2021 PEUGEOT BOXER fuse box

4
Overview
Presentation
These illustrations and descriptions are intended
as a guide. The presence and location of certain
elements may vary, depending on the version or
trim level.
Instruments and controls



1. Instrument panel with display screen
2. Lighting control and direction indicator stalk
3. Wiper/Screenwash
control stalk
Trip computer (Diesel)
4. Vehicle configuration/Headlamps beam
height/Front/rear foglamps 5.
Steering mounted controls for the audio
system
6. Driver's front airbag/Horn
7. Ignition switch
8. Additional programmable heating (Diesel)
Heating (Electric)
9. Fusebox
10. Cruise control/speed limiter controls (Diesel)
11 . Pneumatic suspension/Reading spotlamps/
Additional rear ventilation (Diesel)
Centre console



1. Audio system/Navigation
2. Heating/Air conditioning
3. Storage compartment/Removable ashtray
4. 12 volt accessory socket (180
W max)
5. USB socket/Cigarette lighter
6. Dynamic stability control (DSC/ASR)
Intelligent traction control (Diesel)
7. Hill Assist Descent Control
8. Lane departure warning system
9. Hazard warning lamps
10. Central locking
11 . De-icing/Demisting
12. Gear lever (Diesel)
Drive selector (Electric)

56
Safety
General safety
recommendations
Do not remove the labels attached in
different places on your vehicle. They
include safety warnings as well as
identification information for the vehicle.
For all work on your vehicle, use a
qualified workshop that has the technical
information, skills and equipment required, all
of which a PEUGEOT dealer is able to
provide.
Depending on country regulations,
certain safety equipment may be
mandatory: high visibility safety vests,
warning triangles, breathalysers, spare bulbs,
spare fuses, fire extinguisher, first aid kit, mud
flaps at the rear of the vehicle, etc.
Installing electrical accessories:
– The fitting of electrical equipment or
accessories not approved by PEUGEOT
may
cause excessive current consumption and
faults and failures with the electrical system
of your vehicle. Contact a PEUGEOT dealer
for information on the range of approved
accessories.
–

As a safety measure, access to the
diagnostic socket, used for the vehicle's
electronic systems, is reserved strictly for
PEUGEOT dealers or qualified workshops,
equipped with the special tools required (risk
of malfunctions of the vehicle's electronic
systems that could cause breakdowns or
serious accidents). The Manufacturer cannot
be held responsible if this advice is not
followed.
–

Any modification or adaptation not intended
or authorised by PEUGEOT

or carried out
without meeting the technical requirements
defined by the Manufacturer will result in the
suspension of the commercial warranty.
Installation of accessory radio
communication transmitters
Before installing a radio communication
transmitter with an external aerial, you must
without fail contact a PEUGEOT dealer for
the specification of transmitters which can
be fitted (frequency, maximum power, aerial
position, specific installation requirements),
in line with the Vehicle Electromagnetic
Compatibility Directive (2004/104/EC).
Declarations of conformity for radio
equipment
The relevant certificates are available on the
http://public.servicebox.peugeot.com/APddb/
website.
Hazard warning lamps



► Pressing this red button causes all the
direction indicators to flash.
They can work with the ignition switched off.
Horn

► Press the central part of the steering wheel.

108
Practical information
On the outside

► Push the lever located above the grille
upwards and lift the bonnet.
Do not open the bonnet under very windy
conditions.
When the engine is hot, handle the lever and
the stay with care (risk of burns).


► Unclip the stay and rotate it to insert it into
the first slot and then into the second slot.
Because of the presence of electrical
equipment under the bonnet, it is
recommended that exposure to water (rain,
washing, etc.) be limited.
Closing the bonnet
► Before closing the bonnet, replace the stay in
its housing.
►

Lower the bonnet and release it near the end
of its travel. Check the bonnet is locked.
Diesel engines



1. Screenwash and headlamp washer reservoir
2. Power steering fluid reservoir
3. Engine coolant reservoir
4. Brake and clutch fluid reservoir
5. Diesel fuel filter
6. Fusebox
7. Air filter
8. Dipstick
9. Engine oil filler cap
Battery connections:
+ Positive metallic terminal
- Negative metallic terminal (earth)
Diesel fuel system
This system is under very high pressure.

109
Practical information
7All work must be carried out only by a
PEUGEOT dealer or a qualified workshop
Electric motor

1.Screenwash and headlamp washer reservoir
2. Engine coolant reservoir
3. Power steering fluid reservoir
4. Brake and clutch fluid reservoir
5. Heating
circuit fluid reservoir
6. Fusebox
Checking levels
Check all of the following levels regularly in
accordance with the manufacturer's service
schedule. Top them up if required, unless
otherwise indicated.
If a level drops significantly, have the
corresponding system checked by a PEUGEOT
dealer or a qualified workshop.
The fluids must comply with the
manufacturer's requirements and with
the vehicle's engine.
Take care when working under the bonnet, as certain areas of the engine
may be extremely hot (risk of burns) and the
cooling fan could start at any time (even with
the ignition off).
If the engine cover is to be removed /
refitted, handle it with care to avoid
damaging the mounting clips.
Used products
Avoid prolonged contact of used oil or fluids with the skin.
Most of these fluids are harmful to health and
very corrosive.
Do not discard used oil or fluids into
sewers or onto the ground.
Empty used oil into the containers reserved
for this purpose at a PEUGEOT dealer or a
qualified workshop.
Engine oil
The level is checked, with the engine having been switched off for at least 30
minutes and on level ground, using the dipstick.
It is normal to top up the oil level between two
services (or oil changes). It is recommended
that you check the level, and top up if necessary,
every 3,000 miles (5,000 km).
In order to maintain the reliability of the
engine and emissions control system,
never use additives in the engine oil.
Checking using the dipstick
For the location of the dipstick, please refer
to the illustration of the corresponding engine
compartment.
►

Grasp the dipstick by its coloured grip and
pull it out completely

.
►

Wipe the end of the dipstick using a clean,
lint-free cloth.


► Reinsert the dipstick and push fully down,
then pull it out again to visually check the oil
level: the correct level is between marks A
(max)
and B (min).
Do not start the engine if the level is:
–

above mark
A: contact a PEUGEOT dealer or
a qualified workshop.
–

below mark B

: top up the engine oil
immediately.
Oil grade
Before topping up or changing the engine
oil, check that the oil is suitable for the engine
and complies with the recommendations in

131
In the event of a breakdown
8Disconnecting the battery

► Tilt lever 1 downwards to release the
terminals.
►
Remove terminals

2
from the negative (-)
terminal.
Wait approximately 6 minutes after
switching off the ignition before
disconnecting the battery.
Do not disconnect the terminals while the
engine is running.
Do not charge a battery without disconnecting
the terminals first.
Close the windows and the doors before
disconnecting the battery.
After reconnecting the battery, turn on the
ignition and wait 1 minute before starting the
engine, to enable the electronic systems to
initialise. If minor problems nevertheless persist
following this operation, contact a PEUGEOT
dealer or a qualified workshop.
It is recommended to disconnect the (-)
terminal of the battery if the vehicle is to
be left unused for more than one month.
The description of the battery charging
procedure is only indicative.
After prolonged battery disconnection, it may be
necessary to reinitialise the following functions:
–

the display parameters (date, time, language,
distance and temperature units),
–


the stations of the audio system,
–


the central locking.
Some settings are cancelled and must be
entered once again; contact a PEUGEOT

dealer.
If the vehicle is equipped with a tachograph or
an alarm,
it is recommended that the (-) terminal
of the battery (located under the floor on the
left-hand side, in the cab) be disconnected if the
vehicle is not going to be used for more than 5
days.
Starting using another
battery
Never start the engine by connecting a
battery charger.
Never use a 24 V or higher battery booster.
Check beforehand that the backup battery
has a nominal voltage of 12 V and a capacity
at least equal to that of the discharged
battery.
The two vehicles must not be in contact with
each other.
Switch off all electricity-consuming equipment
on both vehicles (audio system, wipers,
lighting, etc.).
Make sure that the jump leads are well away
from the engine’s moving parts (fan, belt,
etc.).
Do not disconnect the (+) terminal while the
engine is running.
Starting the engine using another battery is to be
performed inside the engine compartment.
►

Open the bonnet.

A. Positive metallic terminal on the vehicle
B. Backup battery
C. Vehicle earth point
The positive metallic terminal A is accessible
through a flap located on the side of the fuse
box.

190
Alphabetical index
A
ABS 29
Accelerated charging unit (Wallbox)
71
Accessories

28
Active Safety Brake

90–92
AdBlue®

86
AdBlue® tank

87
Adjusting the date

21
Adjusting the seat angle

18
Adjusting the seat belt height

60–61
Adjusting the time

21
Advice on care and maintenance

70, 88
Advice on driving

6, 69–70
Airbags

35, 37
Airbags, curtain

35
Airbags, front

62–63
Airbags, lateral

35
Air conditioning

23, 39–40
Air conditioning, additional

39–40
Air conditioning, automatic

24
Air conditioning, manual

24
Air vents

23
Alarm

27–28
Anti-lock braking system (ABS)

29
Armrest, front

19
ASR

29
Assistance, emergency braking

29, 64
Audible warning

28
Audio streaming (Bluetooth)

173–174
Audio system

134
B
Battery 45
Battery, 12 V
111–112, 102
Battery, ancillaries

102
Blind spot sensors

61
BlueHDi

14, 83
Bluetooth (hands-free)

137, 177–178
Bluetooth (telephone)

137, 177–178
Bodywork

89
Bonnet

79
Brake discs

85
Brakes

85
Braking, automatic emergency

90–92
Brightness

8
Bulbs (changing)

97
Bulbs (changing, type)

97
C
Cable, audio 136, 145
Cable, Jack
136, 145
Capacity, fuel tank

68
Care of the bodywork

89
CCS (Combined Charging System)

74
CD

145
CD, MP3

145
Centre console

4
Changing a bulb

97
Changing a fuse

101
Changing to free-wheeling

105
Charging cable (Electric) 71
Charging connector (Electric)
70, 101–103
Charging flap (Electric)

70, 101–103
Charging system (Electric)

5, 6, 69
Charging the traction battery
(Electric)

69, 101–103
Checking the levels

109–111
Checks

111 – 11 3
Checks, routine

111 – 11 3
Children

33
Child seats

33, 63–65
Cigar lighter

35
Cleaning (advice)

70, 116–117
Collision Risk Alert

90–92
Configuration, vehicle

15, 21
Container, AdBlue®

87
Control, heated seats

19
Control stalk, lighting

23
Control stalk, wipers

26
Control unit

71
Courtesy lamp, front

43–46
Courtesy lamp, rear

36
Courtesy lamps

36
Cruise control

85–86
D
DAB (Digital Audio Broadcasting) -
Digital radio
144
Dashboard

4
Daytime running lamps, LED

23

191
Alphabetical index
Deactivating the passenger airbag 34, 37
Dimensions
11 3
Dipstick

81
Direction indicators

23
Display screen, instrument panel

8, 47
Domestic charging (Electric)

102–103
Drive selector (Electric)

47
Driving

69–70
Driving aids camera (warnings)

53
Driving aids (recommendations)

52
Driving economically

6
DSC

29
Dynamic stability control (DSC)

57–58
E
EBA 29
EBFD
29
Eco-driving (advice)

6
Electric motor

5, 6, 8, 69, 76,
81, 102, 105, 109
Electric windows

18
Electronic brake force distribution (EBFD)

29
Emergency warning lamps

28
Emissions control system, SCR

86
Engine compartment

108–109
Engine, Diesel

69, 80, 108
Engines

135–136
Environment

6, 42
ESP/ASR

30
F
Filling the AdBlue® tank 83, 87
Filling the fuel tank
68
Filter, air

84
Filter, Diesel fuel

85
Filter, oil

84
Filter, particle

84
Filter, passenger compartment

23, 84
Fittings, front

43–46
Fittings, interior

43–46
Flap, fuel filler

68
Flashing indicators

23
Fluid, brake

110–111
Fluid, engine coolant

110–111
Fluid, power steering

110–111
Foglamps, front

23
Foglamps, rear

23
Front doors

16
Fuel

6, 69
Fuel consumption

6
Fuel tank

68
Fuses

101
G
Gauge, fuel 68
Gearbox, manual
47, 49, 85
Glove box

43–45
H
Hazard warning lamps 28
Headlamp flash
23
Headlamps, dipped beam

23
Headlamps, main beam

23
Head restraints, front

18
Heating

35–36
Heating, additional

39–40
High voltage

69
Hill Descent Control

31
Hill start assist

77–78
Horn

28
I
Immobiliser, electronic 43
Indicator, coolant temperature
14
Indicator, engine oil level

13
Indicators, direction

23
Inflating tyres

85
Information, vehicle

151, 159
Infrared camera

53
Instrument panel

53
Instruments and controls

4
Intelligent Traction Control

31
J
Jack 136, 145