1981 CHEVROLET MONTE CARLO automatic transmission fluid

Downloaded from www.Manualslib.com manuals search engine 2, Never leta child stand ,or kneel on any seat Children who can sit up by
themselves should
be placed on a sealand restrained with the seat belts
provided, When children ride in a rear seat, .they should be restrained with
a lap
belt, When child(en ride in the front seat, they should wear both lap
and shoulder belt If the .shoulder beH irritates the neck or face due to .the child's size, this may be r.educed by placing the child closer to the center
of the
vehicle , If irritalior Is not reduced, place the child in the rear seat
3, General Motors ~iseS that childr"", be restrained properly when riding ,
However. unusual cond~ions may prevent use of restraints. and require
that a small child
stand, If that ~s.lhe'Child should stand on the floor , behind the'driver's seat This will help reduce the chance and/or \he
severity of injury in case of a frontal collision, --'-'-'''"''''''''i''':>' ~7','" ,,.' ;.,,~"".'. _ .. .. ,
TRAILER TOWING
This car is designed and intended to be used mainly to carry people, Towing a
trailer will affect handling , durability and economy , Your safety and satisfaction
depend :,upoQ proper use of correct llqUipmenl. Also , you should avoiq
overloads
and other abusive use,
' The '
!1'lIiximum 1000000trailet: weight youe;mpull with your vehicle depends ,on what special equipffienrfi'as been installed on il,. We do not recommend towing
any
trailer more than 450 kilograms (1.000 pounds) gross trailer weight unless your vehicle has the required 'equipment
.. .... ~ ' °' -"""''1111'''.''-'' .. J~._ .. _ '."'-:,_, :" .,', .... ,,', , ,'" :', : ' . .. ....... :.' .... " ..... : .. , :"',' "'." ,: ",' ,i,.:." .... __ .. -:,:· .. ,,' .. _." . .'~:.,:;.,~')ff';:.' CAUTION: Do not .. try to tow .. • nv:,,. tr-I.-'r ,mqrtt:,_lt)arr ' 2 '2., Idfogranl( (5,000 Pounds) WPU trliler,we~t IlC) 'In.tter what trailer toWing -'equiprrient is instelled. Trai" over iMM maximum-~_iir:nlt.,-c:OuId teriously affect ~ __ vehk:"'. pertormence ; -_durability and
handling, ~_~kf l'esuh. in personal i~~;_-_, ;""_~ ':~.,,:.:.
Information ,on trailer towing ability, speciateq(Jipn1ent required, and optional
equipment available should.be obtained from your dealer . Ask for the trailering
~rocliure, Or, write: Consum~r Helations Department Chevrolet Motor Divfsion,
Warren , Michigan 48090. (In Canada, write to General Motors of Canada
limited , Customer Services Department, Oshilwa , Ontario L IJ 5Z6),
Tires
When towing trailers be sure your tires areprope,ly inflated'to 'the inflation
,
pressure shown 'on the .. Tire Placard on \he driver's door , The allowable
passenger . and cargo load for this vehicle, also.shown on the Tire Placard , is
reduced by the traiter tongue weight whenever . the trailer is attached to the
'v~hicle, See "Service arid Maintenance," Section 5, for more tire informatlon ,
Maintenance
More' frequent service is required when using your vehicle to pull a traileL See
Section A of the Maintenance Schedule folder for Automatic Transmission Fluid , Engine Oil, and Hear Axle Ltibricantchange requirements for. trailering ,
Now and \hen, check that all trailer hitch bolts and nuts are tight Also see the
Maintenance Schedule
foider, and the Index in this manual, for important facts
on belts, cooling system care and brake adjustment.
1-12

Downloaded from www.Manualslib.com manuals search engine PART NUMBER
1051516
1050017
1052277
1050172
1050173
1050174
1050214
f' 1050237 .... 1050244
1052280
1050427 1050429
1052349
1050729
1051055
1051398
1051515 1051172 1051855 1051858
1052103
1052271 1052272
APPEARANCE CARE AND MAINTENANCE MATERIALS
SIZE DESCRIPTION
32 02. 10.946 U Washer -Solvent and Gas Line De-Icer 3 '2 oz, (0.946 LI Power Steering Fluid 16 oz. (0.473 LI Spray-A-Sq ueak
16 oz. (0.473 L) Tar and Road Oil Remove'r 16 oz . (0.473 L) Chrome Cleaner and Polish 1602.10,473 LI WhiteSidewall Tire Cleaner , 32 oz. 10.946 L) Vinyl/Leather Cleaner 16 oz. 10.473 L) Finish Guard Cleaner 16 oz. (0.473 L) Fabric Cleaner 1'2 oz. 10.354 L) Heat Valve Lubricant 23 oz. (0.680 L) Glass Cleaner 6 lb. 12.72 kg) Multi·Purpose Powdered Cleaner
16 oz. (0.453 kg) Lubriplate (White Grease) 8 oz. 10.237 Ll Vinyl Top Cleaner 16 oz. (0.473 LI Preservatone 8 oz. 10.237 L) Spot Lifter 32 oz, 10.946 LI GM Optikleen 20 oz . (0.567 kg) presofl®ed-Cleaner/wax 32 oz. 10.946 U Dexron II 16 oz. (0.473 1I GM Engine Oil Supplement (E.O.sJ 1 gal. 13.785 L) Anti·Free ze Coolant lethylene glycol base) 23 oz. 10.680 L ) GM Gear Lubricant 15 gal. (60 L) GM Gear Lubricant
USAGE
Washer Solvent and gas line Oe-icer Power Steering Weather Strips -stops squeaks on metal-to-metal and metal-to~ rubber contact Removes old waxes, polishes, tar, and road oil Removes rust and corrosion on chrome and stainless steel
Cleans white imd black tires Spot and stain removal on leather or vil'lyl One step cleaner and wax and aluminum· wheels Spot and stain removal on cloth and fabric Free up sticky heat ri;ers -general purpose penetrant Glasscleaning and spot cleaning on vinyls
Cleans vinyl and cloth on door trim, seats, and carpet-also, tires and mats Grease for hood, trunk and door hinges and latches
Cleaning of vinyl tops Viny l Top Dressing SPOt and stain removal on cloth and fabric
W indshield washer solvent and anti-freeze One step c leaner/wax Automatic transmission Consult your Dealer for specific usage
Year round coolant and anti-freeze Rear axle lubricant Same as 1052271

Downloaded from www.Manualslib.com manuals search engine un mUE SAl: VIScOSITY GRADES
F~O 20 40 60 100 C -30 -20 10 0 10 20 30 40 TEMPERATURE RANGE YOU .EXPECT SHORE NEXT Oil CHANGE
NOTICe: DO NOTUSE SAE 5W-2(I OILS fOR COIfi"INUOUS HIGH SPEED DRIVING.
Engine Oil Additives
There are many extra engine oil additives (or helpers) for sale. Your engine
should not need these extra additives if you Use SF-quality engine oil and
change it as suggested. If you think your engine has an oil-related problem,
talk
to your authorized dealer. If needed, your dealer can provide you with a
tested and approved oil additive called "GM Engine Oil Supplement."
AUTOMATIC TRANSMISSION FLUID RECOMMENDATIONS
Proper Fluid -Use only automatic transmission fluid labeled DEXRON® II. You
can buy this fluid from your dealer or other service outlets.
Checking
Fluid Level-Check the automatic transmission fluid level at each
engine
oil change, Overfilling GaI).c"!,J~e foaming and loss of fluid. A low fluid
level can cause slipping or loss of drive. In either case, transmission damage
can result.
To check the fluid
level, first set the parking brake, then start the engine in "P"(Park). With the regular brakes applied, move the shift lever through all the
gear ranges, ending
in "P". You must check the fluid level with the engine
running
at slow idle and the vehicle level.
You cannot read the correct fluid level if you have just.driven you(vehicle fora
long time at high speed, in city traffic in hot weather, or if your vehicle has
been
pulling a trailer. Wait until the fluid cools down (about 30 minutes).
Remove the dipstick
located at the rear of the engine compartment on the
passenger's side. Carefully touch the wet end of the dipstick to find out if the
fluid
is cool, warm or hot. Wipe it clean and push it back in until the cap seats. Pull out the dipstick and read the fluid level.
• If
it felt cool (about room temperature), the level should be 3 to 10
millimeters (118 to 3/8 inch) below the "Add" mark. The dipstick has two
dimples below the" Add" mark to show this range.
• If it felt warm, the level should be close to \he "Add" mark (either above or below).
• If
it was too hot to hold, the level should be at the "Full" mark.
5-5

Downloaded from www.Manualslib.com manuals search engine COOL
WARM
Add just enough DEXRO~ II fluid to fill the transmission to the proper level. It
takes only 0.5 liter (one pint) to raise the level from "Add" to "Full" with a hot
transmission.
Automatic Transmission Drain Intervals
Change the transmission fluid and change the filter (or clean the screen) as
outlined
in Section A of the Maintenance Schedule folder.
ENGINE COOLING SYSTEM
Your vehicle has a coolant recovery system. Coolant in the system expands
with heat and overflows into the recovery tank. When the system cools down,
coolant is drawn back into the radiator.
The cooling system was
filled at the factory wrth a quality coolant that meets
GM
Spec~ication 1S99-M . The cooling ·system is designed to use coolant (a
mixture of water and ethylene glycol antifreeze) rather than plain water. The
coolant solution should be used year round.
It has many advantages, such as:
~ provides freezing protection down to -3rC (-34"F) "''''''<~. !'"","."" ' • provides boiling protection up to 12S"C (262"F),
• protects against rust and corrosio~in th~ cooling system,
• maintains the proper engine temperature for efficient operation and
emission control, and
• allows proper operation of the coolant temperature light or gage :
See Section A of the Maintenance Schedule folder to find out when the coolant
must
be ·replaced.
Cooling System Care
Check the c60ling system at regular intervals, such as during fuel stops . You usually do not need to remove the radiator cap to check the coolant level. Lift
the engine hood and look at the "see through" coolant recovery tank. When
the engine is
cold, the coolant level should be at the "Full Cold" mark on the
tank . When the engine has fully warmed . up, the level should be above the
"Full Cold" mark on the tank . If the coolantl6vel is low, remove the cap on the
coolant recovery tank. Add to the recovery tank enough of a 50/50 mixture of
water and a good quality ethylene glycol antifreeze to bring the
level up to the
proper mark. Put the cap back on the recovery tank.
Certain conditions, such
as air trapped in the system, may affect the coolant
level in the radiator. You should check"the coolant level in the radiator at the
time you change the engine
oil and when the engine Is cold. Follow.taps I, S,
9, and 10 under "Coolant Repfacement" for the correct way to remove the
radiator cap and add coolant.
5-6

Downloaded from www.Manualslib.com manuals search engine AJt Cleaner. Ail CoricIitionor FOlK Season .. Mainten ance .. AM" Pressu-e. Tires. AM" Vents. Alterna tOf tGEN) l.ghl AUniIlUffi Cafe .. AM or AM-FM Radios Antenna Antifreeze . Appearaoc e Care . Ash1rays & Lignler s. Assistance. Owl"lef Automat ic Door Locks. Automatic Transmission CorwElfter ClUlch Maintenanr;e
"""'-OpefaJ .... '1 TiPS.: AKIe. Re ar Standard . lifnited-SHp . Babies. AesCraint 01 .. BaIt Joints .. fun..., E mergency S ta ring F reedom. Gas Caution ..• GEN 191I... .•.• Test Indicator ...
. ........ 5-9
2-24
5-11
5-12
2-23 ....... 2·17 ... 2:27. 2-28 2·29 (Seo "Coolant") ,.,
2·22 6·' ,.,
2·10 5-5 .. 2 -9 2 ·'
5 ·'
5·' 1·10. ,-" . 5·1 0
3 ·' 5-10 3·' 2-17 5·10 Betore Dr iving Your Vehide... \. Bells: Sea!....,.. . (See I'Se at Belts") Blower, Healer & Air Cond.. 2-24. 2-25
Body Da mage . 4-4
.. """ ~,. Pedal Travel Trailer Towing .... Warning Ught .
2·14 2-\4 H2 2-17
Breakers . <;ircui t. • ..... 2-21. 7·3 Bteak ..... Period. New Vehicle ..• 2·2 Srioj'!( Headlights 2·7. 2·21 Brighl Metal Cleaning 4-4
Bulbs & Fuses.. 7·3. 7-4 Bumpers & HiIC:·~s. '·13 ~ 'Jack Operation ...... 3-4 B.w:ers._ . (See "'SOunds'" CoirpJler Con"mand Cont rOl System:~ 2·\8, 5·3 Cop Coolant A ecovery Tant.: .. ................. , .. 5-6 F uel.. 5-2 f>o¥Iier Steefing.. _____ -._ ....... ...... 0<. _____ -5-9 Radiator ... 5·8 Capacity, Cargo Weight. 5-11 Capacities. FlUid:. 7- Car Break-In Period . New.. 2-2 . car -Chemicals ... carbon Monoxide cautJorI .... ___ 4·' 2·' Care & Cleaning. Appearance . . .. 4·' Cargo Capacity . 5-11 Cargo on Root . Carrying,. '·2 Catalytic Converter . . ..................... ....... 5-2 ~ Command Control System .. -2·18. , ·3 Chains. Tire .. 5·15
7-6
Changing Wheets & Tires .. _ Cl-£O< ENGtl'E light .. Chectlbt, DrillSf . Child Seals & Restr ainls Chrome Protection .. ag.yette lighter ... CirCUIt Beakers QtiZOtlS Band Raoio . C!earIing .. Clock.I .. Cloth Trim Care .. ClutCh . Converter
Cold W&ather Starting ....
3 ·4 . 3·5 2 ·18. 5-3 ,., I -tO. 1·11 ... 2·22 2·21 , 7·3 2·29 . ..... 4·' 2-22 '·2 2·10 2·8 ~ip""lt Plocedu.-e . . ... 6 ·1
Condi lioner, Air (See "All" Cooditioner"~ Cons umer Relation s ... Converter ClUtch Con...eJo: Mirror Cooling System Afltilreeze (CooIanI) .. Overheating R ecovery Tank Service,. Thermoslal . COfl"lefing Lights . CorTosion Pmlection. Countries. Oper-ating in Fo.-eign .. Courtesy lights CruISe Control Cus!omer Service . 5·6
3·3
3 ·4 ,
5·6 '·7 '·8 2·7 . . 4-5 2· ' 2·30
2·12
6·' Damage, Sheet Metal . 4·4 Detogger,Re..-WiNJoW.. 2-25 DelrOSlor. Windshield . 2·24. 2·25 Delay Wipers 2·20 Descending a· Grade 2-9 Ditlererlliai (Rear Axle) limited·Slip __ 5·9 ,Malt)l~O 5 ·9
Trailllfing. 1·1 2
Dimensions 7· , Oimn'\e( Switch, Head~L 2·14 O ipshCks A.utomalic Tfansmission .. . 5-4 Engine Oil 5·3 Power Steering. 5-9 Directional Signals.. 2-7 Disc Brakes 2·15 Door loc::ks . __ ................ 1-2 Orivet' Checklist 1-1 Driving Down S teep Grades .... 2-9 in OU'sty Areas . 5 .... on Slippery Surlaces .................... 2·9 Economy ripS. Fuel .............................. 2-4 E lectric· Po_oo QpIion$ .. (See "Power"') Electrical System Banerv .. S-1 0 Bulbs .. . ....... ...... .... ........... 7,4 Circuit Breakers ....... , ........................ , 7-3 Fuses:. 7·3 GEN (Genefalor) lighI ..................... 2· 17 Jump S tarting 3- Spark Plugs 7-2 Voltmeter . 2·19 Emetgency. In Case oj Bralle WCIIllWlg li!1Il .. Eroglne Hot light .. • .. 2·17 . 2·17

Downloaded from www.Manualslib.com manuals search engine -. lap/ShOulder ..• light/Buzzer Reminder .. Pregn!lll1 Women ..
1-10 ,., ,.,
,.,
Rear Seal.. SeIr·~stiOg BrakE!S .. SENSOR Indicator:
......... 1-8. 1-9
Sensor, Oxygen .. serviCe & Maintenance Service Station Information .. CoVer)
_ 2-14 5·3 '·3 5·' (Irisioo' Back
ShOOt Metal Damage". Shoulder Belts .. Sidemarker ,lights.
4·5 (See "Seat Betts")
Signals. Turn .. Slippefy Surfaces, Driving On .. Snow Chains
Snow Tires _. Sounds (Buzzers. Tones,elc.) Disc Brake Wear Indicator.
Headlights On .. Key Reminder. Seal Bell Spare Tire
"""-Jacking Stowage Spark Plugs Sound Systems (Radios): Speakers .. Spatilicatlons
Speed,CrUise Control .. S~. New Car Break-In. Speedometer & Odometer Spot Cleaning Stainless Steel Protection. stains. RemOval' 01".,.; Starter Salety Switch Starting Emergency (Jump. Starting). Engine Fails to Start Gasoline Engine. Pushing to Start. Steering Column Controls Column lock. Power .. Wheel, Till Stereo. Radios & Tape Systems 2·29 Stowage 0( Tire & Jacl< Stowing Things In (Or (0) Gat StucfI. Car, Freeing. Sunrool ................... . Suspension Ball Joints Tachometer Tape Systems, Stereo T ernpei'ature Gage T~ature light Thefmostat
2-26,
7-4 2·' 2·' 5-15
5-15
2-15
2-21
. 2-7 ,.,
3-8 3·5 3·' 7-2
2-26 2-27
,., 2-12 2-2 2-15 4·2 4·4 4-3 2·'
3-, 2·' 2"8 5·2
2·6 2·6 2-11
2-11
2-28,
3·' '·2 3·' 2·30
5-10 2-18 2-27
2-19
2-17 5·' Tilt-Away Steering Whee! 2-11 TipS. Operating (See "Operating TIPS" TlreS) Air Pressure. 5-11
7·9
ChainS ..
-. Cleoning. 5-15 3-4,3-5,
U .; _ ... 4 .... 3·6 """-' -.. H..,·_ .. . ............. _ ..... _ ...... 5-12
Inflation Pressure. Load Capacity .. Load Range .. Overseas Use. Placatd .. PreSsur&,·Ait.,
Replacement WhOOIs .. Stowage .. Trailer Towing. Top Care, Vinyt .. Towing OisablOO Vehicle .. To start .. Trailaring .. Transmission
........ 3-4,3-5, 3-6 5-12 5-11 5-11 . ............. ; ... 2-4 . .......... _ ... 5-11 5-12 5-17 3~5. 3-6,3-7 1-12 ...
,., .._ .... : .. 3-9 1-12
Automatic .. (See ,'Automatic TransmiSSion") Transmitter, Mobile Radio .. Trip Odometer .• ... T,,... Driving With Trunk Open ......... 2-2 Key. 1-1 Release, power .................... 2·22 Turbochafgef Oil Change_. 3-33 Turbocharger Power ...... ....... , ........... 2-32 Tum Signals.. . .... 2-7 Unleaded Gasoline (See "Fuel") Upholstery Care _. . 4-I
Vehicle Identification Number 7-5 Vehicle Loading.. 5·11
Ventilation System.. 2-22 Vents, Outside Ail".. 2-22 VIN 7-5 Vinyl
Fabric Care Root Care .. Vollmeter ..
... 4-2 4-4 2-19
Warning Flasher, Hazard Warning. Lights .. '-3-1 (See "lights-:) (See WarrantY folder) Warranty Washers,· Windshield
Washing Car. Waxing & Polishing . Wear Indicators, Disc Brake
Weight, Load Carr'iiog. Wheel Changing Wheel Nut Torque
Whgels, Replacement
Wheal, Till Steering.
Windows Manual.
Pow~ Rear, Defogger .. Windshield
2-19
. .............. 4-4 ...... 4-4 ........ 2-15 5-11 3-5 . . 3-6 3-7, 7-2 5-17 2-11
Defrosting & Defogging ..... , ............. 2-25
Washer Use in Cold Weather .. 2·20 2-19 2-19 Washer Fluid .. Wipers & Washers
Wrecker Towing
Zone Offices .. ................. 3-9 6-2, 6-3