1960 CHEVROLET CORVAIR parking brake

BRAKES
The brake pedal is of the pendant type, providing
ample footroom and extra leverage for easy safe stops.
PARKING BRAKE
Pull the parking brake lever to engage the brake. The
lever will remain in the applied position until released
by means of the "trigger" on the handle. To release,
pull the
handle toward the steering wheel, depress the
unlocking trigger and allow the handle to return to the
releas.ed position. Always engage the parking brake
when parked.
PARKING BRAKE APPLYING HANDLE
9
WINDSHIELD WIPERS AND WASHERS
The parallel acting wipers are operated by means
of the wiper control knob on the dash .
Pressing
once on the accessory windshield washer
button will cause the washer to squirt a measured
amount of water or other cleaning agent onto the glass,
and will at the same time turn on the wiper motor. You
will have to turn off the wiper manually at the switch .
Keep the
washer jar filled to a level 2 inches below
the top of the jar with a suitable solvent. G. M. Part No.
988299, Windshield Washer Anti-Freeze and Solvent,
is recommended for use in the Corvair windshield washer
jar. NEVER USE ANY SOLVENT OR ANTI-FREEZE SOLU­
TION WHICH CONTAINS METHANOL Fill the washer
jar only % full to allow for expansion if the solution
freezes. In freezing weather, pre-warm the windshield
using the heater defrosters before using the washers.

13. TRANSMISSION
3-Speed (Transmission and Rear Axle)
First 1'000 miles-Drain and refill with lubricant spe­
cified
below.
Every 1000 miles-Check at operating temperature
and keep lubricant at level of the filler plug.
Add SAE-80 multipurpose gear lubricant (G. M.
Part No. 3772661) as required.
Powerglide (Transmission only)
Every 1000 miles-Check fluid level on dipstick with
engine idling, selector lever in NEUTRAL posi­
tion,
parking brake set and transmission at
operating temperature. Add Automatic Trans­
mission
Fluid Type "A" with an AQ-ATF-A num­
ber to full mark on dipstick . Check with engine
idling. DO NOT OVERFILL. Correct oil level must
be established by dipstick measurement.
NOTE: From the "Add Oil" mark to the "Full"
mark
on the dipstick indicates a difference of
only 1 pint of fluid.
22
14. REAR AXLE
First 1000 miles-Drain rear axle and refill with
lubricant specified
below.
Every 1000 miles-Check rear axle at operating tem­
perature and keep lubricant at level of filler
plug.
Every 10,000 miles or seasonally-Drain rear axle
and refill with lubricant specified below.
With Powerglide Transmission
Add G. M. No. 3772661 (SAE-80 Multipurpose Gear
Lubricant) or equivalent to rear axle as required.
With 3-Speed Transmission
Add G. M. Part No. 3772661 (SAE-80 Multipurpose
Gear Lubricant) or equivalent to rear axle as
required.
NOTE: if rear axle requires additional lubricant,
be sure that 3-speed transmission is also checked.
Low lubricant in the axle indicates that the trans­
mission
may also be low .
15. BATTERY
Every 1000 miles-Check fluid level. Keep filled with
distilled
water to level of the split ring in the
vent tube. Oil battery terminal washer with engine
oil. Clean top of battery regularly with diluted

ammonia or soda solution and flush with clear
water. Check state of charge regularly, espe­
cially in freezing weather, for an undercharged
battery may freeze and break.
16. FUEL FILTER
Every 15,000 miles-Replace filters, located in each
carburetor inlet. If flooding occurs, replace more
often.
17. BRAKE MASTER CYLINDER
Check frequently and maintain fluid level at mark
inside reservoir below filler opening, using G. M.
Hydraulic Brake Fluid, Super No. 11. If addition
of fluid is required more often than ·every 1000
miles the entire system should be checked for
leaks.
18. PARKING BRAKE & CLUTCH PULLEYS
AND CABLES
Every 10,000 miles-Lubric.ate pulleys under dash.
Remove the
tunnel cover under vehicle and lubri­
cate pulleys and cable bearing points with lub­
riplate. lubricate gearshift lever ball and socket
and shift rod universal joint at transmission con­
nection with lubriplate.
BODY LUBRICATION POINTS
Most body lube points do not need frequent, heavy
23
lubrication as does the chassis. However, periodic checks
of certain points on the Corvair body, and lubrication
when needed will eliminate annoying squeaks and
noises . Be careful not to over-lubricate. Wipe off all
surplus lubricant.
The following items should be lubricated periodically:
1. DQQr Hinges-Wipe off dirt and apply Lubriplate.
2 . Door Lock
Striker-Wipe off dirt and apply stick type lu­bricant.
3. Door Bottom Drain Hole Sealing Strip-Apply silicone rub-
ber lubricant.
4. Door Jamb Switch-Apply Lubriplate.
5 .
Rear Door Weatherstrip-Apply silicone rubber, lubricant.
6 . Front
and Rear Compartment Lid Lock-Apply Lubriplate.
7. Front Compartment Lid Torque Rods-Apply dripless oil to bearing points.
8. Gas Tank Filler Door Hinge-Apply dripless oil. 9. Glove Box Door Hinge-Apply dripless oil. 10. Rear Folding Seat Back Support Link Assembly & Filler Panel Hinge-Apply dripless Qil to bearing points.
The following items moy be lubricated whenever
access to the item is availoble:
11. Door Outsi.de Handle Lock Cylinder Shaft-Apply Lubri-
plate. 12. Door Window Regulator and Cams-Apply Lubriplate .
13. Door Lock Parts-Apply Lubriplate . 14. Door Locking Mechanism-Apply Lubriplate .
15. Front and Rear Compartment Hinges-Apply Lubriplate.

INDEX
Page
Air Cleaner .............. , . ............ .. 21
Air Vents ............................... .
Ash Tray
............ .................... .
Battery ................................. .
Body
lubrication ......... . ............... .
Brake
Master Cylinder ..................... .
Brake-Parking .......................... .
Brakes
........ .. ............. .. ........ .
Breaking-in
Period . ........ .. ........... . .
11
11
22
23
?3
9
9
2
Bright Metal Parts . .............. .......... 14
Bulb Specifications .................... .... , 29
Chassis lubrication ................... ..... 19
Cigarette Lighter .......................... 11
Circuit Breaker ......... . ................. 29
Cleaning Hints . . . . . . . . . . . . . . . . . . . . . . . . . . .. 14
Clutch Cross Shaft lever ................... , 20
Clutch Pulleys & Cables .. . . . . . . . . . . . . . . . . . .. 23
Cooling System ........................... 17
Crankcase lubrication ................ 16 and 20
Dimensions .............................. . 28
Dimmer Switch ... ........................ . 8
Distributor .............................. . 21
30
Page
Driving for Economy . . . . . . . . . . . . . . . . . . . . . . .. 3
Engine Oil Cooler ............. .......... . . 21
Engine
Compartment ....................... 13
Engine lubrication .................... 16 and 20
Engine Specifications . . . . . . . . . . . . . . . . . . . . . .. 28
Exterior Appearance ....................... 14
Washing ............................. 14
Polishing ........ ..................... 14
Bright Metal Parts . . . . . . . . . . . . . . . . . . . . .. 14
White Sidewall Tires .................... 15
Folding Rear Seat . . . . . . . . . . . . . . . . . . . . . . . .. 12
Front Seat Adjuster ........................ 12
Front Suspension ......... ........ ......... 20
Front Wheel Bearings ............ .......... 21
Fuel Filter ............. .. ................ 23
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. 6
Fuses ..
................. ................ 29
Gas Cap ........ ........................ 13
Generator ............................... 20
Gen-Fan Indicator ......................... 6-7
Glove Box ......... .... ............... . ' .' 11
Heater .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. 10
Ignition Switch . . . . . . . . . . . . . . . . . . . . . . . . . . .. 2
Interior Appearance ............... ...... .'. 15
Jacking the Car . . . . . . . . . . . . . . . . . . . . . . . . . .. 1 8
Keys
and Locks .... . . . . . . . . . . . . . . . . . . . . . .. 11

Page
Light Control Knob ........................ 8
locks ................................... 11
lubrication Diagram .. ....... . .......... .. . 26
lubrication & Maintenance Guide ............ 24-25
luggage Compartment . . . . . . . . . . . . . . . . . . . . .. 13
Maintenance and Lubrication ....... ......... 16
Octane Requirements . . . . . . . . . . . . . . . . . . . . . .. 16
Oil Filter ................................ 20
Owner Protection Policy ............ '. . . . . . . .. 30
Parking Brake
Operation ............................ 9
Service .
............................. 23
Polishing Your Corvair ...................... 14
Pushing to Start
Three-Speed ................. ......... 4
Powerglide . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Radio
............. ..................... 10
Rear Axle .................. ............. 22
Rear Seat-Folding ....................... .
Rocking
Car-Powerglide . .................. .
Seats
12
6
Front Seat Adjustment . . . . . . . . . . . . . . . . . .. 12
Rea r Seat-Folding ..................... 1 2
Service Accessories
....................... .
Serv ice Brakes ........................... .
27
9
31
Page
Serial and Unit Numbers . . , ............... " 28
Spare Tire ..... . . . . . . . . . . . . . . . . . . . . . . . . .. 19
Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . .. 28
Speedometer ... .. ........ .......... ...... 6
Starting the Engine . .. . . . . . . . . . . . . . . . . . . . .. 3
Steering Linkage ............. ;............ 20
Steering Gear . . . . . . . . . . . . . . . . . . . . . . . . . . .. 20
Switching Tires ........................... 19
Temp-Press-Indicator ........ ............... 6-7
Tire Care ............................... 18
Tire Information . . . . . . . . . . . . . . . . . . . . . . . . . .. 28
Towing-Powerglide ....................... 6
Transmission
Three-Speed
Operation ................... ...... 4
Service ........................... 22
Powerglide
Operation .... . . . . . . . . . . . . . . . . . . . .. 5-6
Service .............. ............. 22
Turn Signal .............................. 8
Universal Joints ........................... 21
Warm-up. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Washing your Corvair . . . . . . . . . . . . . . . . . . . . .. 14
White Sidewall Tires .... . . . . . . . . . . . . . . . . . .. 15
Windshield Wipers and Washers . . . . . . . . . . . . .. 9