1967 CHEVROLET CAMARO head light

ELECTRICAL-BODY AND CHASSIS 12-40

Fig.
54 - Seat Separator Instrument Console

consists of a single red light which will indicate an over-

heated engine condition.

Engine Sender Unit Replacement

1.
Drain engine cooling system to a level below unit.
2.
Remove sender unit (located in cylinder head near

an exhaust port on L-6 engines and in the inlet mani-

fold near water pump housing on V-8 engines).

3.
Replace unit, refill cooling system and check opera-

tion of unit.

DIRECTIONAL SIGNAL

Directional signal assemblies provide as standard pro-

duction equipment a lane changing feature and hazard

warning system on all model applications. Two different

design switches are used as shown in Figure 55. Major

difference between the two units is that one type has can-

celling and detent springs which are serviceable, other-

wise both units are not repairable and must be replaced

as an assembly in service.

Due to the integral design relationship of the signal

switch and the energy absorbing steering column, refer-

ence should be made to Steering, Section 9 of this manual
whenever any service operations are performed on the

steering column. The directional signal switch replace-

ment procedures covered in this section are intended to

supplement the detail service operations outlined in Sec-

tion 9.

Special note should be taken of the fact that different

signal flasher units are used in Chevrolet models depend-

ent on the number of lamps to be operated. The hazard

warning unit, even though an integral component of the

directional switch assembly, requires the installation of

an additional flasher unit in the fuse panel capable of op-

CHEVROtET CHASSIS SERVICE MANUAL

SPECIFICATIONS 25

BODY AND CHASSIS ELECTRICAL

SECTION
12

LAMP USAGE
CANDLE

POWER
BULB

NUMBER

Headlamp Unit

Chevrolet, Chevelle & Corvette

Outer - High Beam

Outer - Low Beam

Inner -• High Beam only

Chevy H

High Beam . .

Low Beam

Parking Lamp and Directional Signal

All Exc. Camaro

Camaro

Tail, Stop and Directional Signal (Exc. Bel Air)

Backing Lamp ••...,

Instrument Illumination Lamps

Chevrolet & Camaro ,

Chevelle and Chevy n

Corvette

Temperature Indicator

Chevrolet & Camaro

Chevelle and Chevy II .............

Oil Pressure Indicator

Chevrolet & Camaro .............

Chevelle and Chevy II

Generator Indicator

Chevrolet & Camaro .

Chevelle and Chevy n ,

Hi-Beam Indicator

Chevrolet & Camaro <

Chevelle and Chevy II

Corvette , . • . ,

Directional Indicator

Chevrolet & Camaro

Chevelle & Chevy II . .

Corvette . .

Cigarette Lighter Lamp

Corvette .

Ignition Lock Lamp

Chevrolet . . .

Corvette . . .

Heater or A/C Control Panel

Chevrolet, Chevelle, Chevy n & Camaro . . .

Corvette . . .

Glove Box Lamps

Chevrolet, Chevelle, Chevy n & Camaro . . .

Corvette . . . . .

Dome and Courtesy Lamps

Cartridge Type (AU)

Bayonet Type (Exc. Corvette) . . .

Corvette ,

Convertible . .
37 1/2 Watts

55 Watts

37 1/2 Watts

55 Watts

45 Watts

4-32

4-32

4-32

Special Fiber

1

2

3

2

3

12

6

6

6
Optic
4002

4002

4001

6012

1157

1034-A

1157

1156

194

1895
.

1816

194

1895

194

1895

194

1895

194

1895

1445

194

1895

1816

1445

Wiring

1445

1895

1893

1895

1893

211

89,
212

90

631

CHEVROLET CHASSIS SERVICE MANUAL

SPECIFICATIONS 26

LAMP USAGE (Cont'd.)
CANDLE

POWER

1

6

4

2

3

2

2

3

2

3

15

15
BULB

NUMBER

1445

212

67

1893

1816

194

1895

1816

257

1816

1003

93
Seat Separator-Compartment Lamp . . . . .

-Courtesy Lamp •

License Plate Lamp . .

Radio Dial Lamp

Chevrolet, Chevelle, Chevy n & Camaro

Corvette

Brake Alarm Lamp

. Chevrolet & Camaro . . .... . .

Chevelle & Chevy n . . . . .'. ;v . . . .

Corvette . . . . . . . .

Headlamp Mqtor Warning Lamp (Flashing) .

Clock Lamp (Corvette) .''> ....

Luggage Compartment Lamp. . ... . . . •

Underhood

FUSES AND CIRCUIT BREAKER

A circuit breaker in the light control switch protects

the headlamp circuit, thus eliminating one fuse. A

separate circuit breaker protects the power window,

seat and top circuits. On Corvettes the headlamp motor
circuit is also protected by a separate circuit breaker.

Where current load is too heavy, the circuit breaker

rapidly opens and closes, protecting the circuit until

the cause is found and eliminated.

louses located in the Fuse Panel under the instrument panel are:

Wiper (Chevrolet, Chevelle, and "F" Car) 3AF/AGC 20 Amp.

Back-up Lamp and Gauges. . . 3AG/AGC 10 Amp.

Heater - Air Conditioning 3AG/AGC 25 Amp.

Radio 3AG/AGC 10 Amp.

Radio - Wiper (Chevy II and Corvette) 3AG/AGC 20 Amp.

Instrument Lamps 3AG/AGC . 4 Amp.

Stop and Tail Lamps ........ t 3AG/AGC 20 Amp.

Clock, Lighter, Courtesy Lamps, and Hazard Warning 3AG/AGC 20 Amp.

In-Line Fuses:

Air Conditioning High Blower Speed Fuse located in wire running

from horn relay to A/C Relay

Comforton and Four Season SAE 30 Amp.

Universal & All Weather (Chevy H) SAE 20 Amp.

Fusible Links: ,

Pigtail lead at battery positive cable (except Corvette) 14 gage brown wire

Molded splice at Solenoid "Bat" terminal (Corvette only) 14 gage brown wire

Molded Splice Located at the horn relay 16 gage black wire

Molded splice in Voltage Regulator #3 terminal wire 20 gage orange wire

Molded splice in Ammeter circuit (Both sides of meter) 20 gage orange wire

CHEVROLET CHASSIS SERVICE MANUAL