1981 CHEVROLET MONTE CARLO engine oil capacity

Downloaded from www.Manualslib.com manuals search engine If you have to add coolant more than four times a year (either to the recovery
tank or to the radiator), see your dealer for a cooling system check.
NOTICE: If you use the proper quality antifreeze, there is no· need to add extra inhihitorsor additiveswtlich claim to improve-the system. They may be harmful to the proper operation of the system.
Cooling' System Service
The cooling system should be serviced at the intervals specified in Section A of
the Maintenance Schedule folder as follows:
1. Wash the radiator cap and filler neck with clean water. See step 1 of "Coolant Replacement" for the proper way to remove the radiator cap.
2. Check the coolant level in the radiator and have it tested for freeze
protection.
Add ethylene glycol antifreeze, if needed, to maintain freeze
protection at-3JOC (~$4°f).
3. Have the cooling system and radiator cap tested for a pressure capacity of 105. kPa (15psi). (The pressure cantle anywhere from 95 kPa, or 14 psi,
to 120
kPa, or 18 psi.) If a replacement cap is needed, use an AC cap, or
an equivalent cap, designed fof coolant recovery systems and specffied for
your model.
4. Tighten all radiator hose clamps ang heater hose clamps and inspect all
hoses. Replace the hOSes if they are swollen, "checked" or otherwise worn.
NOTICE: Take care when tightening the hose clamps at the radiator. Overtightening could bend or collapse the radiator fittings.
5. Clean the front of the radiator core and air conditioning condenser to
remove dirt and other objects. Also clean the auxiliary engine oil andlor
transmission fluid cooler if the vehicle has them.
Coolant Replacernent
At the intervals specffied in Section A of the Maintenance Schedule folder, flush
9r1d refill the cooling system as follows:
1. Remove the radiator cap when the engine is cool:
•
Turn the cap slowly to the left until it reaches a "stop." Do not press
down while turning the
cap.
• Wait until any remaining pressure (indicated by a hissing sound) is
relieved, then press down on the cap and continue turning it to the left.
CAUTION: To help avoid the dangarm being burned. donotrem_ove the radiator cap While the engine' and radiator are. still. hot. Scaldingftukland steam ean be blown out under ~re It the cap is taken off too SOOf1.
2. When the cap is removed, run the engine until the upper rad.iator hose is
hot.
(ThiS shows that th~ thermostat is open and the coolant is flowing
through the system.)
3. Stop the engine. Open Ihe,actialor drain valVE! to drain the coolant. Drainage may be speeded by removing the drain plugs in the block, ff so
equipped.
5-7

Downloaded from www.Manualslib.com manuals search engine SECTION 7
SPECIFICATIONS
These specifications are given here for information only. Before using them,
see
the cautions and other instructions throughout this manual. For further
information, see the service manual covering the ,chassis or body part in
question. Your Chevrolet dealer may also be able to help.
DIMENSIONS
Overall Length 2"000r Coupe ' ......... ' ..
Overall Height .. .. , .................... . Width .... ,., , .. . , ....... , ... , ..... ... .
Wheelbase
.. , .... ... ................ .. ,
CAPACITIES
Gasoline ,Tank (Approx.) All Models , .... , .. , , ........
Crankcase (App rox. Relill )
Oil Change Only
Meiric U.S.
Metric U.S.
Measure Measure
5090mm 200. ,4 "
1370mm
53,9"
1816mm '. 71,S " 2745mm 108 .1 "
Metric U .S . Measure Measure
68 .5L 18.1 ga l.
Oil Change and FilterCha~
Metric U.S. Measure Measure Measure Measure
V ·8 ..... .... 3.8L 4 qts. 4.7L 5 qts. V-6 3.8L 4 qts. 3.8L 4 qu. "'" After refill , fluid If wei must be checked as~ out~ed-under "Service and Maintenance " in thi s manual.
Cooling System (Appro •. )
3.8 (229) CIO Engine .............•...•..... 3.8 (231) C1D En9in~ .....•.......•..••• ,'" .
5. 0 (305) CID Engine ......... , ... " _ ..•.. : •. 4.4 (267) CID Engi ne ....... , . ....•... •...•. Thermostat (All) .... " .... ,. _, ...... Radiator Pressure Cap (All) ......•. _ ...... .
BATTERY RATING
Cold Crank ,
Engine 18°C (O°F)
All (Base)
". X ' 350 Amps F-14
Heavy Duty
F-18 460 Amps
7-1
Metric Measure
17.4 L
14.3 L
18·0L 2O.0L 91°e l05kPa
U.S. Measur.
l8Y.!: qts. 15% qts. 19 qts. 21 qts. 195 °F
15 PSI
25 AMP Reserve
Capacity (Minutes)
80
115

Downloaded from www.Manualslib.com manuals search engine AJt Cleaner. Ail CoricIitionor FOlK Season .. Mainten ance .. AM" Pressu-e. Tires. AM" Vents. Alterna tOf tGEN) l.ghl AUniIlUffi Cafe .. AM or AM-FM Radios Antenna Antifreeze . Appearaoc e Care . Ash1rays & Lignler s. Assistance. Owl"lef Automat ic Door Locks. Automatic Transmission CorwElfter ClUlch Maintenanr;e
"""'-OpefaJ .... '1 TiPS.: AKIe. Re ar Standard . lifnited-SHp . Babies. AesCraint 01 .. BaIt Joints .. fun..., E mergency S ta ring F reedom. Gas Caution ..• GEN 191I... .•.• Test Indicator ...
. ........ 5-9
2-24
5-11
5-12
2-23 ....... 2·17 ... 2:27. 2-28 2·29 (Seo "Coolant") ,.,
2·22 6·' ,.,
2·10 5-5 .. 2 -9 2 ·'
5 ·'
5·' 1·10. ,-" . 5·1 0
3 ·' 5-10 3·' 2-17 5·10 Betore Dr iving Your Vehide... \. Bells: Sea!....,.. . (See I'Se at Belts") Blower, Healer & Air Cond.. 2-24. 2-25
Body Da mage . 4-4
.. """ ~,. Pedal Travel Trailer Towing .... Warning Ught .
2·14 2-\4 H2 2-17
Breakers . <;ircui t. • ..... 2-21. 7·3 Bteak ..... Period. New Vehicle ..• 2·2 Srioj'!( Headlights 2·7. 2·21 Brighl Metal Cleaning 4-4
Bulbs & Fuses.. 7·3. 7-4 Bumpers & HiIC:·~s. '·13 ~ 'Jack Operation ...... 3-4 B.w:ers._ . (See "'SOunds'" CoirpJler Con"mand Cont rOl System:~ 2·\8, 5·3 Cop Coolant A ecovery Tant.: .. ................. , .. 5-6 F uel.. 5-2 f>o¥Iier Steefing.. _____ -._ ....... ...... 0<. _____ -5-9 Radiator ... 5·8 Capacity, Cargo Weight. 5-11 Capacities. FlUid:. 7- Car Break-In Period . New.. 2-2 . car -Chemicals ... carbon Monoxide cautJorI .... ___ 4·' 2·' Care & Cleaning. Appearance . . .. 4·' Cargo Capacity . 5-11 Cargo on Root . Carrying,. '·2 Catalytic Converter . . ..................... ....... 5-2 ~ Command Control System .. -2·18. , ·3 Chains. Tire .. 5·15
7-6
Changing Wheets & Tires .. _ Cl-£O< ENGtl'E light .. Chectlbt, DrillSf . Child Seals & Restr ainls Chrome Protection .. ag.yette lighter ... CirCUIt Beakers QtiZOtlS Band Raoio . C!earIing .. Clock.I .. Cloth Trim Care .. ClutCh . Converter
Cold W&ather Starting ....
3 ·4 . 3·5 2 ·18. 5-3 ,., I -tO. 1·11 ... 2·22 2·21 , 7·3 2·29 . ..... 4·' 2-22 '·2 2·10 2·8 ~ip""lt Plocedu.-e . . ... 6 ·1
Condi lioner, Air (See "All" Cooditioner"~ Cons umer Relation s ... Converter ClUtch Con...eJo: Mirror Cooling System Afltilreeze (CooIanI) .. Overheating R ecovery Tank Service,. Thermoslal . COfl"lefing Lights . CorTosion Pmlection. Countries. Oper-ating in Fo.-eign .. Courtesy lights CruISe Control Cus!omer Service . 5·6
3·3
3 ·4 ,
5·6 '·7 '·8 2·7 . . 4-5 2· ' 2·30
2·12
6·' Damage, Sheet Metal . 4·4 Detogger,Re..-WiNJoW.. 2-25 DelrOSlor. Windshield . 2·24. 2·25 Delay Wipers 2·20 Descending a· Grade 2-9 Ditlererlliai (Rear Axle) limited·Slip __ 5·9 ,Malt)l~O 5 ·9
Trailllfing. 1·1 2
Dimensions 7· , Oimn'\e( Switch, Head~L 2·14 O ipshCks A.utomalic Tfansmission .. . 5-4 Engine Oil 5·3 Power Steering. 5-9 Directional Signals.. 2-7 Disc Brakes 2·15 Door loc::ks . __ ................ 1-2 Orivet' Checklist 1-1 Driving Down S teep Grades .... 2-9 in OU'sty Areas . 5 .... on Slippery Surlaces .................... 2·9 Economy ripS. Fuel .............................. 2-4 E lectric· Po_oo QpIion$ .. (See "Power"') Electrical System Banerv .. S-1 0 Bulbs .. . ....... ...... .... ........... 7,4 Circuit Breakers ....... , ........................ , 7-3 Fuses:. 7·3 GEN (Genefalor) lighI ..................... 2· 17 Jump S tarting 3- Spark Plugs 7-2 Voltmeter . 2·19 Emetgency. In Case oj Bralle WCIIllWlg li!1Il .. Eroglne Hot light .. • .. 2·17 . 2·17

Downloaded from www.Manualslib.com manuals search engine Freeing Vehicle When Stuck . Hazard Warnong FlaSher Jacking Jump Starti ng
Towing: Cru EtIlIssion Caution EmISSic:m Control
3·9 3·' 3·4, 3'5
C ata lytic Conve rter 5-2 ~te< Command ContrOl System 2·18. ; ·3 CHECK ENGINE ligh t Exha ust Ga s Caution
F uel Requ irements (Gas) E",,~
2·18. 5·3 ,., , .,
... " Break -In Code Coo~ng
(See Ma intenance Schedule) 2·2 , .; ;·6 El ,.,
.. , 2·9 ,.,
(See "Fuel") ' ·5 . .. 3·1 Ideflti hcation Jump Starting . C>r Overheating . Spec~fcations Starling . Cold WeaHJeI Star ting (Gasoline) Temperature Gage Tempera ture 19h1 Thermostat E OOIN E ligh!
{See ··Oir . . EllIjne··) 3·3 ,., ,.,
'·6 2·t9 2· 17 5·6 2·t8 El"9oo Oil. (See ·'Oi l. E'ngine.') E thylene Glycot Antifree ze
E)(hausl Gas Cau tion E~~. System , If'Ispection. Ederior Fnsh Care .
Fabric Care
Fan,
Healer & Air Cond FASTEN SEAT BELTS Light. . Fastener s. RepIacemeflI .. Fifter s
Air Cleal'lEl!' . , Finish Care. Firish Damage . Flammable C\e.aoets .. .. F lashers Hazard w arning . Turn Signal..
Flooded EngIne . Starling . Floor Controls .. F luid Capacities .. FM Radios .. Folding Seats ...
5·' ,.,
, .,
... . 4·4 ,., 2-24. 2·25 '·6 5 ·'
;., ,., ,., . . • -1
3·.1 ..... 2:7 . ....... , 2·9 ......... 2·13 ..... ..... 7·1
F Ofeign CounlrllltS . Operation in ... FOUl' Season Ioit ~ . Four·WayHazard FlasheI' ... Freedom Battery .. Freeirig Car When Stt.JCk.". , .... Cop . Economy Tips .. Gogo Gasohol .. a...... Octane RaIing ..
;., , ., . 2 ·15 . '. ..... 2-3 ....... .. . 2-3
7 ·7
Overse3$ OpefatiOtl _. Tanl( Capacity Fuse
Cha rt
Circuit Breakers ...
""'" Engrne Temperat lJ'e
Fuel.. Oil Prossure Tachometef (Engille $peed) Voltmetet' , .. Gasoline
GEN (Gener ator) Light
Glas s Clea ning
Gto"e 80)( Guard AQaIIlSl Theft Hazar d Warning Flasher Headlight s Circuil &eakel IJimmtIf Switc h
instrument Pa~ SWitch Light s ON Reminder .. Head Restraint s .. tEAT Light. Heated Rear Wmdow .
2·' ,.,
'·3 '·3
2-1 9 2-15 2·19 2·18
2· 19
(See "Fuer') 2-\7 ..,
2-16 ,.,
3'
.7-3 2,14 2--?1
2-21
'·5 2·17 2·25 Heat er/Air Condihoner2·23. 2-24 High ·Beam Head~ghl!i 2-2t _ 1·13 5·10 . (Inside Back Colter) 5·10. !Inside Sack Cover)
Hitches. Traile( . Hood Latches .. Hood Release . Horn .. HOT UghL Ideotihcation Nt.mbers 19r>ilion K9YS Lock . In Case of EIT1efgenc:y .nocator lights ... Infant Seats & Aestra.nt .. II1l1ati04'l Pressure. Tires. Inlets . Air.
2-t3 2·t7 7.·5
,.,
2·' ,., (See "UghIS") 1 ·10. r_ll 5·12 2·23 Inside Rearview Muror , '-3 Instrumetl t Pan&! & Controts .. 2·15 InleilOl Appe«i¥1Ce Care.. 4-1 Interior & inst rumen t Lights (See "Lights" ) Jacl:: Operation & Stowage.. 3- 4. 3 ·5 . 3-6 ~ S\aI1ing .. 3- 1 Keys...... '·1 Lane Ct\ange &. Turn Signals 2-7 Lap- Shoulcler Belts . (See "Seat Bells") L_
,_­Hood ...
,..
(Inside 8acto: Cover) Sealback. From. 1-4 Trunk . 2-22 lighter. Cigarette ... 2·22 ligh<' BRAKE .... ...................... .................. 2·1 7
Bright s On. !lui> c.... O£CI( ENGINE Choke Warning .. Comoring .................. . CouttKY·· ClimrneI-Swoi1ch. HNdigflt .. Electrical S)Stem (GEN) ..
2-21 ,..
2·18.,5·2 2-17 .. ....... 2-7 '·30 2-1. 2-11

Downloaded from www.Manualslib.com manuals search engine ~_ fOIl a/or OdIe) ... .. 2·17 Engine -T""1* .... -(tOn... . ..... -2·17 FASTEN SEAT BELTS._ .......... -1·5 GEN (Electrical Sysl.m) . . ........ 2·17 Hazard War'rWIg Flasher . . ........ . 3·1 Headlight Circuit breaker.. . 2·~.7·3 HeedigtIf SWi1ch ••...• _ ..... ......•..•...• 2·7. 2.21
HeadIirj1ts On Reminder .. . ....... 2-21 Hi!tI·Beam rdcaIor .. . ....... 2·21 t-K>T. . ...........•.• _ .. ....... ....... 2-'17 Instrumenl Panel... ...... 2.15 Interior .... 01.. (PresstMe) .. ... .
--
....• . '2-30 2·19 ...... 2·14 Seal Bell FIerrindBf.. 1·8 Switch Headlights ................. ......... 2·21 TEMP (Teq)8falU'e). . ...... 2,19 LJmited·SIp Oift«enIiaI.. . ........ _5--5
""'" DOOr, . • ... ... ... 1,2 ._ .... . 2·16 GloVe Box .. 19ni1ion .. .... ............. ....... .......... _ .. 2--6 Keys ,.,
Theft Protection .... ..... ..... .........• ............. 2:2 Tn,ri:. -Powcw I\aIease .. ... 2·22 Low Seat. Child & ""8111.. . ... _. HI _ Luggage /Cargo Capacity. ; ..... ,. ..... 5-11 Mainlen PressUfe Gage ... Pressure ligtll .. RecommendaTion .
5-3. 7·1 ................ 2·19 . ................. 2·17 . ........ 5- ,3
Turbo Chaoge Interval .... ........... 2·33. 5-4 01.. Ught . . .......... .... 2-17 Openings. Roof ....... ... .. : ..... (See " Roofs") Opening 'The Hood (tnside Back Cover) Trunk ..... 2-22 Windows 1-2 Operating SpeecI$ . New car . __ -2-2 OperMing rIPS Fuel Economy .. : .... : ..... . __ ... 2"" Trailer Towing.. 1-12 Transmission .. . .... ...... 2-9 V...tilaeion Sys&em.. . ...... 2-22 Openllion ., Foreign Countries .. 2-4 Outside AIIarYiew Minor. _. . 1·3 Overheating" Engine 3-3 'Oversees Operation .. 2-4 7-8
............. Pwting Brake Pa1cing Lights ... PCII Valv. & Filter ...
... 2·. . 2·14 ... 1·. .... 7·2 Pat.1 Travel, Brake ............................ 2,14 Poishing ' & Waxing.. .. ....... ..... .......... 4-4 PoIUion ~ .... (see "Emission ConIrol")
""-~ ... Brakft: .. Door LockS .. Seett ...
.............. .......... 2-25 . .................. 2 ·14 ' ·2 .................. . 1-3 --.g ........................... . .., 2-11 2·22 Trunk Refease-.. WIfIdOoWs .. .... '·3 Pressur •• Oil GagII... .. ..... ..... ...... 2·19 L911... ............................ .. .... 2·17 Pr ....... e. ne Innation .. . So-I 2 P\..tse ""* .. 2·20 I!'ushing to Start.. . .... ..... ............. .... 5-2 ........ Andfreaze (Coolant). .. 5-6 CAp. Pressure ... . ................... ....... 5-8 o.ddng l..IMI' ... _....... ......... 5-6 0vemee8ing .... 3·3 Tha-mostat... .. 5·8 Aldol & Antennas... .. ...... 2-26 • 2~29 ..... wndoW Defogger ... . ................... .... 2-25
--I.irJWted.SIip ...... ....... 2-30. 5-9 MainTenance. ... 5·5 Stanc*d . .. 5-9 Tra iletlng.. 1·12 ReaMew Mirrors 1 -3 Aeco-v Tn. Coolant ... __ .-.................. 5·6 -.. Hood .: ' .. .' ... ' (Inside Back Cover) Seatbac k Latch 1-4 Trunk ... .. .... 2-22 Reminder Lights .......... ....... {See "L ights ") Replacomenl fastlilOef s. . .. 5· 1 Reptacement Maint9l1anc; e Schedule. .,' 5· t Reptacement Owner's Manua:.. (See Older Form) Replacement Parts.. . ....... ..... ... , ..•. 5-1 ReWaints ... Rests. Head . {See "Seal Sells") ..... 1-5 .. , 3 -9 Rocking Car When Stuc k ... RooIs C.rying cargo On .. SunrOQll ...... v-.nyt ...... ____ .... _ ......
'·2 . ..... 2 ·30 ______ ..... ...... 4-4 AotiMiOn. Tire .......... ........... .............. ..... 5·13 Ruslprooting.. .. ........ 4-5 Rust Protection SaMIy Belts .. .....
........ 4-5 .. {See "Seal 8eIts .. )
_ .............. , .. . .. .... '·4 1 ·10 CtIiIcI ...... .................. .. ~ .. . .............. ... ... 1,3 Heet RMltaints ............................... " 1-5 laIcl'lM ..
.... -
. . ..... .... .......... .. 1-4
c. ................................ .. • ... 0&-3 1·10 Child Reser ..... .

Downloaded from www.Manualslib.com manuals search engine -. lap/ShOulder ..• light/Buzzer Reminder .. Pregn!lll1 Women ..
1-10 ,., ,.,
,.,
Rear Seal.. SeIr·~stiOg BrakE!S .. SENSOR Indicator:
......... 1-8. 1-9
Sensor, Oxygen .. serviCe & Maintenance Service Station Information .. CoVer)
_ 2-14 5·3 '·3 5·' (Irisioo' Back
ShOOt Metal Damage". Shoulder Belts .. Sidemarker ,lights.
4·5 (See "Seat Betts")
Signals. Turn .. Slippefy Surfaces, Driving On .. Snow Chains
Snow Tires _. Sounds (Buzzers. Tones,elc.) Disc Brake Wear Indicator.
Headlights On .. Key Reminder. Seal Bell Spare Tire
"""-Jacking Stowage Spark Plugs Sound Systems (Radios): Speakers .. Spatilicatlons
Speed,CrUise Control .. S~. New Car Break-In. Speedometer & Odometer Spot Cleaning Stainless Steel Protection. stains. RemOval' 01".,.; Starter Salety Switch Starting Emergency (Jump. Starting). Engine Fails to Start Gasoline Engine. Pushing to Start. Steering Column Controls Column lock. Power .. Wheel, Till Stereo. Radios & Tape Systems 2·29 Stowage 0( Tire & Jacl< Stowing Things In (Or (0) Gat StucfI. Car, Freeing. Sunrool ................... . Suspension Ball Joints Tachometer Tape Systems, Stereo T ernpei'ature Gage T~ature light Thefmostat
2-26,
7-4 2·' 2·' 5-15
5-15
2-15
2-21
. 2-7 ,.,
3-8 3·5 3·' 7-2
2-26 2-27
,., 2-12 2-2 2-15 4·2 4·4 4-3 2·'
3-, 2·' 2"8 5·2
2·6 2·6 2-11
2-11
2-28,
3·' '·2 3·' 2·30
5-10 2-18 2-27
2-19
2-17 5·' Tilt-Away Steering Whee! 2-11 TipS. Operating (See "Operating TIPS" TlreS) Air Pressure. 5-11
7·9
ChainS ..
-. Cleoning. 5-15 3-4,3-5,
U .; _ ... 4 .... 3·6 """-' -.. H..,·_ .. . ............. _ ..... _ ...... 5-12
Inflation Pressure. Load Capacity .. Load Range .. Overseas Use. Placatd .. PreSsur&,·Ait.,
Replacement WhOOIs .. Stowage .. Trailer Towing. Top Care, Vinyt .. Towing OisablOO Vehicle .. To start .. Trailaring .. Transmission
........ 3-4,3-5, 3-6 5-12 5-11 5-11 . ............. ; ... 2-4 . .......... _ ... 5-11 5-12 5-17 3~5. 3-6,3-7 1-12 ...
,., .._ .... : .. 3-9 1-12
Automatic .. (See ,'Automatic TransmiSSion") Transmitter, Mobile Radio .. Trip Odometer .• ... T,,... Driving With Trunk Open ......... 2-2 Key. 1-1 Release, power .................... 2·22 Turbochafgef Oil Change_. 3-33 Turbocharger Power ...... ....... , ........... 2-32 Tum Signals.. . .... 2-7 Unleaded Gasoline (See "Fuel") Upholstery Care _. . 4-I
Vehicle Identification Number 7-5 Vehicle Loading.. 5·11
Ventilation System.. 2-22 Vents, Outside Ail".. 2-22 VIN 7-5 Vinyl
Fabric Care Root Care .. Vollmeter ..
... 4-2 4-4 2-19
Warning Flasher, Hazard Warning. Lights .. '-3-1 (See "lights-:) (See WarrantY folder) Warranty Washers,· Windshield
Washing Car. Waxing & Polishing . Wear Indicators, Disc Brake
Weight, Load Carr'iiog. Wheel Changing Wheel Nut Torque
Whgels, Replacement
Wheal, Till Steering.
Windows Manual.
Pow~ Rear, Defogger .. Windshield
2-19
. .............. 4-4 ...... 4-4 ........ 2-15 5-11 3-5 . . 3-6 3-7, 7-2 5-17 2-11
Defrosting & Defogging ..... , ............. 2-25
Washer Use in Cold Weather .. 2·20 2-19 2-19 Washer Fluid .. Wipers & Washers
Wrecker Towing
Zone Offices .. ................. 3-9 6-2, 6-3