1960 CHEVROLET CORVAIR air filter

8. DISTRIBUTOR
Every 1000 miles-Fill hinged cap oiler with light
engine. oil.
Every 5000 miles-Apply small drop of light engine
oil to breaker lever pivot.
9. AIR CLEANER
Every 2000 miles-Clean .and re-oil filter element.
Under severe dust conditions, it may be neces­
sary to clean and re-oil the element more often.
To clean: remove element from screen, wash in
kerosene
or mineral spirits to remove oil and dirt.
Squeeze dry, dip in engine oil and squeeze to
remove excess oiL (Never shake or wring-always
squeeze.)
Replace screen assembly and reinstall in Air
Cleaner.
NOTE: A clean air cleaner element is essential to
satisfactory gas mileage. -
21
10. ENGINE OIL COOLER
Every 5000 miles-Remove cover and brush or blow
out accumulated dirt.
NOTE: Material usually found in the oil cooler
consists primarily
of twigs, straw, chaff, and
leaves. Check the cooler more often if you
drive
in areas where such material is more
likely to enter engine compartment.
GENERATOR
11. FRONT WHEEL BEARING
Every 10,000 miles-Clean and repack bearings with
a high melting point lubricant. Replace grease
seals at the same time.
12. UNIVERSAL JOINTS
Every 25,000 miles-(More often under dusty or
other adverse driving conditions} clean and
repack with a high melting point lubricant.

ammonia or soda solution and flush with clear
water. Check state of charge regularly, espe­
cially in freezing weather, for an undercharged
battery may freeze and break.
16. FUEL FILTER
Every 15,000 miles-Replace filters, located in each
carburetor inlet. If flooding occurs, replace more
often.
17. BRAKE MASTER CYLINDER
Check frequently and maintain fluid level at mark
inside reservoir below filler opening, using G. M.
Hydraulic Brake Fluid, Super No. 11. If addition
of fluid is required more often than ·every 1000
miles the entire system should be checked for
leaks.
18. PARKING BRAKE & CLUTCH PULLEYS
AND CABLES
Every 10,000 miles-Lubric.ate pulleys under dash.
Remove the
tunnel cover under vehicle and lubri­
cate pulleys and cable bearing points with lub­
riplate. lubricate gearshift lever ball and socket
and shift rod universal joint at transmission con­
nection with lubriplate.
BODY LUBRICATION POINTS
Most body lube points do not need frequent, heavy
23
lubrication as does the chassis. However, periodic checks
of certain points on the Corvair body, and lubrication
when needed will eliminate annoying squeaks and
noises . Be careful not to over-lubricate. Wipe off all
surplus lubricant.
The following items should be lubricated periodically:
1. DQQr Hinges-Wipe off dirt and apply Lubriplate.
2 . Door Lock
Striker-Wipe off dirt and apply stick type lu­bricant.
3. Door Bottom Drain Hole Sealing Strip-Apply silicone rub-
ber lubricant.
4. Door Jamb Switch-Apply Lubriplate.
5 .
Rear Door Weatherstrip-Apply silicone rubber, lubricant.
6 . Front
and Rear Compartment Lid Lock-Apply Lubriplate.
7. Front Compartment Lid Torque Rods-Apply dripless oil to bearing points.
8. Gas Tank Filler Door Hinge-Apply dripless oil. 9. Glove Box Door Hinge-Apply dripless oil. 10. Rear Folding Seat Back Support Link Assembly & Filler Panel Hinge-Apply dripless Qil to bearing points.
The following items moy be lubricated whenever
access to the item is availoble:
11. Door Outsi.de Handle Lock Cylinder Shaft-Apply Lubri-
plate. 12. Door Window Regulator and Cams-Apply Lubriplate .
13. Door Lock Parts-Apply Lubriplate . 14. Door Locking Mechanism-Apply Lubriplate .
15. Front and Rear Compartment Hinges-Apply Lubriplate.

SPECIFICATIONS
SERIAL AND UNIT NUMBERS
Serial Number . Stamped on plate attached to left center body pillar. Body Number .. Stamped on a plate attached to the left rear wheel well, within the engine compartment.
Engine Number. Stamped on the engine block behind and to
left of the fuel pump.
DIMENSIONS
Overall length ............................. 180.0 in.
Height
(loaded) .......... ................. 51.3 in.
Width
............... . . . . . . . . . . . . . . . . . . .. 66.4 in.
Wheelbase ...........•................... 108.0 in.
Turning
diameter ................. ............ 39 ft.
CAPACITIES
Gasoline Tank .........................•.... 11 gal.
Crankcase Refill ............................... 4 qt.
Add for Filter .......... , ... : ............... 1 pt.
Transmission
3-Speed .................................. 2 pt.
Powerglide
(Refill) ...... 4% to 8 pts . (depending on drain period) Differential .................. ............ 3 pt.
Air Cleaner ..................... . Polyurethane Element
Cooling System ...
.................. Air Cooled Engine
28
TIRE INFORMATION
Type .................................... Tubeless
Size .............................. 6.50 x 13-4 ply
Inflation COLD HOT
Front ............................ 15 18
Rear ......................•..... 26 30
Spare Tire-Inflate to 26 Ibs. Deflate to 15 Ibs. when using as front wheel.
ENGINE SPECIFICATIONS
Horsepower .•..............................
Compression Ratio ........................... 8.0:1
Displacement ....... ....................• 140 cu. in.
Bore
................... ' ............ ' ....... 3.375
Stroke ...................................... 2.60
Firing Order .............. .............. 1-4-5-2-3-6
Spark Plugs .............•. AC-4.4FF (Gap: .033-.038")
Idle Speed
3-Speed .................. 450-500 RPM (in Neutral)
Powerglide
................ .. 475-500 RPM (In Drive)
Ignition Timing .......................... 40 B.T.D.C.
Axle Ratio
(Std.) ......... ................... 3.55:1
(Opl.) ............................ 3.89:1

INDEX
Page
Air Cleaner .............. , . ............ .. 21
Air Vents ............................... .
Ash Tray
............ .................... .
Battery ................................. .
Body
lubrication ......... . ............... .
Brake
Master Cylinder ..................... .
Brake-Parking .......................... .
Brakes
........ .. ............. .. ........ .
Breaking-in
Period . ........ .. ........... . .
11
11
22
23
?3
9
9
2
Bright Metal Parts . .............. .......... 14
Bulb Specifications .................... .... , 29
Chassis lubrication ................... ..... 19
Cigarette Lighter .......................... 11
Circuit Breaker ......... . ................. 29
Cleaning Hints . . . . . . . . . . . . . . . . . . . . . . . . . . .. 14
Clutch Cross Shaft lever ................... , 20
Clutch Pulleys & Cables .. . . . . . . . . . . . . . . . . . .. 23
Cooling System ........................... 17
Crankcase lubrication ................ 16 and 20
Dimensions .............................. . 28
Dimmer Switch ... ........................ . 8
Distributor .............................. . 21
30
Page
Driving for Economy . . . . . . . . . . . . . . . . . . . . . . .. 3
Engine Oil Cooler ............. .......... . . 21
Engine
Compartment ....................... 13
Engine lubrication .................... 16 and 20
Engine Specifications . . . . . . . . . . . . . . . . . . . . . .. 28
Exterior Appearance ....................... 14
Washing ............................. 14
Polishing ........ ..................... 14
Bright Metal Parts . . . . . . . . . . . . . . . . . . . . .. 14
White Sidewall Tires .................... 15
Folding Rear Seat . . . . . . . . . . . . . . . . . . . . . . . .. 12
Front Seat Adjuster ........................ 12
Front Suspension ......... ........ ......... 20
Front Wheel Bearings ............ .......... 21
Fuel Filter ............. .. ................ 23
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. 6
Fuses ..
................. ................ 29
Gas Cap ........ ........................ 13
Generator ............................... 20
Gen-Fan Indicator ......................... 6-7
Glove Box ......... .... ............... . ' .' 11
Heater .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. 10
Ignition Switch . . . . . . . . . . . . . . . . . . . . . . . . . . .. 2
Interior Appearance ............... ...... .'. 15
Jacking the Car . . . . . . . . . . . . . . . . . . . . . . . . . .. 1 8
Keys
and Locks .... . . . . . . . . . . . . . . . . . . . . . .. 11

Page
Light Control Knob ........................ 8
locks ................................... 11
lubrication Diagram .. ....... . .......... .. . 26
lubrication & Maintenance Guide ............ 24-25
luggage Compartment . . . . . . . . . . . . . . . . . . . . .. 13
Maintenance and Lubrication ....... ......... 16
Octane Requirements . . . . . . . . . . . . . . . . . . . . . .. 16
Oil Filter ................................ 20
Owner Protection Policy ............ '. . . . . . . .. 30
Parking Brake
Operation ............................ 9
Service .
............................. 23
Polishing Your Corvair ...................... 14
Pushing to Start
Three-Speed ................. ......... 4
Powerglide . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Radio
............. ..................... 10
Rear Axle .................. ............. 22
Rear Seat-Folding ....................... .
Rocking
Car-Powerglide . .................. .
Seats
12
6
Front Seat Adjustment . . . . . . . . . . . . . . . . . .. 12
Rea r Seat-Folding ..................... 1 2
Service Accessories
....................... .
Serv ice Brakes ........................... .
27
9
31
Page
Serial and Unit Numbers . . , ............... " 28
Spare Tire ..... . . . . . . . . . . . . . . . . . . . . . . . . .. 19
Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . .. 28
Speedometer ... .. ........ .......... ...... 6
Starting the Engine . .. . . . . . . . . . . . . . . . . . . . .. 3
Steering Linkage ............. ;............ 20
Steering Gear . . . . . . . . . . . . . . . . . . . . . . . . . . .. 20
Switching Tires ........................... 19
Temp-Press-Indicator ........ ............... 6-7
Tire Care ............................... 18
Tire Information . . . . . . . . . . . . . . . . . . . . . . . . . .. 28
Towing-Powerglide ....................... 6
Transmission
Three-Speed
Operation ................... ...... 4
Service ........................... 22
Powerglide
Operation .... . . . . . . . . . . . . . . . . . . . .. 5-6
Service .............. ............. 22
Turn Signal .............................. 8
Universal Joints ........................... 21
Warm-up. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Washing your Corvair . . . . . . . . . . . . . . . . . . . . .. 14
White Sidewall Tires .... . . . . . . . . . . . . . . . . . .. 15
Windshield Wipers and Washers . . . . . . . . . . . . .. 9