2021 TOYOTA HIGHLANDER automatic transmission fluid

45Maintenance Log
MAINTENANCE LOG
MAINTENANCE
60,000 miles or 72 months
■ Add Toyota EFI Tank Additive or equivalent
(Hawaii, Puerto Rico and Saipan only)
■Check installation of driver’s floor mat
■Inspect and adjust all fluid levels1
■Inspect wiper blades
■Replace cabin air filter
■Replace engine air filter
Inspect the following:
_ A

utomatic transmission fl
u
id cooler
h

oses and connections
_ A

utomatic transmission for signs of leakage
_ B

all joints and dust covers
_ B

rake lines and hoses
_ B

rake linings/drums and
brake pads/discs
6
_ Dr ive belts7
_Dr ive shaft boots
Additional Maintenance Items for Special Operating Conditions3
Driving on dirt roads or dusty roads: ■Tighten nuts and bolts on chassis and body
Driving while towing, using a car-top carrier, or heavy vehicle loading:9
■Replace automatic transmission fluid
■Tighten nuts and bolts on chassis and body
Extensive idling and/or low speed driving for a long distance such as police, taxi or
door-to-door delivery use:
■Replace automatic transmission fluid

1
Inspect sealed transmissions, transfer cases and differentials for signs of leakage. If any leakage from a sealed component is suspected, it is recommended that you have the sealed component inspected by a Toyota dealer. Inspect
power steering fluid (if equipped) and brake fluid level/condition. Inspect engine and inverter (if equipped) coolant
level/condition/freezing point. Your dealer may recommend services (Dealer-Recommended Maintenance) based on
inspection results.
2 R eset the oil replacement reminder light (“MAINT REQD”) or the message “OIL MAINTENANCE REQUIRED” on the
multi-information display after maintenance at every 5,000 miles.
3 P erform these service items only if you drive primarily under the conditions indicated. 4 Includes operating on roads which road salt has been applied.5 Maintenance services of spark plugs are required under the terms of the Emissions Control Warranty. 6 Inspect thickness measurement and disc runout.7 Initial inspection at 60,000 miles/ 72 months. Inspect every 15,000 miles/18 months thereafter. 8 R efer to “Engine Coolant” in the “Explanation of Maintenance Items” section in the back of this guide for more information.9 N ot all vehicles are designed for towing. Refer to your Vehicle Owner’s Manual for details.
_
Engine coolant8
_ Engine oil cooler hoses and connections
_ E

xhaust pipes and mountings
_ F

uel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
_ F

uel tank cap gasket
_ R

adiator and condenser
_S

teering gear
_S

teering linkage and boots
Dealer Service verification:
D
ate:
Mileage: ■
Replace engine oil and oil filter2
■Replace rear differential oil (4WD)
■Replace spark plugs5
■Replace transfer case oil (4WD)
■Re-torque propeller shaft bolt (4WD)
■Rotate tires _Engine oil cooler hoses and connections
_Exhaust pipes and mountings
_ Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
_Fuel tank cap gasket
_Radiator and condenser
_Steering gear
_Steering linkage and boots
19-TCS-14200 TMY21 WMG Highlander.indd 4519-TCS-14200 TMY21 WMG Highlander.indd 458/6/20 1:50 AM8/6/20 1:50 AM

53Maintenance Log
MAINTENANCE LOG
MAINTENANCE
120,000 miles or 144 months

■ Add Toyota EFI Tank Additive or equivalent
(Hawaii, Puerto Rico and Saipan only)

■Check installation of driver’s floor mat

■Inspect and adjust all fluid levels1

■Inspect wiper blades

■Replace cabin air filter

■Replace engine air filter
Inspect the following:
_
A

utomatic transmission fl
u
id cooler
h

oses and connections
_ A

utomatic transmission for signs of leakage
_ B

all joints and dust covers
_ B

rake lines and hoses
_ B

rake linings/drums and brake pads/discs
6
_ Dr ive belts
_
D

rive shaft boots
_E

ngine coolant
7
_Additional Maintenance Items for Special Operating Conditions3
Driving on dirt roads or dusty roads:
■Tighten nuts and bolts on chassis and body
Driving while towing, using a car-top carrier, or heavy vehicle loading:8

■Replace automatic transmission fluid

■Tighten nuts and bolts on chassis and body
Extensive idling and/or low speed driving for a long distance such as police, taxi or
door-to-door delivery use:

■Replace automatic transmission fluid

1
Inspect sealed transmissions, transfer cases and differentials for signs of leakage. If any leakage from a sealed
component is suspected, it is recommended that you have the sealed component inspected by a Toyota dealer. Inspect
power steering fluid (if equipped) and brake fluid level/condition. Inspect engine and inverter (if equipped) coolant
level/condition/freezing point. Your dealer may recommend services (Dealer-Recommended Maintenance) based on
inspection results.
2 R
eset the oil replacement reminder light (“MAINT REQD”) or the message “OIL MAINTENANCE REQUIRED” on the
multi-information display after maintenance at every 5,000 miles.
3 P erform these service items only if you drive primarily under the conditions indicated. 4 Includes operating on roads which road salt has been applied.5 Maintenance services of spark plugs are required under the terms of the Emissions Control Warranty.6 Inspect thickness measurement and disc runout.7 R
efer to “Engine Coolant” in the “Explanation of Maintenance Items” section in the back of this guide for more information.8 N ot all vehicles are designed for towing. Refer to your Vehicle Owner’s Manual for details.
_
Engine oil cooler hoses and connections
_ E

xhaust pipes and mountings
_ F

uel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
_ F

uel tank cap gasket
_ R

adiator and condenser
_
S

teering gear
_
S

teering linkage and boots
Dealer Service verification:
D
ate:
Mileage:
■
Replace engine oil and oil filter2

■Replace rear differential oil (4WD)

■Replace spark plugs5

■Replace transfer case oil (4WD)

■Replace vacuum pump for brake booster

■Re-torque propeller shaft bolt (4WD)

■Rotate tires
19-TCS-14200 TMY21 WMG Highlander.indd 5319-TCS-14200 TMY21 WMG Highlander.indd 538/6/20 1:50 AM8/6/20 1:50 AM

54Maintenance Log
MAINTENANCE
EXPLANATION OF MAINTENANCE ITEMS
T
he following descriptions are
provided to give you a better
understanding of the maintenance
items that should be performed on your
vehicle. The scheduled maintenance log
indicates at which mileage/time intervals
each item should be performed. Please
note that many maintenance items should
be performed only by a qualified technician.
For further information on maintenance
items you can perform yourself, see the
“Maintenance and Care” section of the
Owner’s Manual.
Automatic Transmission Fluid
Inspect or replace at specified intervals.
When performing inspections, check each
component for signs of leakage. If you
discover any leakage, have it repaired by
a qualified technician immediately.
Ball Joints and Dust Covers
Check the suspension and steering
linkage ball joints for looseness and
damage. Check all dust covers for
deterioration and damage. Replace
any deteriorated or damaged parts.
A qualified technician should perform
these operations.
Brake Lines and Hoses
Visually inspect for proper installation.
Check for chafing, cracks, deterioration
and signs of leakage. Replace any
deteriorated or damaged parts. A qualified
technician should perform these operations.
Brake Linings/Drums and
Brake Pads/Discs
Check the brake linings (shoes) and
drums for scoring, burning, fluid leakage,
broken parts and excessive wear. Check
the pads for excessive wear and the discs
for runout, excessive wear and fluid
leakage. Replace any deteriorated or
damaged parts. A qualified technician
should perform these operations.
Cabin Air Filter
Replace at specified intervals. Driving in
heavy traffic, on dirt roads or in urban,
desert or dusty areas may shorten filter’s
life. More frequent replacement may
be necessary.
Drive Belts
Inspect for cracks, excessive wear and
oiliness. Check the belt tension and adjust
if necessary. Replace the belts if they
are damaged.
19-TCS-14200 TMY21 WMG Highlander.indd 5419-TCS-14200 TMY21 WMG Highlander.indd 548/6/20 1:50 AM8/6/20 1:50 AM