ATF
Replace: no fluid change required.

The dipstick is attached to the cap. Fluid level should be between MIN a\
nd MAX marks. Add fluid
when the level is at the ADD mark.



Brake fluid

file:///K|/ownersdocs/1990/1990_240/90240_15.htm (4 of 10)12/30/2006 8\
:25:09 AM

Volvo 1990 240 Model
pg. 86 Replacing wiper blades, Washing
Replacing wiper blades

Lift the wiper arm off the windshield and hold blade at right angles to \
arm. Pinch
the end of the plastic clip located at the back of the arm.
Slide the wiper blade along the arm to release it from the hook.
Install new blade in reverse order to removing and make sure that it is \
properly
attached to the wiper arm.
For reasons of safety, you should change the windshield wiper blades as \
soon as
they start to leave marks on the windshield or fail to wipe efficiently \
and cleanly.
Washing

The car should be washed at regular intervals since dirt, dust, insects \
and tar spots adhere to the paint
and may cause damage.
When washing the car, do not expose it to direct sunlight. Use lukewarm \
water to soften the dirt before
you wash with a sponge, and plenty of water, to avoid scratching.
A detergent can be used to facilitate the softening of dirt and oil. Spe\
cial car washing detergent or
household detergent can be used. A suitable mixture is about 2.5 fl. oz.\
(8.5 cl) of detergent to 2.6 US
gal. =10 liters of warm water. After washing with a detergent the car sh\
ould be well rinsed with clean
water.
A water soluble grease solvent may be used in cases of sticky dirt. Howe\
ver, use a washplace equipped
with a drainage separator.
Dry the car with a clean chamois and remember to clean the drain holes i\
n the doors and rocker panels.
Tar spots can be removed with kerosene or tar remover after the car has \
been washed.
Electrically operated antenna (optional) should be dried and lightly l\
ubricated with an oil dampened
file:///K|/ownersdocs/1990/1990_240/90240_18.htm (1 of 8)12/30/2006 8:\
25:11 AM

Volvo 1990 240 Model

Polishing (waxing)

Normally, polishing is not required during the first year after delivery\
. Waxing may be beneficial.
Before applying polish or wax the car must be washed and dried. Tar spot\
s can be removed with
kerosene or tar remover. Difficult spots may require a fine rubbing comp\
ound.
After polishing use liquid or paste wax.
Several commercially available products contain both polish and wax. Wax\
ing alone does not substitute
for polishing of a dull surface.
A wide range of polymer based car waxes can be purchased today. The waxe\
s are easy to use and
produce a long lasting high gloss finish which protects the bodywork aga\
inst oxidation, road dirt and
fading.

Cleaning the upholstery

Generally the fabric can be cleaned with soapy water or a detergent. For\
more difficult spots caused by
oil, ice cream, shoe polish, grease, etc., use a stain remover.
The plastic in the upholstery can be washed.
To clean leather upholstery , use soft cloth and mild soap solution, for\
instance common bath soap.
For more difficult spots, consult an expert for the choice of cleaning a\
gent.
On no account must gasoline, naphtha or similar cleaning agents be used \
on the plastic or the leather
since these can cause damage.
When aging, leather changes appearance, but the typical texture remains.\
To preserve smoothness and
appearance, it is recommended to treat the leather with a special leathe\
r preservative after one or two
years of use.

Cleaning the seat belts

Clean only with luke warm water and mild soap solution.
WARNING! Do not use cleaning solvents to clean the seat
belts.

Cleaning floor mats

file:///K|/ownersdocs/1990/1990_240/90240_18.htm (3 of 8)12/30/2006 8:\
25:11 AM

Volvo 1990 240 Model
Capacities
Fuel tank 15.8 US
gals 60 liters
Cooling system
-manual transmission
-automatic transmission
-expansion tank
separately
9.9 US qts
9.7 US qts
0.7 US qts

9.4 liters
9.2 liters
0.6 liters
Engine:
-oil and filter change
-oil changed separately
4.0 US qts
3.5 US qts
3.85
liters
3.35
liters
Transmission:
-manual, M47 II
-automatic, AW70
1.6 US qts
7.8 US qts

1.5 liters
7.4 liters
Rear axle -1030
-1031 1.4 US qts
1.7 US qts 1.3 liters
1.6 liters
Power steering gear 0.8 US qts 0.75
liters
Windshield washer fluid 3.4 US qts 3.2 liters

ELECTRICAL SYSTEM

12 V, negative ground. Voltage-controlled alternator.
Single-wire system with chassis and engine used as conductors.

Voltage 12 V
file:///K|/ownersdocs/1990/1990_240/90240_20.htm (7 of 14)12/30/2006 8\
:25:15 AM