1990 VOLKSWAGEN TRANSPORTER lights

Downloaded from www.Manualslib.com manuals search engine
VEHICLE OPERATION

For
best roadability adjust your load to the
maximum allowed tongue load. To be sure

measure
tongue load of loaded trailer on
bathroom
scales.

Check
that
both sides of your trailer can be

seen
from the driver's seat. If necessary in­
stall extended rear-view mirrors.

Check
proper working of vehicle and
trailer lights.

Check
cold
tire
pressure of both vehicle

and
trailer.

Be
sure trailer safety chains are properly

connected
from trailer to the hitch on the

vehicle.
Leave enough slack in the chains
to permit turning corners.

Trailer
towing
tips
Your
vehicle handles differently when tow­ ing a trailer because of the additional
weight. Safety, performance and economy
will greatly depend on how carefully you
load
your trailer and operate your "rig."
Before
you actually tow your trailer, prac­
tice turning, stopping and reversing in an
area
away from
traffic
until
you learn the
feel of your vehicle and trailer
unit.

Reversing
is
difficult
and requires practice.

Steering
while reversing is generally oppo­
site of
that
when backing your vehicle with­
out a trailer.

Observe
speed limits. In some areas

speeds
for vehicles towing trailers are lower than for regular vehicles.
Maintain a greater distance between your

vehicle
and the one in
front.
You will need more room to stop.

When
passing remember
that
you cannot
accelerate
as fast as you normally would

because
of the added load. Make sure you
have
enough room to
pass.
After passing
allow plenty of room for your trailer before

changing
lanes again.

Avoid
jerky starts or sudden acceleration.
Slow
down in crosswinds and on rougi"

roads.
Be especially carefull when
pas­

sing
other vehicles and trucks.

When
parking always block the wheels o: both vehicle and trailer. Do not park
with
a
trailer on a slope. If it cannot be avoided dc
so
only after the following:
• Apply brakes.
• Have someone place wheel blocks
under both vehicle and trailer wheels.
• With wheel blocks in place slowly re­

lease
brakes
until
wheel blocks absorb the

load.

• Apply parking brake.
•
Place
transmission in
"P"
for automatic
or in
first
or reverse gear for manual trans­
mission.

74


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
ADVERTISEMENT

Autobahn®
Accessories ...specially designed
for
your
Volkswagen.

You'll find
a
wide selection
of
"Autobahn" Accesso­
ries to help you make
your
Volkswagen fit
your
lifestyle
even better.
For
a
sporty
flair, there are spoilers, wind-deflectors,

fog
lights and driving lights.
Select from "Sound Choice" audio components.
They

are designed
to
add
to
your
listening pleasure: Electronic radio/cassette combinations with state-of-the-art features
and micro switch controls, full-frequency-range high

compliance
speakers, antennas with fully retractable
telescopic masts
—
manual
or
automatic
—
some even with electronic signal amplification.
And there are
roof-
and rear-deck carriers with

special
attachments
for
extra luggage
or
sporting
equipment
—
ski-,
bike-, surfboard carriers, etc.
— to
expand the usefulness and convenience
of
your

Volkswagen even further.
Autobahn care and protective maintenance products
— splashguards, floor mats, chemicals
—
will help protect
your
investment in
your
Volkswagen's good running condition and appearance
—
inside and out
—

for many years to come.

Your
Dealership Parts Department Professionals will

assist
you
in
selecting from our complete line
of

Autobahn Accessories
...
all designed for
your

Volkswagen.
Autobahn
Items available
at
time
of
purchase may differ from those shown here.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE OPERATION
After driving over
difficult
terrain,
espe­
cially through water or mud, the following
is
important:
• Disengage the differential lock*.
• After long drives through deep mud, the
brakes must be checked and cleaned if
they are
dirty.
This will prevent damage to
the brakes and premature wear.
• After driving through deep water, take
out oil dipstick and check to see whether
there are drops of water on the dipstick or if the oil level has risen. In
that
case,
the oil
must be changed immediately.
• If during an off-road drive the vehicle

has
become stuck (dug its way
into
the
ground) or the underside was stuck by
rocks
or similar, check undercarriage,
brake lines and oil pan for damage. • The engine compartment and vehicle
underbody must be cleaned if they are
very
dirty
so
that
the function of all mova­ ble and electrical/electronic parts is main­
tained.
•
Clean
heavy soil from wheels and tires,

check
tires for damage or foreign objects in treads.
•
Clean
turn
signals, lights and license
plate.
• Dry brake system by driving a short dis­
tance
with
brake pedal slightly depressed.

This
will help regaining normal braking ac­
tion
and help prevent the possibility of the
vehicle pulling to one side while braking.
Performance
testing

If the
Vanagon/Transporter
Syncro re­

quires
testing
on a
dynamometer
(en­

gine
output
analysis and
brake
test)
the

transaxle
drive
shaft
must
be discon­ nected.
The
differential
lock
must
not be en­ gaged.
84 "where applicable


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE
CARE

COOLING
SYSTEM
The cooling system
is
sealed and gener­ ally requires little attention.
The cooling system has been filled at the factory with
a
permanent coolant which
does not need to be changed. The coolant

consists
of a
mixture
of
water
and the
manufacturer's coolant additive
G 11 —

antifreeze
on
glycol basis with anticorro-
sion additives (40% for USA
models;
50%
for Canadian models).
This
mixture
assures
the
necessary frost protection
and protects
the
entire cooling system
against corrosion and
scaling,
and raises
the boiling point of the coolant.
Do
not
reduce
the
concentration
of the

coolant
in the
summer
by
adding plain
water.
The coolant additive proportion
must
be at least
40%
but not more than

60%,
to
maintain the antifreeze protection
and the cooling efficiency. For year round driving, antifreeze is added
at the factory for temperatures down to:

-13°
F/-25°C(USA)

-40°
F/-40°
C
(Canada)

Only
use
quality phosphate-free
anti­

freeze containing ethylene glycol. Such antifreeze
is
available at
your
Volkswagen

dealer.

WARNING Antifreeze is poisonous. Always store antifreeze in its original container and

well
out of the reach of children. If you drain
the
coolant,
it must
be
caught
and

safely stored. Drained coolant should normally not be reused. Always des-

pose
of used coolant observing all en­
vironmental regulations.
Coolant losses
Coolant losses may indicate
a
leak in
the

cooling
system.
In
this
case,
the
cooling
system should
be
inspected immediately by
your
Volkswagen dealer.
It is not
suffi­

cient merely to add coolant.

In a
sealed system, losses can only occur
if
the
boiling point
of the
coolant
is ex­

ceeded as
a
result of overheating.
Overheating can occur
if:

•
the
flow
of air to the
radiator
is

obstructed
by
leaves, dust, insects
or by

additional
lights installed
in
front
of the
radiator grille;

•
the boiling point of the coolant has been
reduced
due to an
incorrect mixture
of

coolant and water;

•
the
radiator fan
is not
working
- see

"Radiator
fan",
or;

•
the vehicle is being driven up
a
long
hill
j

in
a
low gear with engine speed
very
high
and
at
very
high ambient temperature
-

see
"Radiator fan".

If
the cause for the overheating cannot
be

determined
and
corrected, contact
your

Volkswagen dealer immediately, other-
I
wise serious engine damage could result.

104
Always
heed
WARNING on page
97.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE CARE

Refill
tank

Checking
the coolant level

The coolant level should
be
checked from time
to
time, and always before going on
a
longer
trip.

WARNING

To
reduce the risk of being burned, never open the hood if you see or hear
steam or coolant
escaping
from the en­
gine compartment.
Wait
until
no steam

or
coolant can be seen or heard before
carefully opening the
hood.
Expansion
tank
The refill tank and
the
expansion tank are in
the
engine compartment.
The coolant level
is
normally checked only in
the
refill tank (behind
the
license plate
lid).
The expansion tank needs checking only
if
a
large amount
of
coolant
is
lost
or if the

warning
light
in the
water temperature gauge lights up.
On
the
refill
and the
expansion tank,
the

cap
need
not
be taken
off,
since the tanks
are transparent.

On
the refill tank, the coolant level must
be

between
the
min.
and
max. marks when
engine
is
cold
and not
running. When
engine
is
warm, coolant level
may be

slightly above max. mark.
The expansion tank
is
equipped
with
an
electric coolant level checking device.
When the coolant level is too low, the warn­ ing
light
in the
coolant temperature gauge

(see
page
43)
will flash
until
the
coolant
level has been restored
to
normal.

Always heed WARNINGS on page 97.
105


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE
CARE
Winter operation During the winter months, battery capacity
tends to decrease as temperatures drop.
Additionally, more power is consumed while starting, and the headlights, heater, rear window defogger, etc., are used more
frequently. Curtail unnecessary power
consumption,
particularly in city traffic or
when travelling short distances only. Let
your
Volkswagen dealer test the battery's
capacity before winter sets in. A well
charged battery will not only prevent

starting
problems but will also live longer.
If
your
vehicle is left standing for several

weeks
at extremely low temperatures, the battery should be removed and stored
where it will not freeze.
This
will prevent it
from being damaged.
When removing the battery, first discon­ nect both cables (see Charging of Bat­

tery),
then unscrew the battery mounting.
WARNING
Always keep the battery well out of the reach of children.
Always heed WARNINGS on page
97.
Charging of battery
WARNING
•
Always shield
your
eyes and avoid

leaning
over
the battery whenever pos­

sible.

•
Charge battery in a well ventilated

area.
Keep away from open flame or

electrical
spark. Do not
smoke.
Hydro­ gen gas generated by the battery is ex­plosive.

•
Battery acid that may spill during
charging should be washed off with a solution of warm water and baking

soda
to neutralize the
acid.

•
If you get battery
acid
in
your
eyes or
on
your
skin,
immediately rinse with

cold
water for several minutes and
call

a
doctor.

•
Never charge
a
frozen battery. It may
explode because of gas trapped in the
ice.
Allow a frozen battery to thaw out
first.

•
Never use a fast charger as a boo­
ster to start the engine.
This
will
seri­

ously damage sensitive electronic
components,
such as relays, radio,

etc.,
as well as the battery charger.
•
Fast charging
a
battery
is
dangerous
and should only be attempted by a
competent mechanic with the proper
equipment.
Slow battery charging WARNING
•
Heed all WARNINGS and follow in­
structions that come with
your
battery

•
It is not necessary to remove the bat­

tery
from the engine compartment, and it
is
also not necessary to disconnect the

cables.

•
Make sure the electrolyte level in each

cell
is between the "min" and "max" marks. If the fluid level is below the "min" mark, le:

your
Volkswagen dealer correct the condi­

tion.

•
Connect charger cables.
Charger cables must be connected
POSITIVE
(+) to
POSITIVE
(+) and

NEGATIVE
(-) to
NEGATIVE
(-).
Do not connect or disconnect charger

cables
while charger is operating to re­
duce the danger of exploding.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF-SERVICE
FUSES

A
failure in the electrical system may be
caused
by a burned fuse.

Fuses
are arranged in one centralized

unit.
The
unit
is located on the
left
side under the dashboard behind a cover.

Removing
cover:

Detach cover at
front,
swing downwards
and take it off.

Installing
cover:

Hang
cover in the eyes of fuse box
bracket, swing it upwards and press it

firmly
into
position.
Replacing
a
fuse

Before
replacing
a fuse,
turn
off all
lights

and accessories and
remove
the
ignition
key to
avoid
damaging
the
electrical

system.
• Consult the fuse listing on the following
page to
find
out which fuse belongs to the
component
that
has failed.
• Remove blown fuse
with
the plastic clip
located on cover in
front
of fuse box.
Three spare fuses can be attached to the
bottom
of the fuse panel. It is good plan­ning to keep a supply of spare fuses on

hand.
They are available at your Volks­
wagen dealer.
• Replace the blown fuse which can be
recognised by the
burnt
metal strip,
with
a
fuse of equal ampere rating. If a
fuse
blows
repeatedly,
do not
keep
or

replacing
it. The cause of the
short
cir­

cuit
or
overload
must
be found. On nc

account
should fuses be
patched
up

with
tin
foil
or
wire
as
this
may cause serious
damage
elsewhere
in the
electrj

cal
circuit
or cause a
fire.

WARNING
Do not use a
fuse
of
higher
amperage,

because
this
could
damage
the
elec­

trical
part
and
fire
can
result.

128


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF-SERVICE
Fuse arrangement No. Component Amp. No. Component Amp.
From left to right: 1
Radiator fan 30 17 Windshield wiperengine 10
2 Brake lights 10
18 Brake warning light,
3 Interior lights, illuminated heated driver's seat,
Make-up mirror, clock,
ciga­
cruise control system 10
rette lighter, radio 15 19 Turn signals 10
4 Emergency flasher system 15 20 Number plate light,
5 Vacant headlight washer
10
6 Vacant 21 Low beam left
10
7 Tail and side light left 10
22 Low beam right 10
8 Tail and side light right
10
9 High beam right 10
10 High beam left
10 Additional fuses
11 Windshield wipers and washer
15 (in separate holders)
12 Cruise control system
Air conditioner, power above the fuse box:
windows, auxiliary heater, Instrument lightning
10
electric outside mirrors, Overheating fuse for auxiliary heater
10
auxiliary heat exchanger, Main fuse for auxiliary heater
20
rear window wiper 20 Central locking 20
13 Fresh air fan
20 Automatic fuse for window lifter
20
14 Rear window heating, heated
rear view mirror, light for Color codes
15
16 lighting switch
Back-up lights
Double tone horn 20
10
15 10 Amp. fuses - red
15 Amp. fuses - blue
15
16 lighting switch
Back-up lights
Double tone horn 20
10
15 20 Amp. fuses - yellow
30 Amp. fuses - green
The number on the face of the fuse is the amperage rating.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans