1981 CHEVROLET MONTE CARLO tires

Downloaded from www.Manualslib.com manuals search engine 2, Never leta child stand ,or kneel on any seat Children who can sit up by
themselves should
be placed on a sealand restrained with the seat belts
provided, When children ride in a rear seat, .they should be restrained with
a lap
belt, When child(en ride in the front seat, they should wear both lap
and shoulder belt If the .shoulder beH irritates the neck or face due to .the child's size, this may be r.educed by placing the child closer to the center
of the
vehicle , If irritalior Is not reduced, place the child in the rear seat
3, General Motors ~iseS that childr"", be restrained properly when riding ,
However. unusual cond~ions may prevent use of restraints. and require
that a small child
stand, If that ~s.lhe'Child should stand on the floor , behind the'driver's seat This will help reduce the chance and/or \he
severity of injury in case of a frontal collision, --'-'-'''"''''''''i''':>' ~7','" ,,.' ;.,,~"".'. _ .. .. ,
TRAILER TOWING
This car is designed and intended to be used mainly to carry people, Towing a
trailer will affect handling , durability and economy , Your safety and satisfaction
depend :,upoQ proper use of correct llqUipmenl. Also , you should avoiq
overloads
and other abusive use,
' The '
!1'lIiximum 1000000trailet: weight youe;mpull with your vehicle depends ,on what special equipffienrfi'as been installed on il,. We do not recommend towing
any
trailer more than 450 kilograms (1.000 pounds) gross trailer weight unless your vehicle has the required 'equipment
.. .... ~ ' °' -"""''1111'''.''-'' .. J~._ .. _ '."'-:,_, :" .,', .... ,,', , ,'" :', : ' . .. ....... :.' .... " ..... : .. , :"',' "'." ,: ",' ,i,.:." .... __ .. -:,:· .. ,,' .. _." . .'~:.,:;.,~')ff';:.' CAUTION: Do not .. try to tow .. • nv:,,. tr-I.-'r ,mqrtt:,_lt)arr ' 2 '2., Idfogranl( (5,000 Pounds) WPU trliler,we~t IlC) 'In.tter what trailer toWing -'equiprrient is instelled. Trai" over iMM maximum-~_iir:nlt.,-c:OuId teriously affect ~ __ vehk:"'. pertormence ; -_durability and
handling, ~_~kf l'esuh. in personal i~~;_-_, ;""_~ ':~.,,:.:.
Information ,on trailer towing ability, speciateq(Jipn1ent required, and optional
equipment available should.be obtained from your dealer . Ask for the trailering
~rocliure, Or, write: Consum~r Helations Department Chevrolet Motor Divfsion,
Warren , Michigan 48090. (In Canada, write to General Motors of Canada
limited , Customer Services Department, Oshilwa , Ontario L IJ 5Z6),
Tires
When towing trailers be sure your tires areprope,ly inflated'to 'the inflation
,
pressure shown 'on the .. Tire Placard on \he driver's door , The allowable
passenger . and cargo load for this vehicle, also.shown on the Tire Placard , is
reduced by the traiter tongue weight whenever . the trailer is attached to the
'v~hicle, See "Service arid Maintenance," Section 5, for more tire informatlon ,
Maintenance
More' frequent service is required when using your vehicle to pull a traileL See
Section A of the Maintenance Schedule folder for Automatic Transmission Fluid , Engine Oil, and Hear Axle Ltibricantchange requirements for. trailering ,
Now and \hen, check that all trailer hitch bolts and nuts are tight Also see the
Maintenance Schedule
foider, and the Index in this manual, for important facts
on belts, cooling system care and brake adjustment.
1-12

Downloaded from www.Manualslib.com manuals search engine OPERATION IN FOREIGN COUNTRIES
All models which have the Computer Command Control system, (see "Service
and Maintenance," Section 5), are designed
to use unleaded gasoline as
specified under
"Fuel Requirements" in this section of the manual. Therefore,
these cars are not intended for use in areas where unleaded gasoline is
not readily available,
There also is a chance the gasolines available in some countries will not meet the needs of your gasoline engine even if it is not equipped with the Computer
Command Control system; Low~octane-ratedgasolines may cause engine pre­
ignition and serious engine damage, for which Chevrolet is not responsible.
In either case (with or without the Computer Command Control system), the
use of leaded gasoline will cause the emission control system to lose its
effectiveness.
It could also affect coverage· under the emission warranty. In
case of emergency, leaded gasoline may be used in your vehicle if unleaded gasoline is not available, but it should not be used exclusively. If you must use
leaded gasoline exclusively
in a vehicle designed for unleaded gasoline,
different maintenance intervals will be required. For additional information and
a copy of the maintenance schedule write to: Chevrolet Motor Division, Consumer Relations Department, Warren, Michigan 48090, (in Canada, write
to General Motors of Canada Limited, Customer Service Department, Oshawa,
Ontario
L 1J 5Z6).
When writing, please
include:
•
the Vehicle Identification Number and
• the countries in which you plan to travel.
Tires
If you plan to use your vehicle in countries where speeds over 75 mph (120
km/h) are allowed, see lIem3 on page 5-12.
IMPORTANT FACTS YOU SHOULD KNOW ABOUT FUEL
ECONOMY AND HOW
TO IMPROVE IT
How you drive, where you drive and when you drive all affect how many miles/
kilometers you can get from a galion/liter of fuel. The careful attention you give
your vehicle as far as maintenance and repairs are concerned
will also help
fuel economy.
Fuel Selection
Use only unleaded gasoline meeting the octane ratings given under "Fuel Requirements" in "Starting and Operating," Section 2 of this manual.
Unleaded gasoline must be used. for the. emission control ,system to operate
properly. Leaded gasoline will damage the Computer Command Control system
oxygen sensor and affect emission control. Using leaded gasoline can also
damage other parts of the emission control system and
CQuld result in 19s8 of
emission warranty coverage.
"Jackrabbit" Starts
You can save fuel (and prolong engine and tire life) by avoiding fast starts
away from lights and stop signs.
2-4

Downloaded from www.Manualslib.com manuals search engine Tire Inflation
Underinflation not only causes needless wear 01 the tires, but can also waste ' fuel. It's a good idea to check tire pressures often and, fO( the best fuel
eccnomy, keep your tires inflated to the highest pressures shown on the Tire
Placard on the left front door of your vehicle .
Wheel Alignment
Improper toe alignment will cause the tires to roll at an angle, which will result in faster tire wear. It takes' power to overcome this improper alignment which.
in turn, wastes fuel.
STEERING COLUMN CONTROLS
ANTI-THEFT STEERING COLUMN LOCK
The anti-theft lock (ignition) on the right side of the steering column has five
-""'positions: .
• Accessory-You can use SO the top of the key toward you.
• Lock -Normal parking position. It locks the ignition and prevents normal use
of the steering
wheel and shift controls. The ignition key cannot be turned
to "Lock" and removed until the shift lever is moved to "P"(Park).
• Off-You
can turn off the engine without locking the steering wheel and shift controls.
• Run-Normal operating position.
• Start-Cranks the engine.
If you have trouble turning the key to uniock the ignition, first be sure the key is
pushed in
all the way . Then , try to turn the steering wheel as hard as you can
in the direction the
wheels are turned. At the same time, turn the ignition key
with as much effort as you can apply with your hand; Do not try to use a tool of
any kind to
apply more force on the lock knob, as this could break the knob .
NOncE: Do not drive through, idle or park your vehicle over combustible marla Is, .uch •• grass or leaves. They could touch the hot eJlhauat .ystem .-.cIlgnite.
Parking
When leaving your vehicle unattended :
2-6

Downloaded from www.Manualslib.com manuals search engine JACKING
CAUTION
To help avoid personal injury:
• Follow air jacking and stowage instructions.
• Use jack only for lifting this vehicle during wheel change.
• Never get . beneath the vehicle, start or run engine while vehicle is supported by jack.
• Always securely restol" sp!.re tire (orflattire) and all jac king equipment.
Wheel Nut Torque .
CAUTION: As soon as possible atter installing a wheel -AND at the intervals stated
In Section 'S of the Maintenanc," Schedule folder --have a technician tighten wheel nuts with a torque wrench to the specifications shown in "Specifications," Section 7 of this manual.
Wheel nuts should be tightened alternately and evenly to the correct torque.
Never use oil or grease on studs Of nuts.. Jrnproperty tightened wheel nuts could eventually aUow the whee! to come off while the veNeta Is moving, -po$$rbty causing
personal injury , damage and/or klss of c_ontrol. (Also see the "Replacement Fasteners" Caution In "Service and Maintenance ," Section 5 01 this m8nu81 regarding the danger of mixing metric and custom,sry fasteners. And, see the "Replacement Fasteners " Caution
under "Tires" in the same seclion regarding the importance of obtaining good metal-to­
metsl contact.)
Stowage ·of. Tire . and .!aC;.k,. . .
CAUTION: Always securely restow the spare tire assembfy (or nat tire), all jacking equipm ent, any tire inflator, and any covers or doors, using the means provided. This will help keep such things from being thrown about-and injuring people In the vehicta d.Ufing a sudden maneuver or an accident.
Before stowing
the tire, be sure:to clean the tire well 01 anything that would keep the tlr. from resting on the bOttom of the well. To stow the jack, place its lever in the "UP" position and. move the handle back and forth until the column is ·secure in the receiver (see Illustration). If these steps are not taken, the tire or lack may push against the trunk lid so thai the trunk lid cannot seal tightly. This _ may allOw carbon monoxide from the '. exhaust system -to get _inside tiMt c • . ttvougtl the trunk. (See "Engine -Exhaust Gas Caution (CaroonMonoxkle) " al the beginning of "Starting and Operating,'; Section 2 of this manual .)
Extended Vehicle Storage
If you plan to store your vehicle over an extended periOd of time, certain steps
should be taken to give it maximum protection.
It is recommended that you
write the Chevrolet Motor Division , General Motors Corporation, Consumer
Relations Dept., Warren , Michigan
48090, for detailed instructions on how to
prepare your vehicle for storage .
3-7

Downloaded from www.Manualslib.com manuals search engine Cleaning Rear Glass
tf abrasive cleaners are used on the inside of the rear window, any electric
delogger element may be damaged. Avoid placing decats on the inside rear
window since they may later have to be scraped off. II you use a tempcrary
license, take care not to attach
it across the delogger grid.
Cleaning Glass Roof Panels
Never use abrasive cleaners'''on any glass roof panels, such as Vista~Vent as
they may cause scratches. AI,sQ, if you use such cleaners on the inside
surface , the tinted coating may be damaged. Avoid placing decals on the inside
surfa ce which may
later have to be scraped off.
CARE AND CLEANING OF THE EXTERIOR
Exterior Finish
The paint·lii'ish on your vehicle provides beauty, depth 01 color, gloss retention
and durability.
Washing Your Vehicle
The best way,lo,preserve your vehicle's finish is to keep it clean by frequent washings. Wash the vehide in lukewarm or cold water.
Do not use hot water or wash your vehicle in the direct rays of the sun. Do not
use strong soap or chemical detergents . All cleaning agents should be lIushed
promptly Irom the surface and not allowed to dry on the linish.
J?olis!lil,!9,.~nd Waxing Your Vehicle
Polishing is reCommended to remove built-up residue and eliminate any "weathered" appearanc~.
Your dealer offers several polishes and cleaners which have proven value in
maintaining original finish appearan£e ~ -durabtlity.
Protection of Exterior Bright Metal Parts
Bright metal parts should be cleaned regularly to keep their luster. Washing
with. water is all that is usually needed. However, you may use GM Chrome Polish on CHROME or STAINLESS STEEL trim, il necessary.
Use special care with
ALUMINUM trim. Never use auto or chrome polish, steam or caustic soap to clean aluminum. A coating 01 wax , rubbed to a high polish , is recommended lor all bright metal parts.
Cleaning Aluminum Wheels
Preserve the original appearance of aluminum wheels (il your vehicle has
them) by keeping them clean and Iree lrom build-up 01 road dirt and/or road
salt. Regular cleaning lollowed by a coat
01 paste wax (such as GM 1 050~37 "Finish Guard") is recommended .
Cleaning White Sidew.all Tires
Use GM White Sidewall Tire Cleaner or a tire cleaner which will not harm
aluminum wheel trim. A stiff brush may be used with the cleaner .
4-4

Downloaded from www.Manualslib.com manuals search engine PART NUMBER
1051516
1050017
1052277
1050172
1050173
1050174
1050214
f' 1050237 .... 1050244
1052280
1050427 1050429
1052349
1050729
1051055
1051398
1051515 1051172 1051855 1051858
1052103
1052271 1052272
APPEARANCE CARE AND MAINTENANCE MATERIALS
SIZE DESCRIPTION
32 02. 10.946 U Washer -Solvent and Gas Line De-Icer 3 '2 oz, (0.946 LI Power Steering Fluid 16 oz. (0.473 LI Spray-A-Sq ueak
16 oz. (0.473 L) Tar and Road Oil Remove'r 16 oz . (0.473 L) Chrome Cleaner and Polish 1602.10,473 LI WhiteSidewall Tire Cleaner , 32 oz. 10.946 L) Vinyl/Leather Cleaner 16 oz. 10.473 L) Finish Guard Cleaner 16 oz. (0.473 L) Fabric Cleaner 1'2 oz. 10.354 L) Heat Valve Lubricant 23 oz. (0.680 L) Glass Cleaner 6 lb. 12.72 kg) Multi·Purpose Powdered Cleaner
16 oz. (0.453 kg) Lubriplate (White Grease) 8 oz. 10.237 Ll Vinyl Top Cleaner 16 oz. (0.473 LI Preservatone 8 oz. 10.237 L) Spot Lifter 32 oz, 10.946 LI GM Optikleen 20 oz . (0.567 kg) presofl®ed-Cleaner/wax 32 oz. 10.946 U Dexron II 16 oz. (0.473 1I GM Engine Oil Supplement (E.O.sJ 1 gal. 13.785 L) Anti·Free ze Coolant lethylene glycol base) 23 oz. 10.680 L ) GM Gear Lubricant 15 gal. (60 L) GM Gear Lubricant
USAGE
Washer Solvent and gas line Oe-icer Power Steering Weather Strips -stops squeaks on metal-to-metal and metal-to~ rubber contact Removes old waxes, polishes, tar, and road oil Removes rust and corrosion on chrome and stainless steel
Cleans white imd black tires Spot and stain removal on leather or vil'lyl One step cleaner and wax and aluminum· wheels Spot and stain removal on cloth and fabric Free up sticky heat ri;ers -general purpose penetrant Glasscleaning and spot cleaning on vinyls
Cleans vinyl and cloth on door trim, seats, and carpet-also, tires and mats Grease for hood, trunk and door hinges and latches
Cleaning of vinyl tops Viny l Top Dressing SPOt and stain removal on cloth and fabric
W indshield washer solvent and anti-freeze One step c leaner/wax Automatic transmission Consult your Dealer for specific usage
Year round coolant and anti-freeze Rear axle lubricant Same as 1052271

Downloaded from www.Manualslib.com manuals search engine Air Conditioning
Your vehicle's air conditioning system will not operate below ambient
temperatures of 4'C (40"F) regardless of control position. .
See your
dealer immediately H you suspect the system is not performing as it
should.
TIRES
CAUTION: T~\'reduce the 'risk of lose ~VehiCIe control and Person.1 injury:
• TTres MUST BE prOperly Inflated, .nd your vehicle MUST NOT BE overkMtded (see 1M r.e PtacM'.d _1Oc_.c:t on the driver's door).
• Voui" vehicle MUST NOT BE operated cti, lpeedsfaster than 85 mph (140 ~m/h) unless it Is equipped with poIi~ pursuit tires or equivalent high-speed capability ti,es.-regardhtss 01 the ~ speed lmtt.
For more Safety InfOrmation. ~ the rest or this " TIre" section.
The tires installed on your vehicle are engineered to provide a proper balance
of these performance characteristics under normal driving conditions.
• Endurance
• Handling
• Noise
• Ride
• Road Hazard Resistance
• Rolling Resi.stance
• Traction
• Tread Mile'age"' •... .... <.
This section has some tips on how you can get the most benem from these tires. '
Vehicle Loading
The tires on your vehicle will perform well at all normal loads when inflated as
recommended on the . Tire Placard (located on the driver's door of your vehicle) . Do not load your vehicle beyond the load Umits (total kilograms or
pounds) shown
on the·TIre Placard . The placard. tells you the design limits of
the vehicle, not
Just of the tires.
VEt«:lf CAP.l.CIl" DCGuI' ... " ,COLO Tff\E ffiESSURE ... _, ,., " •... 10'" ,_, "' ...
SPAR{ HR£
",,! " 1-::.:::(' 1 • SEE O~ S ~ANu ... i. FOR "'OI)IJ lQtjA,l INf-QAMATioN
5·11

Downloaded from www.Manualslib.com manuals search engine If the tires are other than standard load range (or load range B for metric size
tires). the
load range will appear after the tire size stated on the Tire Placard.
Inflation Pressure
The Cold inflation pressures listed on the Tire Placard provide for the best
balance of fuel economy. tire life. riding comfort. and vehicle handling under
normal driving conditions.
These pressures
should be used for all vehicle loading conditions. except When towing a trailer. See. "Trailer Towing in "Belore Driving Your Monte
Carlo." Section 1 of this manuaL
Incorrect tire inflation pressures can. have adverse effects on tire. lije and
vehicle performance. Too low an air preS$urecaul>eS incre f~lure,. It can result in tire overloading, abnormal tire wear, adverse vehicle handling. and reduced fuel~nomy .. Too high an air pressure can result in
abnormal wear. harsh ride. an.d can increase the chance of damage from road
hazards.
LUGGAGE/CARGO LOAD CAPACITY
Maximum Luggage Compartment Load
Coupe 72 Kilograms (160 Pounds)
"'"~~\"'_"~"""_'","",' NOTICE: Total combined weight of luggage _compartment 16ad •. ·.luggage rack load (when equipped). trailer tongue load and passengers must not exceed the vehicle capacity
weight (shown on the Tire Placard located on the left front door).
· ·' .L' Check tire inflation pressures at least monthly (this includes the spare tire) and whenever your _ vehicle is serviced. When -possible, check tire inflation pressures when'the tires are "cold."
1. The "cold" ttr~inflation pressure is the tire pressure when a vehicle has
not been driven more than one mile. (1.6 kilometers) after Sitting for three
hours or more. This is the most accurate setting.
2. It is normal for tire pressures to increase 30 to 60 kilopascals (4 to 8
pounds per square inch) or more when the tires become hot from driving. If you must set inflation pressures when the tires are not "cold," add 30
kilopascals
(4 pounds per square inch) to the recommended cold pressures on the Tire Placard.
3. For sustained driving at speeds of 75 mph to 85 mph (120 km/h to
140 km/h), in countries where such speeds are allowed by law, cold
inflation
pressures must be increased 20 kPa (3 psi) above the cold
inflation pressures stated on the tire placard up to the maximum for
each load range as listed in the Chart below. Sustained speeds of 75 mph to 85 mph (120 km/h to 140km/h) ar!! not allow!!d when the 20
kPa (3 psi) adjustment Would require the pressures of either the front or
the rear tiles to be greater than the maximum pressure for each load
range listed on the chart below. For speeds faster than 85 mph (140 km/h) follow Caution at th!! beginning of this "tire" section.
5-12