1976 CHEVROLET MONTE CARLO oil type

Downloaded from www.Manualslib.com manuals search engine APPEARANCE CARE
CARE AND CLEANING OF
INTERIOR TRIM
IMPORTANT: Be sure vehicle is
well ventilated while using any
cleaning agents. Follow manufac­
turer's recommendations in using
such products ..
'
With the advent of modern trim
materials composed of synthetic
plastics and! or man made fibers,
it
is EXTREMELY IMPORTANT
that proper cleaning techniques
and
cleaners ·be used when clean­
ing interior trim. Failure
to do this
on the first cleaning may
result in
water spots, spot rings, setting of
stains or soilage, all of which make
it more difficult or impossible to
remove in a second cleaning.
Certain portions of the following
cleaning instructions are in bold type;
they are particularlyimpor­
tant and
must be performed.
Dust and loose dirt
that accu­
mulates on interior fabric trim
should
be removed frequently with
a vacuum cleaner, whisk broom or
DESCRIPTION"
G.M. Spot Lifter (8 oz. Solvent Type)
soft brush. Vinyl or leather trim
should be wiped regularly with a
clean damp cloth.. Normal trim
soilage, spots or stains can be
cleaned with the following G.
M.
cleaners.
G.M. Multi-Purpose Powdered Cleaner (16 oz. Foam Type)
G.M. PART NO.
1051398
1050803
·T~e a.bovecleaner~ arB EXCELLENT CLEANERS when used properly 'aoc.ordlng to
directions on containers. They are available through your Chevrolet Dealer.
4-1

Downloaded from www.Manualslib.com manuals search engine NEVER use gasoline, nail polish
remover or acetone , lacquer thin­
ners, bleaches, etc, Some basic
steps should .be remember .
ed before
the cleaning
is attempted:
1. Removt! stains as quickly as pos­
sible
before they become "set'" -':"..
2. Use a clean cloth or sponge and
r,hange to a clean area fre­
quently.
(A soli brush may be
used it stains persist.)
3.
Use s<:llvent· type cleaners in a
well ventilated area, also, do not
saturate the stained area.
4.
If a ring should form after spot
cleaning, the entire area of the
trim assembly should be cleaned
immediately.
5. Follow instructions on the label
of the cleaner.
Cleaning General Soilage
or Water Spots from Fabric
Type Trim with Foam Type
Cleaner
G.M. Multi-Purpose Powdered
Cleaner
is excellent for this type
cleaning and for cleaning a panel
section where a minor cleaning ring
may be left from spot cleaning.
Vacuum
aria thoroughly to re­
move excess loose dirt.
AL WAYS
clean a full trim assembly or com­
plete trim section-mask adjacent
4-2
trim along stitch or welt lines. Mix
Multi-Purpose
Powdered Cleaner
in strict accordance with directions
on label of coritainer-mix propor­
tionally for smaller quantities.
USE
SUDS ONLY ON
A CLEAN
SPONGE or SOFT BRISTLE
BRUSH-'-DO NOT WET FAB­
RIC EXCESSrYEL
Y OR RUB
HARSHLY
WI1JI BRUSH. IM­
MEDIATELY
AFTER CLEAN­
ING WIPE
OFF ANY CLEANER
RESIDUE
WITH SLIGHTLY
DAMP ABSORBENT TOWEL
OR CLOTIi.
IMPORTANT­
IMMEDIATELY AFTER wip­
ING, FORCE-DR,Y FABRIC
WITH AIR
IiOSE, HEAT DRY­
ER OR HEAT LAMP. (Use cau­
tion with heat dryer or heat lamp
to, prevent damage to fabric,)
When trim materials with a sheen
or luster finish are dry, wipe fabric
lightly with a soft, dry clean cloth
to restore sheen
or luster.
, ,~

Downloaded from www.Manualslib.com manuals search engine Spot Cleaning Fabric Type
Trim
Materials with Solvent
Type Cleaner
Before attempting to remove
spots or stain s from fabric, deter­
mine as accurately
as possible the
nature and age of the spo t
or stain.
Some spo ts or st.ains can be re­
moved sa
tisfactorily with water or
mild soap
solution (refer to ac­
companying
'' It'emoval of Specific
Stains"). For best results, spots or
stains should
be removed as soon
as possible . S9rne types of stains
or soilage such
as lipstick, some
inks , certain typ
es of grease etc.,
are extrem ely difficult and, in some
cases , impossible to completely re­
move. When cleaning this type .of
stain or soilage, care must be taken
not to enlarge the soiled area.
It is
sometimes more desirable to have
a small stain than an enlarged stain
a s a result of careless cleaning.
~
G.M. Spot Lifter (Solvent Type)
is excellent .for spot cleaning stains
containing grease, oil or fats from
fabric type trim. Exces s stain
should be gently scraped off trim
material with a clean
DULL knife
or
scraper. USE VERY LITTLE
CLEANER, light pressure , and
clean cloths (preferably cheese
cloth). Cleaning action should
be
from outside of stain FEATHER­
ING toward s center of stain and
constantly changing to a clean sec­
tion of cloth. When stain
is cleaned
from fabric, immediately dry area
with an
air hose, heat dryer or heat
lamp to
helppreverit a cleaning
ring (use caution with heat dryer
or heat lamp
to prevent damage to
fabric materi
al). If a ring forms,
immediately repeat the cleaning
operation over
a slightly larger
area with special emphasis on
FEA THERlNG towards center of
area.
If ring still persists, mark
off adjacent trim sections and clean
4-3
entire affected trim panel sectIOn
with G.M. Multi-Purpose Powdered
Cleaner
as previously described
under "Cleaning General Soilage
or Water
Spots with Foam Type
Cleaner."
Removal of Specific Stains
Grease or 011 Stains-Includes
grease, oil, butter , margarine shoe
polish , coffee with cream,
ch~wing
gum, cosmetic creams, vegetable
oils, wax crayon; tar and asphalts.
Carefully scrape
off excess stain;
then us.e Spot. Lifter (Solvent
Type) as previously described.
Shoe polish, wax crayons, tar and
asphalts will stain
if allowed to
remain on trim; they should
be
removed as soon as· possible-use
caution
as cleaner will dissolve
them and may cause them to bleed.
Non-Greasy StaIns-Includes cat­
sup, coffee (black), egg, fruit, fruit

Downloaded from www.Manualslib.com manuals search engine juice, milk . soft drinks , wine , vomit
and blood . Carefull y scrape o
ff ex­
cess stain; ,then sponge stain with
cool
water. If stain remains use
Multi-Purpose Powdered Cleaner
(Foam Type) as previously de­
scribed.If odor persists after clean­
ing vomitus or urine, treat area with
a water-baking soda solution (1
teaspoon baking soda to 1 cup of
tepid
water ) -finally, if necessary ,
clean lightly with
Spot Lifter (Sol­
vent Type).
IMPORTANT: In the event white
or light-colored seat trim becomes
stained due
to contact with materials
that
do not have color-fast dyes
(certain types
of casual clothing ,
decorative paper, etc. )
the trim
must be cleaned
IMMEDIATELY
to avoid permanent discoloration.
Clean with Multi-Purpose Powdered
Cl eaner
(Foam Type) as previously
described.
Combination Stains -Includes
, candy, ice cream, mayonnaise, chili
sauce and unknown stains.
Care­
fully.scrape off'excess stain; then
clean first with cool water and
allow to dry,
If stain remains , clean
with , Spot Lifter (Solvent Type).
Cleaning Vinyl or Leather
Trim
'
Ordinary s oilage can be re­
moved from vinyl or leather with
warm water and a mild soap such
as saddle soap
or oil soap , or ap­
proved equivalent. Apply a small am
ount
of soap solution and allow
to so
ak for a few minutes to loosen
dirt; then,
rub briskly with a clean
damp cloth to remove dirt-and
so ap residues-this operation may
be repeated several times if nec­
essary. Some soilage such as tars,
asphalts, shoe polish, etc, will stain
if allowed to
remain on trim-they
should be wiped off as quickly , as
possible and the area cleaned with
a clean
cloth dampened with G.M.
Spot Lifter (Solvent Type).
Belt Restraint Care
• Clean only with mild soap solu­
tion and lukewarm water.
• ,Do not bleach or dye belts since
this
may severely weaken belts.

Downloaded from www.Manualslib.com manuals search engine APPEARANCE CARE AND MAINTENANCE MATERIALS
Available from your Chevrolet Dealer
Part Number Size
Description Usage
1050001 16 oz. Washer Solvent and Gas Prevents windshield solvent and
Line
De-Icer gas lines from freezing
, 1050017 32 oz. Power
Steering Fluid Power Steering Pump
1050019 16 oz. Spray-A-Squeak
Stopsmetal-to-metal squeaks .and
metal-ta-rubber squeaks
1050027 32 oz. Permanent Type Coolant Year-around coolant and anti-freeze
and . Anti-Freeze for your radiator
1050028 1 gal. Permanent Type Coolant . Same as above
and Anti-Freeze
1050172 16 oz. Tar and Road Oil Remover Removes old wax, polish , tar and road oil
1050173 16 oz. Chrome Cleaner and Polish Removes rust and corrosion from
chrome
or stainless steel
1050174 16 oz
.
White Sidewall Tire Cleaner Cleans whitewall and blackwall tires
1050223 16 oz. Finish Guard Cleaner One-step cleaner and wax
1050422 12 oz. Heat Valve Lubricant
Frees up sticky heat risers ;
genera l-purpose penetrating oil
1050427 23 oz. Glass Cleaner Cleans glass and vinyl
4-7

Downloaded from www.Manualslib.com manuals search engine Gas Cap-The fuel tank filler cap
has a
"Screw-on ratcheting type"
feature for proper gas tank sealing.
To remove:
• Rotate ~ap counterclockwise to
clear
the inside of the filler neck.
This will allow any residual
pres­
sure t!J escape.
• To iQstall, reverse this procedure
and . tighten cap securely until a
"ratcheting", . clicking sound is
heard indicating proper cap to
filler neck sealing.
NOTE: If this cap requires a re­
placement , only a cap with these
same features should
be used. Fail­
ure to use the correct cap can result
in a serious malfunction of the
sys­
tem. Correct replacement caps may
be obtained from your authorized
Chevrolet dealer.
ENGINE ITEMS
Engine Oil and Filter
Recommendations
• Use only SE engine oil.
• Change oil each 6 months or
7,500 miles, whichever occurs
first ,
except under the following
conditions:
•
-driving in dusty conditions
-trailer pulling '
-extensive idling
-short-trip operation at freez-
ing
ternperatures( engine not
thoroughly warmed-up).
'Under these conditions, change oil
each 3 month s
or 3,000 miles,
whichever occurs first.
• Operation in dust stOmlS may
require an immediate oil change.
• Replace the oil filter at the first
oil change, and every second oil
change thereafter. AC oil filters
5-2
provide excellent engine pro­
tection.
See your Chevrolet dealer for ad­
vice on the frequency of' oil and
filter changes under unusual driving
conditions.
The above recommendations
ap­
ply to the first change as well as
subsequent oil changes. The oil
change interval for your Chevrolet
engine
is based on the use of SE
oils and quality oil filters. Oil
change intervals longer than those
listed
above will seriously reduce
engine life and may affect
Chevro­
let obligation undetthe provisions
of the New Vehicle Warranty.
NOTE: Non-detergent and other
low quality oils are
sgecifically not
recommended .
Only the use of SE
engine oils and proper oil and filter
change intervals assure you of
con­
tinued proper lubrication of your
Chevrolet engine.

Downloaded from www.Manualslib.com manuals search engine --;
protection at-20op (-2S0C) or
below to ensure pro;tection against
corrosion and loss
of coolant
from boiling even though freezing '
temperatures are not expected.
• Add ethylene glycol base coolant
that meets
GM Specification
IS99-M when coolant additions
are required because of coolant
loss
Or to provide additional pro"
tection against freezing at tem_
peratures lower than _20oP,
(-2S0C),' and in Canada to
_35°P ( -3JOC).
NOTE: AlcOhol Or methanol base
coolants or plain water are not
recommended for your vehicle at
any time.
Radiator Pressure Cap
The radiator cap, a 15 lb. pres­
sure type, must be installed tightly,
otherwise coolant may be lost and
damage
, to engine may result from
overheating. Radiator pressure caps
should
be chef'ked periodically for
' proper operation.
If replacement is
required specify·AC.
Thermostat
The cooling system is protected
and controlled by a thermostat that
maintains a satisfactory
" engine
operating temperature . This
ther­
mostat is installed in the engine
coolant outlet
arid is designed for
continuous use through both winter
and
s ·ummer. When replacement is
necessary, Delco parts are recom­
mended.
5-9
CHASSIS ITEMS
Rear Axle Lubricant
Standard -
Every 6 months or
7,500 miles , whichever occurs first,
check lubricant level and add
lubri­
cant, if necessary, to fill to level of
filler plug hole.
Use SAE SOW or
SAE SOW-90 GL-5 Gear Lubricant.
cant.
(Por vehicles operated in
Canada, use
SAE SOW Gear Lubri­
cant.)
Posilraction -Drain and refill
after
the first 15,000 miles then
maintain same
as standard axle but
use only the special positraclion lu-·
bricant available from yo ur Chev­
roletDealer , part number 1051022.
Rear Universal Joint Fitting
-Except Wagons
Every 6 months or 7,500 miles­
lubricate universal joint with water
resistant
EP Chassis Lubricant
Part number 1050679 which meets
GM Specification 6040M.

Downloaded from www.Manualslib.com manuals search engine SPECIFICATIONS
VEHICLE IDENTIFICATION NUMBER Car.....;.Stamped on vehicle identification number plate ottached to left top of instrument panel. Body-Stamped on plate attached to upper right corner of cowl panel. Engine-Stamped on boss on block. 8~Cylinder-On right front side of block.
DIMENSIONS Overall Length Coupes and Sedans .....•..•. ........... 222.9" 228.6" 79.5" 121.5" 125.0"
Station Wagons, ........................ . Width ................. , ............... . Wheelbase, All IExc. Station Wagon) ......... . Station Wagon '0 .' ••••• '.' •••••••••••••••• Overall Height Coupe .............. ; •• ' .•.•.• ' ••••..•.• 53.7/1 54.5" 57.4" 58.1 "
Sedan ....................•.•. ,,' ...•.. 3-SeatStation Wagon ................. v •• 2-Seat Station Wagon ................... .
GASOLINE TANK (Approx.)
Coupes and Sedans ..... . Station Wagon ........ .
CRANKCASE (REFILL) (Approx.)
U.S. Measure
26 gal. 22 gal.
OIL CHANGE ONLY
U. S .. Imperial Measure' Measure
350 V-B... .. . . . .. . . .. 4 qt. 3% qt. 400, and 454 V-B .. . . .. 4 qt. 3 V. qt.
Imperial Measure
21.75 gal. IB.25 gal.
OIL CHANGE AND fiLTER CHANGE
U. S. Imperial Measure Measure
5 qt.· 4% qt.
5 qt. 4 V. qt.
6-1
COOLING SYSTEM 350 V-8 400 V·8 454 V·8
U.S. Measure 18 qt. 18 qt. 23.0 qt." Imperial Measure 15 qt. 15 qt. 19.25 qt."
Thermostat ALL ..........•...•••..••• 1950
Radiator Pressure Cap ••....••.•••.••••. 15 lb. ·With Air Conditioning-add 2 q·ts. U.S. Measure
SYSTEMS Refrigerant---:-R-12 ..........•.......... 3 lb., 12 oz. Compressor Oil (525 Vis.) All Systems ............... '. . . . . .. 11 oz.
TRANSMISSIONS IMPERIAL U.S. MEASURE MEASURE Turbo Hydramatic 350... 10.0 qt~ 825 qts. 400..... 11.0 qls. 9.25 qls.
BATTERY RATING Reserve Enaine Volts Watts· Capacity·· 350·V8 and 12 3200 100 min. 400·V8 454-V8 and 12 4000 125 min. H.D; . Cranking power at 0 F • *-Minutes before battery drops to 1O~ volts with a continuous 25 amp. drain.
TIRE INFORMATION Wheel Nut Torque .... _ ..... _ ............ 100ft.lbs. Complete tire information will be found on pages 5-14 through 5-20.
TURN SIGNAL FLASHER, Type ••••••••••••••••••\
•••••••••••••• Capacity Impala and Caprice ..•••.•.•••••..••.... 3-lamp (LL) Bel Air ..........••.....•.•••••.••.... 2-lamp (LL) Hazard Warning Flasher, All .....•.•...... 6-lamp