2020 HYUNDAI I10 transmission
[x] Cancel search: transmissionPage 345 of 486
6-89
06
i Information
7he ESC system (if equipped) must be
turned 2FF before rocking the vehicle.
NOTICE
If you are still stuck after rocking
the vehicle a few times, have the
vehicle pulled out by a tow vehicle
to avoid engine overheating, pos-
sible damage to the transmission,
and tyre damage. See “Towing” in
chapter 6.
Smooth cornering
Avoid braking or gear changing in
corners, especially when roads are
wet. Ideally, corners should always
be taken under gentle acceleration.
Driving at night
Night driving presents more hazards
than driving in the daylight. Here are
V R P H L P S R U W D Q W W L S V W R U H P H P E H U
Page 350 of 486
6-94
Whilst driving
To prevent locks from freezing
To prevent the locks from being fro-
zen, spray approved de-icing fluid or
glycerin into key holes. When a lock
opening is already covered with ice,
spray approved de-icing fluid over the
ice to remove it. When an internal
part of a lock freezes, try to thaw it
with a heated key. Carefully use the
K H D W H G N H \ W R D Y R L G D Q L Q M X U \
Use approved window washer anti-
freeze solution in system
To prevent the window washer from
being frozen, add authorized window
washer anti-freeze solution, as speci-
fied on the window washer container.
Window washer anti-freeze solution
is available from a HYUNDAI autho-
rised repairer, and most vehicle
accessory outlets. Do not use engine
coolant or other types of anti-freeze
solution to prevent any damage to the
vehicle paint.
Do not let your parking brake
freeze
Under some conditions your parking
brake can freeze in the engaged posi-
tion.
This is most likely to happen when
there is an accumulation of snow or
ice around or near the rear brakes or
if the brakes are wet. When there is
the risk that your parking brake may
freeze, temporarily apply it with the
V K L I W O H Y H U L Q 1 I R U $ X W R P D W H G 0 D Q X D O
Transmission) or in first or reverse
gear (for manual transmission). Also,
block the rear wheels in advance, so
the vehicle may not roll. Then, release
the parking brake.Do not let ice and snow
accumulate underneath
Under some conditions, snow and ice
can build up under the fenders and
interfere with the steering. When driv-
ing in such conditions during the
severe winter, you should check
underneath the vehicle on a regular
basis, to ensure that the front wheels
and the steering components is
unblocked.
Carry emergency equipment
In accordance with weather condi-
tions, you should carry appropriate
emergency equipment, whilst driving.
Some of the items you may want to
carry include tyre chains, tow straps
or chains, flashlight, emergency
I O D U H V V D Q G V K R Y H O M X P S H U F D E O H V
window scraper, gloves, ground cloth,
coveralls, blanket, etc.
Do not place objects or materials
in the engine compartment
3 X W W L Q J R E M H F W V R U P D W H U L D O V L Q W K H
engine compartment may cause an
engine failure or combustion,
because they may block the engine
cooling. Such damage will not be
covered by the manufacturer’s war-
ranty.
Page 359 of 486
7-7
07
i , Q I R U P D W L R Q
3 E
An inappropriately disposed
battery can be harmful to the
environment and human
health. Dispose of the battery
according to your local law(s)
or regulations.
Jump starting procedure
1. Position the vehicles close enough
that the jumper cables will reach,
but do not allow the vehicles to
touch.
2. Avoid fans or any moving parts in
the engine compartment at all
times, even when the vehicles are
turned off.
3. Turn off all electrical devices such
as radios, lights, air conditioning,
etc. Put the vehicles in N (Neutral,
for Automated manual transmis-
sion vehicle) or neutral (for Manual
transmission vehicle), and set the
parking brakes. Turn both vehicles
OFF.
OAC3079002TU
4. Connect the jumper cables in the
exact sequence shown in the illus-
tration. First connect one jumper
cable to the red, positive (+) jump-
er terminal of your vehicle (1).
5. Connect the other end of the jump-
er cable to the red, positive (+) bat-
tery/jumper terminal of the assist-
ing vehicle (2).
6. Connect the second jumper cable
to the black, negative (-) battery/
chassis ground of the assisting
vehicle (3).
7. Connect the other end of the sec-
ond jumper cable to the black, neg-
ative (-) chassis ground of your
vehicle (4).
Do not allow the jumper cables to
contact anything except the correct
battery or jumper terminals or the
correct ground. Do not lean over
the battery when making connec-
tions.
Page 361 of 486
7-9
07
If your temperature gauge indicates
overheating, you experience a loss of
power, or hear loud pinging or knock-
ing, the engine may be overheating. If
this happens, you should:
1. Pull off the road and stop as soon
as it is safe to do so.
2. Place the shift lever in N (Neutral,
for Automated manual transmis-
sion vehicle) or neutral (for Manual
transmission vehicle) and set the
parking brake. If the air condition-
ing is ON, turn it OFF.
3. If engine coolant is running out
under the vehicle or steam is com-
ing out from the bonnet, stop the
engine. Do not open the bonnet
until the coolant has stopped run-
ning or the steaming has stopped.
If there is no visible loss of engine
coolant and no steam, leave the
engine running and check to be
sure the engine cooling fan is oper-
ating. If the fan is not running, turn
the engine off.
WARNING
: K L O V W W K H H Q J L Q H L V U X Q-
Q L Q J N H H S K D Q G V F O R W K-
L Q J D Q G W R R O V D Z D \ I U R P
W K H P R Y L Q J S D U W V V X F K
D V W K H F R R O L Q J I D Q D Q G
G U L Y H E H O W W R S U H Y H Q W
V H U L R X V L Q M X U \ 4. Check for coolant leaking from the
radiator, hoses or under the vehi-
cle. (If the air conditioning had
been in use, it is normal for cold
water to be draining from it when
you stop.)
5. If engine coolant is leaking out,
stop the engine immediately and
we recommend that you call a
HYUNDAI authorised repairer for
assistance.
WARNING
1 ( 9 ( 5 U H P R Y H W K H U D G L-
D W R U F D S R U W K H G U D L Q
S O X J Z K L O V W W K H H Q J L Q H
D Q G U D G L D W R U D U H K R W + R W
F R R O D Q W D Q G V W H D P P D \
E O R Z R X W X Q G H U S U H V V X U H F D X V L Q J
V H U L R X V L Q M X U \
7 X U Q W K H H Q J L Q H R I I D Q G Z D L W X Q W L O
W K H H Q J L Q H F R R O V G R Z Q 8 V H
H [ W U H P H F D U H Z K H Q U H P R Y L Q J W K H
U D G L D W R U F D S : U D S D W K L F N W R Z H O
D U R X Q G L W D Q G W X U Q L W F R X Q W H U F O R F N-
Z L V H V O R Z O \ W R W K H I L U V W V W R S 6 W H S
E D F N Z K L O V W W K H S U H V V X U H L V
U H O H D V H G I U R P W K H F R R O L Q J V \ V W H P
: K H Q \ R X D U H V X U H D O O W K H S U H V V X U H
K D V E H H Q U H O H D V H G S U H V V G R Z Q R Q
W K H F D S X V L Q J D W K L F N W R Z H O D Q G
F R Q W L Q X H W X U Q L Q J F R X Q W H U F O R F N Z L V H
W R U H P R Y H L W
IF THE ENGINE OVERHEATS
Page 375 of 486
7-23
07
- D F N O D E H O
The actual Jack label in the vehicle
may differ from the illustration.
For more detailed specifications,
refer to the label attached to the jack.
1. Model Name
2. Maximum allowable load
3. When using the jack, set your park-
ing brake.
4. When using the jack, stop the
engine.
5. Do not get under a vehicle that is
supported by a jack.
6. The designated locations under
the frame7. When supporting the vehicle, the
base plate of jack must be vertical
under the lifting point.
8. Shift into R (Reverse) gear on vehi-
cles with Manual transmission or
move the shift lever to the N
(Neutral) position on vehicles with
Automated manual transmission.
9. The jack should be used on firm
level ground.
10. Jack manufacture
11. Production date
12. Representative company and
address
OHYK065011
Page 405 of 486
8-9
08
Vacuum crankcase ventilation
hoses (if equipped)
, Q V S H F W W K H V X U I D F H R I K R V H V I R U H Y L-
G H Q F H R I K H D W D Q G R U P H F K D Q L F D O
G D P D J H + D U G D Q G E U L W W O H U X E E H U
F U D F N L Q J W H D U V F X W V D E U D V L R Q V D Q G
H [ F H V V L Y H V Z H O O L Q J L Q G L F D W H G H W H U L R U D-
W L R Q 3 D U W L F X O D U D W W H Q W L R Q V K R X O G E H
S D L G W R H [ D P L Q H W K R V H K R V H V X U I D F H V
Q H D U H V W W R K L J K K H D W V R X U F H V V X F K D V
W K H H [ K D X V W P D Q L I R O G
, Q V S H F W W K H K R V H U R X W L Q J W R D V V X U H
W K D W W K H K R V H V G R Q R W F R P H L Q F R Q W D F W
Z L W K D Q \ K H D W V R X U F H V K D U S H G J H V R U
P R Y L Q J F R P S R Q H Q W Z K L F K P L J K W
F D X V H K H D W G D P D J H R U P H F K D Q L F D O
Z H D U , Q V S H F W D O O K R V H F R Q Q H F W L R Q V
V X F K D V F O D P S V D Q G F R X S O L Q J V W R
P D N H V X U H W K H \ D U H V H F X U H D Q G W K D W
Q R O H D N V D U H S U H V H Q W + R V H V V K R X O G
E H U H S O D F H G L P P H G L D W H O \ L I W K H U H L V
D Q \ H Y L G H Q F H R I G H W H U L R U D W L R Q R U G D P-
age.
Air cleaner filter
: H U H F R P P H Q G W K D W W K H D L U F O H D Q H U
I L O W H U E H U H S O D F H G E \ D + < 8 1 ' $ , D X-
W K R U L V H G U H S D L U H U
Spark plugs
(for petrol engine)
0 D N H V X U H W R L Q V W D O O Q H Z V S D U N S O X J V
of the correct heat range.
WARNING
Do not disconnect and inspect
spark plugs when the engine is
hot. You may burn yourself.
Cooling system
& K H F N W K H F R R O L Q J V \ V W H P S D U W V V X F K
D V U D G L D W R U F R R O D Q W U H V H U Y R L U K R V H V
D Q G F R Q Q H F W L R Q V I R U O H D N D J H D Q G
G D P D J H 5 H S O D F H D Q \ G D P D J H G
S D U W V
Engine coolant
7 K H F R R O D Q W V K R X O G E H F K D Q J H G D W
W K H L Q W H U Y D O V V S H F L I L H G L Q W K H P D L Q W H-
Q D Q F H V F K H G X O H
Manual transmission fluid
(if equipped)
, Q V S H F W W K H P D Q X D O W U D Q V P L V V L R Q I O X L G
D F F R U G L Q J W R W K H P D L Q W H Q D Q F H V F K H G-
ule.
Automated manual
transmission fluid (if equipped)
, Q V S H F W W K H $ X W R P D W H G P D Q X D O W U D Q V-
P L V V L R Q I O X L G D F F R U G L Q J W R W K H P D L Q W H-
Q D Q F H V F K H G X O H
NOTICE
The use of non-specified fluid
(even marked as compatible with
genuine) could result in shift qual-
ity deterioration and vibrations,
eventually, the transmission fail-
ure.
Use only specified Automated
manual transmission fluid. (Refer
to “Recommended lubricants and
capacities” in chapter 2.)
Page 446 of 486
8-50
Maintenance
& R Q V X O W D + < 8 1 ' $ , D X W K R U L V H G U H-
S D L U H U W R U H S O D F H P R V W Y H K L F O H O L J K W
E X O E V , W L V G L I I L F X O W W R U H S O D F H Y H K L F O H
O L J K W E X O E V E H F D X V H R W K H U S D U W V R I W K H
Y H K L F O H P X V W E H U H P R Y H G E H I R U H \ R X
F D Q J H W W R W K H E X O E 7 K L V L V H V S H F L D O O \
W U X H I R U U H P R Y L Q J W K H K H D G O L J K W D V-
V H P E O \ W R J H W W R W K H E X O E V
5 H P R Y L Q J L Q V W D O O L Q J W K H K H D G O L J K W D V-
V H P E O \ F D Q U H V X O W L Q G D P D J H W R W K H
vehicle.
WARNING
Prior to replacing a light, depress
the foot brake, move the shift lever
into the N (Neutral, for Automated
manual transmission vehicle) or
neutral (for manual transmission
vehicle), apply the parking brake,
place the ignition switch in the
LOCK/OFF position, and take the
key with you when leaving the ve-
hicle to avoid sudden movement
of the vehicle and to prevent pos-
sible electric shock.
Be aware the bulbs may be hot and
may burn your fingers.
NOTICE
Be sure to replace the burned-out
bulb with one of the same wattage
rating. Otherwise, it may cause
damage to the fuse or electric wir-
ing system.
i Information
The headlight and tail lamp lenses
could appear frosty if the vehicle is
washed after driving or the vehicle is
driven at night in wet weather. This
condition is caused by temperature dif-
ference between the lamp inside and
outside and, it does not indicate a
problem with your vehicle. When
moisture condenses in the lamp, it will
be removed after driving with the
headlight on. The removable level may
differ depending on lamp size, lamp
position and environmental condition.
However, if moisture is not removed,
we recommend that your vehicle is in-
spected by a HYUNDAI authorised re-
pairer.
i Information (For Europe)
Traffic Change
The low beam light distribution is
asymmetric. If you go abroad to a
country with opposite traffic direction,
this asymmetric part will dazzle on-
coming car driver. To prevent dazzle,
ECE regulation demand several tech-
nical solutions (ex. automatic change
system, adhesive sheet, down aiming).
These headlights are designed not to
dazzle opposite drivers. So, you need
not change your headlights in a coun-
try with opposite traffic direction.
LIGHT BULBS
Page 474 of 486
I-2
Index
A
Accessing your vehicle .......................................................................................... 5-4
Remote key ........................................................................................................ 5-4
Remote key precautions ..................................................................................... 5-6
Smart key ............................................................................................................ 5-7
Smart key precautions ...................................................................................... 5-11
Immobiliser system .......................................................................................... 5-12
Air bag - supplemental restraint system .............................................................. 3-40
Where are the air bags? .................................................................................... 3-42
How does the air bags system operate? ............................................................ 3-47
What to expect after an air bag inflates ............................................................ 3-50
Why didn’t my air bag go off in a collision? ................................................... 3-52
SRS Care .......................................................................................................... 3-57
Additional safety precautions .......................................................................... 3-58
Air bag warning labels ..................................................................................... 3-58
Air cleaner ........................................................................................................... 8-19
Filter replacement ............................................................................................. 8-19
Air conditioner compressor label......................................................................... 2-16
Air conditioning system ....................................................................................... 2-11
Appearance care................................................................................................... 8-63
Exterior care ..................................................................................................... 8-63
Interior care ...................................................................................................... 8-69
Audio (Without Touch Screen) ............................................................................ 5-97
System layout – control panel .......................................................................... 5-97
System layout – steering wheel remote control ............................................. 5-101
Turning the system on or off .......................................................................... 5-103
Turning the display on or off .......................................................................... 5-104
Getting to know the basic operations ............................................................. 5-104
Automated manual transmission (AMT) ............................................................. 6-18
Automated Manual Transmission (AMT) operation ........................................ 6-19
Features of the Automated Manual Transmission (AMT) .............................. 6-19
LCD display for transmission temperature and warning message ................... 6-23
Transmission ranges ......................................................................................... 6-28
Parking ............................................................................................................. 6-31
Good driving practices .................................................................................... 6-31