2022 HYUNDAI SANTA FE HYBRID charge

Foreword / Hybrid System Overview
1-44
Charging stopped. Check the cable
connection
OOSEV048196L
This warning message is displayed
when charging is stopped because the
charging connector is not correctly
connected to the charging inlet
In this case, separate the charging
connector and re-connect it and check
whether there is any problem (external
damage, foreign substances, etc.) with
the charging connector and charging
inlet.
If the same problem occurs when
charging the vehicle with a replaced
charging cable or genuine HYUNDAI
portable charger, we recommend that
you have your vehicle inspected by an
authorized HYUNDAI dealer. Remaining time (Plug-in hybrid
vehicle)OAEPHQ049818L
This message is displayed to notify
the remaining time to fully charge the
battery.
Wait until fuel door unlocks (Plug-in
hybrid vehicle)
OTMPHQ010032L
This message is displayed when you
attempt to unlock the fuel filler door with
the fuel tank pressurized. Wait until the
fuel tank is depressurized.

01
1-45
NOTICE

[It may take up to 20 seconds to
unlock fuel filler door.

[ If the fuel filler door does not open
because ice has formed around it,
tap lightly or push on the door to
break the ice and release the door.

[ Do not pry on the door. If necessary,
spray around the door with an
approved de-icer fluid (do not use
radiator anti-freeze) or move the
vehicle to a warm place and allow
the ice to melt.
Check fuel door (Plug-in hybrid
vehicle)
OAEPHQ049831L
The message is displayed when the fuel filler door is open while in driving or an
abnormality has occurred. Fuel door unlocked (Plug-in hybrid
vehicle)
OTMPHQ010033L
The message is displayed when the fuel
filler door unlocked. Also means “Ready
to refuel”. Please press the rear center
edge of fuel filler door to open.
Shift to P to charge (Plug-in hybrid
vehicle)
OAEPHQ049833L
This message is displayed when the
charging connector is plugged with the
shift lever in R (Reverse), N (Neutral) or
D (Drive). Move the shift lever to P (Park)
and re-start the charging process.

01
1-49
Engine generation
OTMHQ010006
When the vehicle is stopped, the high-
voltage battery is charged up by the engine.
(QJLQH
Ÿ%DWWHU\
Regeneration
OTMHQ010007
The high-voltage battery is charged up
by the regenerative brake system.
:KHHO
Ÿ%DWWHU\ Engine brake
OTMHQ010008
The engine braking is used to decelerate
the vehicle.
:KHHO
Ÿ(QJLQH
Power reserve
OTMHQ010009
The engine is simultaneously used to
drive the vehicle and to charge up the
high-voltage battery.
(QJLQH
Ÿ:KHHO %DWWHU\

Foreword / Hybrid System Overview
1-50
Engine generation/motor drive
OTMHQ010010
The engine charges up the high-voltage
battery. The motor power is used to drive
the vehicle.
(QJLQH
Ÿ%DWWHU\
Ÿ:KHHO
Engine generation/regeneration
OTMHQ010011
The engine and regenerative brake
system charges up the high-voltage
battery.
(QJLQH :KHHO
Ÿ%DWWHU\ Engine brake/regeneration
OTMHQ010012
The engine braking is simultaneously
used to decelerate the vehicle and to
charge up the high-voltage battery.
:KHHO
Ÿ(QJLQH %DWWHU\

Foreword / Hybrid System Overview
1-52
WARNING

[ Do not disassemble the high voltage
motor connector. The high voltage
motor connector may contain
residual high voltage. Coming in
contact with high voltage may result
in death or serious injury.

[ Your vehicle’s hybrid system should
only be inspected or repaired by an
authorized HYUNDAI dealer.
WARNING

[ Do not disassemble or assemble
the high voltage battery system.
Doing so may result in electric shock,
causing death or serious injury.

[ If you disassemble or assemble
hybrid system components
improperly, it may damage the
performance and reliability of your
vehicle.

[ If electrolyte comes in contact
with your body, clothes or eyes,
immediately flush with a large
quantity of fresh tap water. Have
your eyes examined by a doctor as soon as possible.
WARNING
Never assemble or disassemble the
high voltage battery system.
[ If you assemble or disassemble the
high voltage battery system, the
durability and performance of the
vehicle may be damaged.

[ When you want to check the high
voltage battery system, have the
vehicle inspected by an authorized
HYUNDAI dealer.

[ Do not touch the high voltage
battery and high voltage cable
connected to motor (orange color).
Severe burns and electric shock may
occur. For your safety, do not touch
the cover of electronic components
and electronic cable. Do not remove
the cover of electronic components
and electronic cable. In particular,
never touch the high voltage battery
system when the hybrid system in
operation. It may result in death or
serious injury.
WARNING

[ Never use the package modules
(high voltage battery, inverter and
converter) for any other purpose.

[ Do not use an unauthorized battery
charger to charge the high voltage
battery. Doing so may result in death
or serious injury.

[ Never locate the high voltage system
near or in a fire.

[ Never drill into or strike the package
module. Otherwise, it may be
damaged. An electric shock may
occur, resulting in serious injury or
death.

01
1-55
WARNING
If a fire occurs:
[ If a small scale fire occurs, use a fire
extinguisher (ABC, BC) that is meant
for electrical fires.
If it is impossible to extinguish
the fire in the early stage, remain
a safe distance from the vehicle
and immediately call your local
fire emergency responders. Also,
advise them that a hybrid vehicle is
involved.
If the fire spreads to the high voltage
battery, large amount of water is
needed to put out the fire.
Using small amount of water or
fire extinguishers not meant for
electrical fires could cause serious
injury or death from electrical
shocks.

[ Upon witnessing any sparks, gases,
flames, or fuel leakage of your
vehicle, immediately call emergency
services or contact an authorized
HYUNDAI dealer. Also, advise them
that a hybrid vehicle is involved.
WARNING
When a submersion in water occurs:
When your vehicle is flooded in water, a
high-voltage battery may cause shock
or fires. Thus, turn the hybrid system
OFF, take the key in your possession and
escape to a safe place. Never attempt
physical contact with your flooded
vehicle.
Immediately contact an authorized
HYUNDAI dealer and advise them that a
hybrid vehicle is involved.
When the Hybrid Vehicle Shuts Off
When the high voltage battery or 12 volt
battery is discharged, or when the fuel
tank is empty, the hybrid system may
not operate while driving. When the
Hybrid system does not operate, do the
followings:
1. Gradually reduce the vehicle speed. Pull over your vehicle off the road in a
safe area.
2. Make sure the shift button is in P (Park).
3. Turn ON the hazard warning flashers.
4. Turn OFF the vehicle, and try to start the hybrid system again, while
depressing the brake pedal and
turning on the ignition switch.
5. When the hybrid system still does not operate, refer to “Jump starting”
section in chapter 8.
Before jump-starting the vehicle,
check the fuel level and the exact
procedure to jump start. For further
details, refer to “Jump starting”
section in chapter 8. When the fuel
level is low, do not attempt to drive
the vehicle only with the battery
power. The high voltage battery may
be discharged, and the hybrid system
will turn OFF.

2-5
02
1. Instrument cluster .................................. 4-5
2. Driver’s front air bag ............................. 3-45
3. Engine Start/Stop button ....................... 6-5
4. Infotainment system ...... Infotainment manual
5. Hazard warning lamp switch ................. 8-2
6. Climate control system ........................ 5-82
7. Transmission shift button .....................6-10
8. Auto Hold button .................................. 6-24
9. Heated steering wheel button ..............5-23
10. Drive mode button (On-road)/Terrain mode button (Off-road) ........................ 6-45, 6-48 11. DBC(Downhill Brake Control) button .. 6-33
12. Parking Safety button .......................... 7-124
13. Parking/View button ........................... 7-104
14. Air ventilation seat button ................... 3-20
15. Seat warmer button .............................. 3-18
16. Passenger’s front air bag ..................... 3-45
17. Glove box .............................................. 5-98
18. Wireless charging system pad ............ 5-105
19. Cup holder ...........................................5-100
20. AC inverter ........................................... 5-103
21. USB charger ......................................... 5-103
The actual shape may differ from the illustration.
OTMH010004
,167580(173$1(/29(59,(:
ã,
ä
Ø+<%5,'9(+,&/(

2-11
02
,167580(173$1(/29(59,(:
ã,
ä
Ø3/8*
Ø,1+<%5,' 9(+,&/(
The actual shape may differ from the illustration.
OTMPH010004L
1. Instrument cluster .................................. 4-5
2. Driver’s front air bag ............................. 3-45
3. Engine Start/Stop button ....................... 6-5
4. Infotainment system ...... Infotainment manual
5. Hazard warning lamp switch ................. 8-2
6. Climate control system ........................ 5-82
7. Transmission shift button .....................6-10
8. EV/HEV button ...................................... 1-36
9. Auto Hold button .................................. 6-24
10. Heated steering wheel button ..............5-23
11. AWD lock button .................................. 6-38 12. DBC(Downhill Brake Control) button .. 6-33
13. Parking Safety button .......................... 7-124
14. Parking/View button ........................... 7-104
15. Seat warmer button ............................. 3-20
16. Air ventilation seat button .................... 3-18
17. Passenger’s front air bag ..................... 3-45
18. Glove box .............................................. 5-98
19. Wireless charging system pad ............ 5-105
20. Cup holder ...........................................5-100
21. AC 220V inverter .................................. 5-103
22. USB charger ......................................... 5-103