2020 Hyundai Tucson 4WD

6-23
What to do in an emergency
6
Towing service
If emergency towing is necessary,
we recommend having it done by an
authorised HYUNDAI dealer or a
commercial tow-truck service.
Proper lifting and towing procedures
are necessary to prevent damage to
the vehicle. The use of wheel dollies
or a flatbed is recommended.It is acceptable to tow the vehicle
with the rear wheels on the ground
(without dollies) and the front wheels
off the ground.
If any of the loaded wheels or sus-
pension components are damaged
or the vehicle is being towed with the
front wheels on the ground, use a
towing dolly under the front wheels.
When being towed by a commercial
tow truck and wheel dollies are not
used, the front of the vehicle should
always be lifted, not the rear.
For 4WD vehicles, it must be towed
with a wheel lift and dollies or flatbed
equipment with all the wheels off the
ground.
T TO
OW
WI
IN
NG
G

OTLE068026Dollies Dollies
A 4WD vehicle should never be
towed with the wheels on the
ground. This can cause serious
damage to the transmission or
the 4WD system.
CAUTION
OTLE068028
OTLE068027

7-13
7
Maintenance
Normal Maintenance Schedule (Petrol Engine [1.6 T-GDI]) (Cont.)
Months1224364860728496
Km x 1,0001020304050607080
Dual clutch transmission fluid *8II
Transfer case oil (4WD) *8I
Rear differential oil (4WD) *8I
Propeller shaft (if equipped)II
Valve clearance *9Inspect every 90,000 km or 72 months
Exhaust systemIIII
I : Inspect and if necessary, adjust, correct, clean or replace.
R : Replace or change.
*
8: Dual clutch transmission fluid,Transfer case oil and Rear differential oil should be changed anytime they have been submerged
in water.
*
9: Inspect for excessive valve noise and/or engine vibration and adjust if necessary.We recommend that the system be checked
by an authorised HYUNDAI dealer.
MAINTENANCE
INTERVALS
MAINTENANCE
ITEM

7-15
7
Maintenance
Maintenance itemMaintenance
operationMaintenance intervalsDriving
condition
Climate control air filterRReplace more frequently
depending on the conditionC, E, G
Dual clutch transmission fluidREvery 120,000 kmC, D, E, F, G, H, I, J
Transfer case oil (4WD)REvery 120,000 kmC, D, E, G, H, I, J
Rear differential oil (4WD)REvery 120,000 kmC, D, E, G, H, I, J
Propeller shaft (if equipped)IEvery 10,000 km or 12 monthsC, E
Severe driving conditions
A : Repeatedly driving short distances of less than 8 km in nor-
mal temperatures or less than 16 km in freezing temperatures
B : Extensive engine idling or low speed driving for long distances
C : Driving on rough, dusty, muddy, unpaved, gravelled or salt
spread roads
D : Driving in areas using salt or other corrosive materials or in
very cold weather
E : Driving in the heavy dust conditionsF : Driving in heavy traffic areas
G : Driving uphill, downhill, or on mountain roads repeatedly
H : Towing a trailer, or using a camper or roof rack
I : Driving as patrol car, taxi, commercial vehicle or vehicle tow-
ing
J : Driving over 170 km/h
K : Frequently driving in stop-and-go conditions

7-19
7
Maintenance
Normal Maintenance Schedule (Petrol Engine [2.0 GDI]) (Cont.)
Months1224364860728496
Km x 1,000153045607590105120
Transfer case oil (4WD) *8II
Rear differential oil (4WD) *8II
Propeller shaft (if equipped)IIII
Exhaust systemIIII
I : Inspect and if necessary, adjust, correct, clean or replace.
R : Replace or change.
*
8: Manual transmission fluid,Transfer case oil and Rear differential oil should be changed anytime they have been submerged in
water.
MAINTENANCE
INTERVALS
MAINTENANCE
ITEM

7-21
7
Maintenance
Maintenance itemMaintenance
operationMaintenance intervalsDriving
condition
Climate control air filterRReplace more frequently
depending on the conditionC, E, G
Manual transmission fluidREvery 120,000 kmC, D, E, F, G,
H, I, J
Automatic transmission fluidREvery 100,000 kmA, C, D, E, G, H, I, J
Transfer case oil (4WD)REvery 120,000 kmC, D, E, G, H, I, J
Rear differential oil (4WD)REvery 120,000 kmC, D, E, G, H, I, J
Propeller shaft (if equipped)IEvery 15,000 km or 12 monthsC, E
Severe driving conditions
A : Repeatedly driving short distances of less than 8 km in nor-
mal temperatures or less than 16 km in freezing temperatures
B : Extensive engine idling or low speed driving for long distances
C : Driving on rough, dusty, muddy, unpaved, gravelled or salt
spread roads
D : Driving in areas using salt or other corrosive materials or in
very cold weather
E : Driving in the heavy dust conditionsF : Driving in heavy traffic areas
G : Driving uphill, downhill, or on mountain roads repeatedly
H : Towing a trailer, or using a camper or roof rack
I : Driving as patrol car, taxi, commercial vehicle or vehicle tow-
ing
J : Driving over 170 km/h
K : Frequently driving in stop-and-go conditions

7-24
Maintenance
Normal Maintenance Schedule (Diesel Engine [2.0 TCI]) (Cont.)
Months1224364860728496
Km x 1,000153045607590105120
Front suspension ball jointsIIIIIIII
Air conditioner refrigerant
(if equipped)IIIIIIII
Air conditioner compressor
(if equipped)IIIIIIII
Climate control air filter
(if equipped)IIIIIIII
Manual transmission fluid *7II
Automatic tansmission fluidNo check, No service required
Transfer case oil (4WD) *7II
Rear differential oil (4WD) *7II
Propeller shaft (if equipped) IIII
Exhaust systemIIII
I : Inspect and if necessary, adjust, correct, clean or replace.
R : Replace or change.
*
7: Manual transmission fluid,Transfer case oil and Rear differential oil should be changed anytime they have been submerged in
water.
MAINTENANCE
INTERVALS
MAINTENANCE
ITEM

7-26
Maintenance
Maintenance itemMaintenance
operationMaintenance intervalsDriving
condition
Climate control air filter (if equipped)RReplace more frequently
depending on the conditionC, E, G
Manual transmission fluidREvery 120,000 kmC, D, E, F, G,
H, I, J
Automatic transmission fluidREvery 100,000 kmA, C, D, E,
F, G, H, I, J
Transfer case oil (4WD)REvery 120,000 kmC, D, E, G, H, I, J
Rear differential oil (4WD)REvery 120,000 kmC, D, E, G, H, I, J
Propeller shaft (if equipped)IEvery 15,000 km or 12 monthsC, E
Severe driving conditions
A : Repeatedly driving short distances of less than 8 km in nor-
mal temperatures or less than 16 km in freezing temperatures
B : Extensive engine idling or low speed driving for long distances
C : Driving on rough, dusty, muddy, unpaved, gravelled or salt
spread roads
D : Driving in areas using salt or other corrosive materials or in
very cold weather
E : Driving in the heavy dust conditionsF : Driving in heavy traffic areas
G : Driving uphill, downhill, or on mountain roads repeatedly
H : Towing a trailer, or using a camper or roof rack
I : Driving a patrol car, taxi, commercial vehicle or vehicle towing
J : Driving over 170 km/h
K : Frequently driving in stop-and-go conditions

7-72
Maintenance
Driver’s side fuse panel
Fuse Name SymbolFuse RatingCircuit Protected
A/CON 1 1A/C7.5A A/C Control Module, Cluster Ionizer,
E/R Junction Block (RLY. 4/5/13 - PTC HEATER 3/PTC HEATER 2/Blower Relay)
RR WIPER 15A Rear Wiper Motor, ICM Relay Box (Rear Wiper Relay)
MODULE 6 10A BCM, Smart Key Control Module
WASHER 15A Multifunction Switch (Wiper Low & Washer Switch)
MODULE 5 7.5A BCM, Parking Distance Warning Buzzer, ATM Shift Lever, 4WD ECM, Crash Pad Switch,
Lane Keeping Assist Unit, Blind-Spot Collision Warning Unit LH/RH, Console Switch,
Forward Collision Avoidance Assist Unit
A/BAG 15A SRS Control Module
MODULE 1 10A BCM, Smart Key Control Module, A/V & Navigation Head Unit, Audio, AMP, Power Outside
Mirror Switch, Wireless Charger, Rear USB Charger, Surround View Monitor
START 10A [W/O Smart Key & IMMO.] ICM Relay Box (Burglar Alarm Relay)
[With Smart Key / IMMO.] Transmission Range Switch, ECM, Ignition Lock & Clutch Switch,
Smart Key Control Module, E/R Junction Block (RLY. 11 - Start Relay)
MODULE 7 7.5A Rear Seat Warmer, Front Air Ventilation Seat Control Module,
Front Seat Warmer Control Module, Surround View Monitor
HTD STRG 15A BCM
MODULE 8 7.5A Key Solenoid, Driver/Passenger Smart Key Outside Handle, Centre Facia Switch,
Driver/Passenger Power Outside Mirror, Data Link Connector,
Forward Collision Avoidance Assist Unit