2023 TOYOTA RAIZE maintenance

2936-2. Maintenance
RAIZE_OM_General_BZ358E
Maintenance and care
6
Do-it-yourself maintenance
⚫What about do-it-yourself maintenance?
Many of the maintenance items are easy to do yourself if you have a little mechanical
ability and a few basic automotive tools. Simple instructions for how to perform them
are presented in this section.
Note, however, that some maintenance task s require special tools and skills. These
are best performed by qualified technician s. Even if you are an experienced do-it-
yourself mechanic, we recommend that repairs and maintenance be conducted by
your Toyota dealer who will keep a record of maintenance on your vehicle. This
record could be helpful should you ever require Warranty Service.
⬛Does your vehicle need repairs?
Be on the alert for changes in performance and sounds, and visual tip-offs that
indicate service is needed. Some important clues are:
⚫Engine misses, stumbling or pinging
⚫Appreciable loss of power
⚫Strange engine noises
⚫A fluid leak under the vehicle (However , water dripping from the air condi-
tioning system after use is normal.)
⚫Change in exhaust sound (This may indica te a dangerous carbon monoxide leak.
Drive with the windows open and have th e exhaust system checked immediately.)
⚫Flat-looking tires, excessive tire squeal when cornering, uneven tire wear
⚫Vehicle pulls to one side when driven straight on a level road
⚫Strange noises related to suspension movement
⚫Loss of brake effectiveness, spongy feeling brake pedal or clutch pedal (vehi-
cles with a manual transmission), pe dal almost touches the floor, vehicle
pulls to one side when braking
⚫Engine coolant temperature continually higher than normal
If you notice any of these clues, take yo ur vehicle to your Toyota dealer as soon
as possible. Your vehicle may need adjustment or repair.
WARNING
⬛If your vehicle is not properly maintained
Improper maintenance could result in serious damage to the vehicle and pos-
sible death or serious injury.
⬛Handling of the battery
Battery posts, terminals and related accessories contain lead and lead com-
pounds which are known to cause brain damage. Wash your hands after han-
dling. ( ➞P. 321)
RAIZE_OM_General_BZ358E.book 293 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2946-2. Maintenance
RAIZE_OM_General_BZ358E
Scheduled maintenance
Perform maintenance by the schedule as follows:Maintenance schedule requirements
Your vehicle needs to be serviced in according to the normal maintenance
schedule. (See “Maintenance schedule”.)
If you mainly operate your vehicle under one or more of the special oper-
ating conditions below, some of th e maintenance schedule items need to
be serviced more frequently in order to keep your vehicle in good condi-
tion. (See “Additional maintenance schedule”.)
⬛Road Condition
⚫Operating on rough or muddy roads, or roads with melted snow
⚫Operating on dusty roads (Roads in areas where their pavement rate is
low, or a cloud of dust often arises and the air is dry.)
⬛Driving Condition
⚫Heavily loaded vehicle (Example: Using a car top carrier, etc.)
⚫Repeated short trips less than 8 km (5 miles) and outside temperatures
remain below freezing (Engine temp erature will not reach to normal
temperature)
⚫Extensive idling and/or low speed dr iving for a long distance such as
police, taxi or door-to-door delivery use
⚫Continuous high speed driving (80% or more of maximum vehicle
speed) for over 2 hours
RAIZE_OM_General_BZ358E.book 294 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2956-2. Maintenance
RAIZE_OM_General_BZ358E
Maintenance and care
6
Maintenance schedule (except for Mexico)
Maintenance operations : I = Inspect, correct or replace as necessaryR = Replace, change or lubricate
SERVICE
INTERVAL:ODOMETER READING
MONTHS(Odometer reading or months,
whichever
comes first.) x1000
km 1 1020304050607080
x1000 miles 1 6 12 18 24 30 36 42 48
BASIC ENGINE COMPONENTS
1Valve clearance
(1KR-VET engine)I96
2Drive beltsIIII24
3Engine oil
(WA-VE engine)RRRRRRRR6
4Engine oil
(1KR-VET engine)Replace when the maintenance reminder
appears.*
1―
5Engine oil filter
(WA-VE engine)RRRRRRRR6
6Engine oil filter
(1KR-VET engine)Replace when the maintenance reminder
appears.*
1―
7Cooling and heater
system*
2II24
8Engine coolantFirst replace at 160000 km (100000 miles),
then replace every 80000 km (48000 miles)―
9Exhaust pipes and
mountingsIIII12
IGNITION SYSTEM
10Spark plugsReplace at every 100000 km (60000 miles)―
11BatteryIIIIIIIII12
RAIZE_OM_General_BZ358E.book 295 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2966-2. Maintenance
RAIZE_OM_General_BZ358E
FUEL AND EMISSION CONTROL SYSTEMS
12Fuel filter*3R96
13Air cleaner filterIRIRI: 24
R: 48
14
Fuel tank cap, fuel
lines, connections
and fuel vapor con-
trol valve*
2
II24
15Charcoal canisterII24
CHASSIS AND BODY
16Clutch pedal
(1KR-VET engine)IIIIIIII12
17Clutch pedal
(WA-VE engine)IIIIIIII12
18Brake pedal and
parking brakeIIIIIIII6
19
Brake linings and
drums (include park-
ing brake linings and
drums)
IIII12
20Brake pads and discsIIII6
21Brake fluidIIIRIIIRI: 6
R: 24
22Clutch fluid
(1KR-VET engine)IIIRIIIRI: 6
R: 24
23Brake pipes and
hosesIIII12
24
Steering wheel, link-
age and steering
gear box
IIII12
SERVICE
INTERVAL:ODOMETER READING
MONTHS
(Odometer reading or months,
whichever
comes first.) x1000
km 1 1020304050607080
x1000 miles 1 6 12 18 24 30 36 42 48
RAIZE_OM_General_BZ358E.book 296 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2976-2. Maintenance
RAIZE_OM_General_BZ358E
Maintenance and care
6
*1Replace both the engine oil and oil filter, even when the maintenance
reminder does not appear, after 6 mont hs have passed, since the last oil
change.
*2After 80000 km (48000 miles) or 48 months inspection, inspect every 20000
km (12000 miles) or 12 months.
*3Including the filter in fuel tank.
25Drive shaft bootsIIIIIIII6
26Front wheel align-
ment (toe-in)II48
27Suspension ball joint
and dust coverIIII12
28
Manual transmis-
sion oil (including
front differential)
IRI: 48
R: 96
29
Continuously varia-
ble transmission
fluid (including front
differential)
Inspect every 12 months, Replace every
100000 km (60000 miles)―
30Front and rear sus-
pensionIIII12
31Tires and inflation
pressureIIIIIIII6
32Lights, horns, wipers
and washersIIIIIIII6
33Air conditioning filterRRRR24
SERVICE
INTERVAL:ODOMETER READING
MONTHS
(Odometer reading or months,
whichever
comes first.) x1000
km 1 1020304050607080
x1000 miles 1 6 12 18 24 30 36 42 48
RAIZE_OM_General_BZ358E.book 297 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2986-2. Maintenance
RAIZE_OM_General_BZ358E
Additional maintenance schedule (except for Mexico)
Refer to the following table for normal maintenance schedule items
requiring more frequent service specific to the type of severe conditions.
(For outline, see “Maintenan ce schedule requirements”.)
A-1: Operating on rough or muddy roads, or roads with melted snow
Inspection*1 of brake linings and drums
(include parking brake linings and drums)Every 10000 km (6000 miles) or 6
months
Inspection*1 of brake pads and discsEvery 10000 km (6000 miles) or 3
months
Inspection*1 of brake pipes and hosesEvery 10000 km (6000 miles) or 6
months
Inspection*1 of steering wheel, linkage
and steering gear boxEvery 5000 km (3000 miles) or 3
months
Inspection*1 of suspension ball joint and
dust coverEvery 10000 km (6000 miles) or 6
months
Inspection*1 or replacement of continu-
ously variable transmission fluid (includ-
ing front differential)I: Every 5000 km (3000 miles) or 3 months
R: Every 50000 km (30000 miles)
Inspection*1 of front and rear suspensionEvery 10000 km (6000 miles) or 6
months
Tightening of bolts and nuts on chassis
and body*
2
Every 10000 km (6000 miles) or 6
months
A-2: Operating on dusty ro ads (Roads in areas where their pavement rate is
low, or a cloud of dust ofte n arises and the air is dry.)
Replacement of engine oil
(WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
Replacement of engine oil filter
(WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil filter
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
Inspection*1 or replacement of air cleaner
filter
I: Every 2500 km (1500 miles) or 3 months
R: Every 20000 km (12000 miles) or 48 months
RAIZE_OM_General_BZ358E.book 298 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2996-2. Maintenance
RAIZE_OM_General_BZ358E
Maintenance and care
6
Inspection*1 of brake linings and drums
(include parking brake linings and drums)Every 10000 km (6000 miles) or 6
months
Inspection*1 of brake pads and discsEvery 10000 km (6000 miles) or 3
months
Inspection*1 or replacement of continu-
ously variable transmission fluid (includ-
ing front differential)I: Every 5000 km (3000 miles) or 3 months
R: Every 50000 km (30000 miles)
Replacement of air conditioning filter Every 20000 km (12000 miles) or 24
months
B-1: Heavily loaded vehicle (Example: Using a car top carrier, etc.)
Replacement of engine oil
(WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
Replacement of engine oil filter
(WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil filter
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
Inspection*1 of brake linings and drums
(include parking brake linings and drums)Every 10000 km (6000 miles) or 6
months
Inspection*1 of brake pads and discsEvery 10000 km (6000 miles) or 3
months
Replacement of manual transmission oil
(including front differential)Every 40000 km (24000 miles) or 48
months
Inspection*1 or replacement of continu-
ously variable transmission fluid
(including front differential)I: Every 5000 km (3000 miles) or 3 months
R: Every 50000 km (30000 miles)
Inspection*1 of front and rear suspensionEvery 10000 km (6000 miles) or 6
months
Tightening of bolts and nuts on chassis
and body*
2
Every 10000 km (6000 miles) or 6
months
B-2: Repeated short trips less than 8 km (5 miles) and outside temperatures remain below freezing (Engine temperature will not reach to normal temperature)
Replacement of engine oil (WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
RAIZE_OM_General_BZ358E.book 299 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3006-2. Maintenance
RAIZE_OM_General_BZ358E
*1Perform correction or replacement as necessary.
*2For seat mounting bolts, front and rear suspension member retaining bolts.
*3Replace both engine oil and oil filter every 3 months, in which the vehicle is
mainly driven in dirt or dusty roads, when the maintenance reminder does not
appear.
Replacement of engine oil filter
(WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil filter
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
Inspection*1 or replacement of continu-
ously variable transmission fluid
(including front differential)I: Every 5000 km (3000 miles) or 3 months
R: Every 50000 km (30000 miles)
B-3: Extensive idling and/or low speed driving for a long distance such as police, taxi or door-to-door delivery use
Replacement of engine oil
(WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
Replacement of engine oil filter
(WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil filter
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
Inspection*1 of brake linings and drums
(include parking brake linings and drums)Every 10000 km (6000 miles) or 6
months
Inspection*1 of brake pads and discsEvery 10000 km (6000 miles) or 3
months
Inspection*1 or replacement of continu-
ously variable transmission fluid
(including front differential)I: Every 5000 km (3000 miles) or 3 months
R: Every 50000 km (30000 miles)
B-4: Continuous high speed driving (80% or more of maximum vehicle speed) for over 2 hours
Replacement of manual transmission oil
(including front differential)Every 40000 km (24000 miles) or 48
months
Inspection*1 or replacement of continu-
ously variable transmission fluid
(including front differential)I: Every 5000 km (3000 miles) or 3 months
R: Every 50000 km (30000 miles)
RAIZE_OM_General_BZ358E.book 300 ページ ２０２２年５月１７日　火曜日　午後１時５９分