1988 JEEP CHEROKEE towing

[x] Cancel search: towing

fuel additives light oil dipstick battery location radio controls heater

Page 488 of 1378

JEEP CHEROKEE 1988 Service Repair Manual Starter Relay (Graphic 2) Behind right headlight, on
wheelwell.
Timer Delay Relay Above starter relay, behind

Page 489 of 1378

$JEEP CHEROKEE 1988 Service Repair Manual Left Turn Signal Relay Above left rear wheelwell. Right Turn Signal Relay Above left rear wheelwell.��\ ��\ ��\ ��$

Page 829 of 1378

JEEP CHEROKEE 1988 Service Repair Manual 1 - 25 Amp
Rear Washer/Wiper.
2 - 15 Amp
Radio, Cigarette Lighter.
3 - 25 Amp
Blower Motor.
4 - 20 Amp
Turn Signal, Back-Up L

Page 904 of 1378

JEEP CHEROKEE 1988 Service Repair Manual * Cold Climate Operation
* Towing Or Heavily Loading
* Severe Dust Conditions
* Sustained High Speed Operation
* Off-Road Driving
* Hot Weather, Stop-And

* Cold Climate Operation
* Towing Or Heavily Loading
* Severe Dust Conditions
* Sustained High Speed Operation
* Off-Road Driving
* Hot Weather, Stop-And-Go Driving
* Extensive Idling Conditions (Taxi Or Delivery Type Service)
Normal Service
* Driven More Than 10 Miles Daily
* No Severe Service Operating Conditions
CAMSHAFT TIMING BELT REPLACEMENT INFORMATION (TURBO-DIESEL)
CAUTION: Failure to replace a faulty camshaft timing belt may result
in serious engine damage.
The condition of camshaft drive belts should always be
checked on vehicles which have more than 50,000 miles. Although some
manufacturers do not recommend belt replacement at a specified
mileage, others require it at 60,000-100,000 miles. A camshaft drive
belt failure may cause extensive damage to internal engine components
on most engines, although some designs do not allow piston-to-valve
contact. These designs are often called "Free Wheeling".
Many manufacturers changed their maintenance and warranty
schedules in the mid-1980's to reflect timing belt inspection and/or
replacement at 50,000-60,000 miles. Most service interval schedules
reflect these changes.
Belts or components should be inspected and replaced if any
of the following conditions exist:
* Cracks Or Tears In Belt Surface
* Missing, Damaged, Cracked Or Rounded Teeth
* Oil Contamination
* Damaged Or Faulty Tensioners
* Incorrect Tension Adjustment
SERVICE LABOR TIMES
SERVICE LABOR TIMES TABLE (HOURS)\
\
\
\
\
\
\

( 1) 30,000 60,000
Application Mile Service Mile Service
2.1L (Turbo Diesel)
Automatic Transmission ........... 4.3 ................ 4.5
Manual Transmission .............. 3.6 ................ 3.8
2.5L
Automatic Transmission ........... 5.6 ................ 3.5
Manual Transmission .............. 4.9 ................ 3.5
2.8L
Automatic Transmission ........... 5.8 ................ 3.7
Manual Transmission .............. 5.1 ................ 3.7
4.0L
Automatic Transmission ........... 5.7 ................ 3.6
Manual Transmission .............. 5.0 ................ 3.6
( 1) - Add .8 hr. for vehicles equipped with 4WD.
\
\
\
\
\
\
\

Page 912 of 1378

$JEEP CHEROKEE 1988 Service Repair Manual Fig. 10: Identification Label Locations Courtesy of American Motors Corp. LUBRICATION SPECIFICATIONS LUBRICATION SPECIFICATIONS TABLE\ \$

Page 913 of 1378

JEEP CHEROKEE 1988 Service Repair Manual Brake Caliper Bushings ....... GE 661 or DOW 111 Silicone Grease
Caliper Slide Pins .......... GE 661 or DOW 111 Silicone Grease
Wheel Bearings ............ Multi-Purpose NLGI Grade 2EP, GC-LB
Dr

Brake Caliper Bushings ....... GE 661 or DOW 111 Silicone Grease
Caliper Slide Pins .......... GE 661 or DOW 111 Silicone Grease
Wheel Bearings ............ Multi-Purpose NLGI Grade 2EP, GC-LB
Drive Shaft U-Joints ...... Multi-Purpose NLGI Grade 2EP, GC-LB
Steering Linkage (4)( 5) ... Multi-Purpose NLGI Grade 2EP, GC-LB
Ball Joints ( 4)( 6) ........ Multi-Purpose NLGI Grade 2EP, GC-LB
Engine Oil Filter (Diesel) ( 7) .... AMC/Jeep (P/N 8983 002 656)
Weatherstrip ......................... Silicone Spray Lubricant
( 1) - SAE 10W-30 SH/CD is preferred.
( 2) - Add 2 Ozs. (59 ml) of Limited-Slip differential lubricant
additive when changing fluid.
( 3) - For vehicles operating under heavy-duty towing conditions,
use SAE 75W-140 Synthetic lube.
NOTE: Before using SAE 75W-140 Synthetic the old fluid must be
DRAINED and FLUSHED with clean mineral based (non-synthetic)
axle lubricant. Then refill with new synthetic lube.
( 4) - Use low pressure grease gun to prevent seal damage.
( 5) - Fill until lubricant squeezes out from the base of seals.
( 6) - Fill ball joint until seal starts to swell.
( 7) - Use of AMC/Jeep Oil Filter is RECOMMENDED.
\
\
\
\
\
\
\

FLUID CAPACITIES
FLUID CAPACITIES TABLE\
\
\
\
\
\
\

Application Quantity ( 1)
A/C System R-12 Refrigerant Capacity ............... 36-40 Ozs.
Automatic Transmission
1984-86 (904 HD)
Fluid Change .............................. 4.0 Qts. (3.8L)
Overhaul (Dry Fill) ....................... 8.0 Qts. (7.6L)
1987-88
Fluid Change .............................. 4.0 Qts. (3.8L)
Overhaul (Dry Fill) ....................... 8.5 Qts. (8.0L)
Cooling System ( 2)
4-Cylinder ................................. 10.0 Qts. (9.5L)
6-Cylinder ................................ 12.0 Qts. (11.4L)
4-Cylinder Turbo Diesel (1985-87) ........... 9.0 Qts. (8.5L)
Engine Oil
4-Cylinder .................................. 4.0 Qts. (3.8L)
6-Cylinder .................................. 6.0 Qts. (5.7L)
4-Cylinder Turbo Diesel (1985-87) ........... 5.5 Qts. (8.5L)
Fuel Tank
Standard ................................. 13.5 Gals. (51.1L)
Optional ................................... 20 Gals. (75.7L)
Manual Transmission ( 3)
AX4 (AISIN) ................................. 7.4 Pts. (3.5L)
T4 (Borg-Warner) ............................ 3.9 Pts. (1.8L)
AX5 (AISIN) ................................. 7.0 Pts. (3.3L)
T5 (Borg-Warner) ............................ 4.5 Pts. (2.1L)
Transfer Case
1985-86
Selec-Trac (229 Full-Time) ................ 6.0 Pts. (2.8L)
Command-Trac (Part-Time 207) .............. 4.5 Pts. (2.1L)
1987
Selec-Trac ................................ 2.5 Pts. (1.2L)
Command-Trac .............................. 2.2 Pts. (1.0L)
1988
Selec-Trac ................................ 3.0 Pts. (1.4L)

Page 917 of 1378

JEEP CHEROKEE 1988 Service Repair Manual WARNING: DO NOT USE starting fluids (ether) or flammable liquids to
aid the starting of a Cummins Turbo-Diesel. NEVER pour diesel
fuel, flammable liquids or starting fluids into the

WARNING: DO NOT USE starting fluids (ether) or flammable liquids to
aid the starting of a Cummins Turbo-Diesel. NEVER pour diesel
fuel, flammable liquids or starting fluids into the air
cleaner canister, air intake or turbocharger housing in an
attempt to start the vehicle. A flash fire may result causing
personal injury.
TRANSFER CASE
CAUTION: Both drive axles are disengaged when transmission gear is
in Neutral position. Always set parking brake when leaving
vehicle unattended.
CAUTION: Never attempt to engage Low range when vehicle is moving
faster than 2-3 MPH (3-5 KM/H). Transfer case damage may
result.
GASOLINES CONTAINING ALCOHOL
CAUTION: Exclusive use of gasohol is not recommended. Vehicle test
results have shown that significant fuel system corrosion
can result when gasohol is used exclusively. Fuel additives
which are now being sold as octane enhancers are not
recommended. Most of these products contain high
concentrations of methanol.
WARRANTY INFORMATION
CAUTION: Due to the different warranties offered in various regions
and the variety of after-market extended warranties
available, please refer to the warranty package that came
with the vehicle to verify all warranty options.
BASIC NEW CAR WARRANTY
Jeep Corporation warrants to the original purchaser that the
vehicle is free from defects under normal use and service for 12
months or 12,000 miles, whichever comes first.
POWERTRAIN PROTECTION LIMITED WARRANTY
Begins at 12 months or 12,000 miles and lasts for 7 years or
70,000 miles, whichever comes first. Warranty covers Engine,
Transmission, Transfer Case, and Drive Shaft/Drive Axle(s) for RWD &
4WD.
Items not covered include, normal scheduled maintenance,
tune-ups, clutch adjustments, lack of proper maintenance, and vehicles
on which the mileage cannot readily be determined. A 100.00 deductible
on 2WD models and a 150.00 deductible on 4WD models applies to each
repair visit.
Powertrain Warranty also covers cost of towing to nearest
Jeep Dealer if vehicle cannot be driven due to failure of a covered
powertrain part.
ANTI-CORROSION PERFORATION WARRANTY
Warrants the sheet metal parts of the vehicle against
perforation (rust-through) due to corrosion. It covers any body sheet
metal panel for unlimited mileage during the first 36 months. Outer-
body sheet metal panels are covered for 7 years or 100,000 miles,

Page 920 of 1378

Load next 8 pages

Page: 1-8 9-16 17-24 25-32 33-40 ... 40 next >

transmission mirror check oil fuse navigation door lock