1990 VOLKSWAGEN TRANSPORTER window

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND EQUIPMENT
AIR
CONDITIONER*

WARNING
• Good
visibility
comes
with
windows

free
of fog, condensation and
frost.

• For clear
visibility
and safe
driving
it
is
extremely
important
that
you
thor­

oughly
familiarize
yourself
with
and fol­ low the
operating
instructions
pertain­

ing to the proper use and
function
of
the
ventilation/heating,
defogging/de-

frosting
and air conditioning system in

this
manual. If in
doubt,
consult your
Volkswagen
dealer.

The
air conditioning unit is installed under
the roof of the driver's cab. Ten air outlets permit interior cooling throughout the

vehicle.

Two
climate control switches are located
on the instrument panel.

The
unit operates on the air recirculation
principle.
Air is sucked in through the two
large
air intake grilles at the rear portion of
the unit.

Because
the air conditioner is not nor­mally used at low ambient temperatures it

is
designed to operate only when outside
temperature is above 41° F or + 5° C.
When
the air conditioner is on, tempera­
ture as well as humidity inside the vehicle

is
controlled. During high outside humidi­
ty you can prevent windshield and win­

dows
from fogging by setting the controls
accordingly.

Maximum
cooling is maintained with

standard
heating/ventilation controls
turned off and the windows
closed.

However,
when the vehicle interior is very
hot from standing in the sun, open a win­
dow for a few minutes to permit hot air to

escape.
• iHBll
1
m
Air
outlets/Vents

1 - These air vents can be adjusted or
closed
completely.
• Tilt air vent housing to direct air
flow up or down.
• Turn thumb wheel to direct air
flow sideways.
• To open outlets, position thumb

wheel
in center of vents.
• To close air outlets,
turn
thumb

wheel
to extreme right or left.

2
- These air vents can be adjusted but not
closed.

• Direct air flow by swiveling the
vent housing.
54 * where applicable


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND EQUIPMENT]
VANITY MIRROR* ASSIST HANDLES/COAT HOOKS*
N VISORS
>fcu
can
lift
the
visor
on the
driver's side
out

cf
the
center mounting
and
move
it
toward
Te
door window
to
protect against side :
are.
[B25-377J

A
vanity mirror is
located
on the
back
of
the
sun
visor
on the
passenger's side.
To illuminate
the
vanity mirror, slide
the
switch (arrow).
When
the sun
visor
is
tilted
up,
illumination is shut
off
automatically. Assist handles
and
coat hooks
are

intended
for
your convenience.
WARNING • Hang clothes
in
such a way that they
do
not
impair
the
driver's vision.
•
Do not
hang heavy objects
on the

coat hooks,
as
they could cause per­
sonal injury
in the
event
of a
sudden
stop.
'where applicable 67


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE OPERATION

OPERATE
YOUR VEHICLE SAFELY

A
lot has gone
into
the manufacture of your Volkswagen, including advanced engineering techniques, rigid quality
control and demanding inspections.

These
engineering and safety features will be enhanced by you, the safe driver,
• who knows the vehicle and all controls
• who maintains the vehicle properly
• who uses driving skills wisely.

For
your own safety as well as
that
of
those around you - be a responsible
driver. If you
drink,
do not
drive.
The use
of alcohol, drugs and certain medications
will seriously impair perception, reactions and driving ability, substantially increasing
the risk of an accident and personal
injury.
Do not
drive
if you are
tired,
ill or
under

emotional
stress.
The
following
points
are also
important
for
your
safety,
please
observe
them

all.
First
things
first...

• Turn the engine off before performing
any checks or repairs on the vehicle.
• Be sure tires are inflated correctly.

Check
for damage and
tire
wear.
• See
that
wheel bolts or nuts are pro­
perly tightened and not loose or missing.
• Check engine oil level, add if neces­

sary.
Make it a habit to have engine oil

checked
with
every fuel filling.
• Check coolant level to assure sufficient
engine cooling.
• Be sure you have a well charged
battery.
• Check brake fluid level. If too low, have
brake system checked.
• Replenish windshield washer fluid.
• Replace worn or cracked wiper blades.
• See
that
all windows are clear and un­
obstructed.
• Check whether all
light
lenses are

clean.
• Be sure all lights are working and head­
lights are aimed correctly.
• Check under vehicle for leaks.
• Make sure the movement of either

brake,
clutch or accelerator pedal is not hampered in any way.
• Be sure all luggage is stored securely.

You'll
find helpful hints on how to perform most of these checks in this manual. If in
doubt, have these checks performed by
your dealer or any other qualified
mechanic.

Emergency
equipment

It is good practice to carry emergency
equipment in your vehicle. Some of the
things you should have are: emergency
light,
first-aid kit, small shovel, and for the
winter
season,
an ice scraper, snow brush,
a
container or bag of sand or salt, etc.
70


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE
OPERATION

In the
driver's
seat
•
Check operation of horn.

•
Adjust seat for easy reach of controls.

•
Adjust head restraints to your
size.

•
Adjust inside and outside rear view mir-
brs.

•
Use safety belts as directed.

•
Assure yourself
that
all passengers,

especially
children, are properly buckled up.

•
Check operation of
foot
and parking

orakes.

•
Check all warning and indicator lights
v/hen starting the engine.

•
Do not leave vehicle idling unattended.

•
Lock all doors
from
inside to prevent in­ advertent opening of doors
from
inside
and unwanted
entry
from
outside. On the
road

•
Always drive defensively. Expect the

unexpected.

•
Observe speed
limits
and obey road

signs.

•
Use signals to indicate
turns
and lane

changes.

•
Turn on headlights at dusk.

•
Always keep a safe distance
from
the
vehicle in
front
of you, depending on
traf­

fic, road and weather conditions.

•
Reduce speed at
night
and during incle­
ment weather.

•
If you smell gas fumes in the vehicle,
drive
with
the windows open, but keep the rear lid
closed.
Have the cause im­
mediately located and corrected.

•
Make frequent rest stops, at least
after

every two hours of driving.

•
When
tired
pull off the road, stop and
take a rest. Turn the engine off. Do not sit in the vehicle
with
engine idling. Engine ex­haust is dangerous if inhaled.
•
When stopped or parked, always set
the parking brake. Move the selector lever
to "P" (Automatic transmission) or move
the gearshift lever to reverse or
first
gear (Manual transmission). When parking on

hills,
turn
wheels
toward
the curb.

•
When stalled or stopped for repairs,
move the vehicle well off the road. Turn on
emergency flasher and use other warning

devices
to alert other motorists. Do not park or operate the vehicle in areas where
the hot exhaust system may come in
con­

tact
with
dry
grass,
brush, fuel spill or other material which can cause a fire.

•
Make it a habit to have the engine oil

checked
with
every fuel filling.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE OPERATION

OPERATE
YOUR VEHICLE ECONOMICALLY AND
MINIMIZE
POLLUTION
Your
personal
style
of
driving
determines your operating costs,
exhaust
emissions and noise levels. To obtain the best
possi­

ble fuel economy,
minimize
pollution
and

save
wear and tear on the engine, brakes
and tires, observe the following points:
• Keep a
light
foot
on the accelerator.
• Drive smoothly, avoid abrupt changes
in speed as much as possible.
• Avoid jack rabbit starts and sudden

stops.

• Avoid unnecessary idling. Turn the
engine off.
• "Warm up" idling wastes gas. Start the
engine
just
before you are ready to drive.

Accelerate
slowly and smoothly.
• Do not drive longer than necessary in
the lower gears. By upshifting early you
can
economize on fuel consumption. • Organize your trips to include in several
errands.
• Any additional weight carried in the
vehicle reduces fuel economy. Always keep cargo to a minimum and remove all

unnecessary
items.
• Remove roof and ski racks when not in

use.

• All electrical consumers contribute to

increased
fuel consumption. Therefore,

use
fan, rear window defogger, etc., only
when needed.
• Check your vehicle's fuel consumption
regularly. Keep a
written
tally sheet or use
the
trip
odometer. Fuel consumption will
vary
with
traffic, road and weather condi­
tions.
• Have your vehicle serviced by an

Volkswagen
dealer at the specified inter­
vals
(see page 95 and your Maintenance brochure). • Air cleaner should be inspected to

assure
proper engine "breathing".
• Battery should be fully charged.
• Wheels should be properly aligned.
• Tires should be inflated to correct pres­

sures.
Check
tire
pressures regularly - at least once a month.
• The published ENVIRONMENTAL-
PROTECTION AGENCY (EPA) and Trans­

port
Canada
mileage
estimates
may not

agree
with
your
actual
highway
mileage

which
will
vary,
depending
upon
vehicle
load
and speed,
road
and
weather
condi­

tions,
trip
length,
etc.
• Have the engine oil level checked
with

every fuel filling. Engine oil consumption
is
normal but tends to be higher when the
engine is new. The use of quality engine oil
and a correct engine oil level are essential
for vehicle performance and economical operation at all times.
72


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE CARE

V
or oil

Z:
not allow tar or oil to remain on the
Remove
as soon as possible
with
a
i soaked
with
a special paint cleaner. It do not have a tar or oil remover, you
=/ substitute
with
turpentine. After apply-
a
cleaning fluid, always wash
with
a
- • ewarm soap water solution and apply a
~e,v wax coat.
-sects

Remove
as soon as possible
with
a
. soap water solution or insect re-
rover.
"•ee sap Z p not allow tree sap or bird droppings to
-arden on the paint. Remove
with
a -kewarm soap water solution. Touch-up
paint

Your
Volkswagen dealer has touch-up paint for minor scratches and stone chips.

Scratches
should be touched up soon
after they occur to prevent corrosion. If cor­
rosion formation becomes visible, how­
ever, a simple touch-up job will not suffice.
The affected surface must be smoothed
with
sand paper and covered
with
an anti- rust primer, before restoring the painted

finish.

The number for the original vehicle paint
can
be found on the vehicle identification
label.

Windows
Clean
all windows regularly to remove
road
film
and car-wash wax buildup. Use a
lukewarm soap water solution or an al­
cohol base commercial window cleaning
agent. If a chamois is used for polishing
the
glass,
it should exclusively be used for

that
purpose.

Also,
be sure to clean all windows regularly on the inside.

Use
a plastic scraper to remove snow and

ice
from windows and mirrors. To prevent

dirt
from scratching the window, always

scrape
in a forward direction - never back
and forth.
Wiper
blades

Always
loosen frozen wiper blades from

glass
otherwise they may tear.

Clean
wiper blades regularly
with
an al­
cohol base solution. If necessary, use a
sponge
or a brush to remove accumulated road film. To assure good visibility, replace
wiper blades at least once a year, or more
often when wiping becomes streaky. For instructions on replacing wiper blades,

see
page 113.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE
CARE

Weatherstrips
Keep silicone sprays
off the
windshield
to avoid wiper smear
in
rain.
To seal properly, weatherstrips around
hood,
hatch, windows, doors,
etc.,
must
be pliable. Spray with silicone
or
coat with
talcum powder
or
glycerine
to
retain
flexibility
of the
rubber
and to
protect against freezing
in the
winter.

Sliding roof quide rails

To assure that
the
sliding roof* function properly, clean
the
guide rails
and
lubri­

cate with silicone spray
at
least once
a

year.
See
your Volkswagen dealer
for
cor­ rect procedures
and
lubricant.
Dull finishes and plastics

Plastic parts, such
as
light bulb lenses,
decorative stripes, panels, bumpers,
etc.,

will come clean with regular washing. Should additional cleaning
or
spot
re­
moval
be
necessary,
use a
soft brush
or

cloth soaked with
a
mild detergent
solu­

tion.
Then rinse thoroughly
and im­
mediately with clear water.
Do not use anything which could mar the
plastic
or
dull finished surface, such
as

wax, polish, abrasive detergents
or
chemical cleaning solvents.

Sliding door

The sliding door mounting points,
the
guide tracks
and the
roller guides should be lubricated regularly
and as
often
as
necessary.

Bright metal trim

Bright
or
black anodized trim will come
clean with regular washing.
To
protect metal
trim,
use car
wax. Remove spots
or

dirt from chrome
and
stainless steel with
a

chrome cleaner. Apply
a
chrome polish
for

continued luster and protection.
Steel wheels

Always include
the hub
caps
and
whee rims when washing your vehicle
to
remove
road dirt, salt sprays and brake dust.
If
nec
essary,
use a
commercial wheel cleaner
t:
remove accumulated brake dust. Pain:
scratches should
be
touched
up to
prever

corrosion.

Light alloy wheels

To preserve
the
decorative appearance
c-
the light aluminium cast, some specie
care
is
necessary.
In
addition
to
road
dr
and salt sprays, brake metal dust
is
alsc
corrosive.
If
left
on too
long,
brake meta
dust
can
cause pitting. Wash
the
wheels
with
a
sponge
or
hose brush every othe-
week. Road salt should
be
remove:
weekly with
an
acid free cleaning solutior Every three months (after regular clear­
ing)
the
wheels should
be
coated
wit-
petroleum jelly
or car
wax.
Rub it in
firml.

with
a
soft cloth. Never
use
abrasive
c
metal polishing cleaning agents.
Remember that moisture,
ice and
roac
salt
on
brakes
may
affect braking
eff

ciency. Test
the
brakes carefully afte'
each washing. Heed warning
on
page
29.

92
*
where applicable


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE
CARE
Winter operation During the winter months, battery capacity
tends to decrease as temperatures drop.
Additionally, more power is consumed while starting, and the headlights, heater, rear window defogger, etc., are used more
frequently. Curtail unnecessary power
consumption,
particularly in city traffic or
when travelling short distances only. Let
your
Volkswagen dealer test the battery's
capacity before winter sets in. A well
charged battery will not only prevent

starting
problems but will also live longer.
If
your
vehicle is left standing for several

weeks
at extremely low temperatures, the battery should be removed and stored
where it will not freeze.
This
will prevent it
from being damaged.
When removing the battery, first discon­ nect both cables (see Charging of Bat­

tery),
then unscrew the battery mounting.
WARNING
Always keep the battery well out of the reach of children.
Always heed WARNINGS on page
97.
Charging of battery
WARNING
•
Always shield
your
eyes and avoid

leaning
over
the battery whenever pos­

sible.

•
Charge battery in a well ventilated

area.
Keep away from open flame or

electrical
spark. Do not
smoke.
Hydro­ gen gas generated by the battery is ex­plosive.

•
Battery acid that may spill during
charging should be washed off with a solution of warm water and baking

soda
to neutralize the
acid.

•
If you get battery
acid
in
your
eyes or
on
your
skin,
immediately rinse with

cold
water for several minutes and
call

a
doctor.

•
Never charge
a
frozen battery. It may
explode because of gas trapped in the
ice.
Allow a frozen battery to thaw out
first.

•
Never use a fast charger as a boo­
ster to start the engine.
This
will
seri­

ously damage sensitive electronic
components,
such as relays, radio,

etc.,
as well as the battery charger.
•
Fast charging
a
battery
is
dangerous
and should only be attempted by a
competent mechanic with the proper
equipment.
Slow battery charging WARNING
•
Heed all WARNINGS and follow in­
structions that come with
your
battery

•
It is not necessary to remove the bat­

tery
from the engine compartment, and it
is
also not necessary to disconnect the

cables.

•
Make sure the electrolyte level in each

cell
is between the "min" and "max" marks. If the fluid level is below the "min" mark, le:

your
Volkswagen dealer correct the condi­

tion.

•
Connect charger cables.
Charger cables must be connected
POSITIVE
(+) to
POSITIVE
(+) and

NEGATIVE
(-) to
NEGATIVE
(-).
Do not connect or disconnect charger

cables
while charger is operating to re­
duce the danger of exploding.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans