70019401960 Specifications
Section 3 Electrical system
Section 3 Electrical system
Group 31 Battery............................... 118
Group 32 Alternator. . . . . . . . . . . . . . . . . . . . . . . . . . . .. 118
Group 33 Starter motor . . . . . . . . . . . . . . . . . . . . . . .
.. 123
Group 35 Lighting......... . . . . . . . . . . . . . . . . . . . .. 127
Group
37 Fuses.... . . . . . . . . . . . . . . . . . . . . . . . . . . .. 128
Group 38 Instrumentation . . . . . . . . . . . . . . . . . . . . . .. 137
Group 31 Battery
System voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 V
Earth connection. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Negative terminal
Battery capacity
Model Co
ld start current*
Reserve capacity* Recommended
CCA SAE
RC SAE (DIN) charging current
B23ET, B28A1E, B280E (66 Ah) 7A
024, 0 24 T -1986 (88 Ah) 9A
024,024 T, 024 TIC 1987-600 A 125 min 9A
B 19/23, B 200, B 230, France 330
A 70 min 5A
B 19/23, B 200/230, not France, B 28 F, B 280 F 450 A 90 min (55 Ah) 6A
1991-type and market adaption
Volvo PIN Cold start current*
Reserve capacity*
Recommended
CCA SAE
RC SAE (DIN) ·charging current
3515893
440 AMP 85 min (50 Ah) 6A
3515895 520 AMP 100 min (60 Ah) 7A
3515897 600 AMP 125 min (70 Ah) 9A
• Cold start current (CCA, SAE) is the discharge current that a battery can deliver for 30 sec at a temperature of -18°C (O°F) without drop
ping below 7 .2 V.
Reserve capacity (RC, SAE) is the time required at + 2rC (80°F) for a steady discharge current of 25 A to reduce the potential of a fully charged battery to 10.5 V .
118
(
7001940/.960 Specifications
Section 4 Power Transmission
Gear shift speeds, km /h (mph)
Mode selector in position ECONOMY (E). Sh ift selector in position D. Thro ttle opening in %
Engine Type Final drive 1-2 2- 3 3-4
3-4 4-3 3-2 2-1
ratio
(100+KD) (100+KD) (75) (100+KD)
(100+KD) (100+KD) (100+KD)
B6304F AW30--43 3.73:1 58 114
157 180 175 105 45
Mode selector in position SPORT (S). Sh ift selector in pos ition D. Thrott le open ing in %
Eng ine Type F
inal drive 1-2 2-3 3-4 3-4 4-3 3-2 2-1
ratio
(100+KD) (100+KD) (75) (100+KD) (100+KD)
(100+KD) (100+KD)
B6304F AW3D-43 3.73:1 58 114 177 180 175 105 45
Mode selector in position WINTER (W). Shift se lector in pos ition D. Thrott le open ing in %
Eng ine Type F
in al drive 1-2* 2-3* 3-4
3-4 4-3 3-2* 2
-1*
rat io (100+KD) (100+KD) (0-100)
(100+KD) (0-100)
(100+KD) (100+KD)
B6304F AW3D-43
3.73:1 50 100 50 170 40 70 20
* 1st and 2nd gear only used on kick-down .
Mechanica l lock-up (LOCK-UP), km/h (mph). Shift selector in pos ition D. Thrott le open ing in %
ECONOMY (E ) SPORT (S ) WINTER
(W)
Eng
ine Type Fin
al drive 2 3 4 2
3 4 3
ratio
(100+KD) (100+KD) (100+KD)
(100+KD) (100+KD) (100+KD) (15-98)
in out in out in out in out in out in out in out
B6304F AW3D-43 3.73:1
85 1 77 130 1123 180 1175 85 1 77 130 1123 180 1175 50 1 40
147
I
III 'II III II III
,II
W · III
(
Delco R4 Compressor
Compressor, coupling plate ................................... 14-34
Kiki Compressor
Front cover bolts. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Drive
plate centre bolt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Rear cover connection. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
22
Oil drain/filler plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
York Compressor
Compressor mounting bolts ........................ .......... .
Oil drain/filler plug ........................................... .
Pulley/clutch centre bolt. ..................................... .
Rear bearing housing
.................................. ...... .
Con rods .
.................................................. .
Lower cover
........................................ .. ...... .
Valve plate/upper cover ...................................... .
Sankyo Compressor
30
5
25-30
20
20
20-30
20-30
Oil drain plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Pulley/clutch
centre bolt. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
Valve plate. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Pressure sensor
(Only fitted to vehicles with D 24, D 24 T and tropic type radiator)
70019401960 Specifications
Section 8 Body and interior
10-25
16
11
16
8
22
3.5
18-22
14
14
14-22
14-22
7
27
11
Electric cooling fan engaged at pressure ....................... .
disengaged at pressure
.................... .
2.0 MPa (284 psi)
1 .7 MPa (242 psi)
Performance test
Test conditions
Bonnet . . . . . . . . . . .. closed
Doors . . . . . . . . . . . .. closed
Engine
speed. . . . .. 33 r/s (2000 r/min)
Control settings
Fan speed ........................... ...................... .
Temperature
control . ................................. ....... .
Mode
selector . ............................................. .
AC switch ............. ..................................... .
.
Recirculation switch ......................................... .
Recorded operating conditions
Ambient temp
(in front of car) 20°C (68°F) 30°C (86°F)
40°C
(104 °
F)
Temp of expelled air, measured 5-8°C 5-8°C 8-12°C
CU + AC
3
COOL
MAX
at centre panel vents
(41-46°F) (41-46 °F) (46-54°F)
ACC
Max cool
Auto Hi
ECC
5
Max cool
Vent
-In
In
143985
161
·11 lit ·11 lit ·11 lit ·11 III II
