2019 TOYOTA TACOMA power steering fluid

5017-2. Maintenance
7
Maintenance and care
General maintenance
Listed below are the general maintenance items that should be
performed at the intervals specified in the “Owner’s Warranty
Information Booklet” or “Own er’s Manual Supplement/Sched-
uled Maintenance Guide”. It is recommended that any problem
you notice should be brought to the attention of your Toyota
dealer or qualified s ervice shop for advice.
Engine compartment
ItemsCheck points
BatteryCheck the connections. (P. 518)
Brake fluidIs the brake fluid at the correct level? ( P. 515)
Engine coolantIs the engine coolant at the correct level? (P. 513)
Engine oilIs the engine oil at the correct level? ( P. 511)
Exhaust systemThere should not be any fumes or strange sounds.
Power steering fluidIs the power steering fluid at correct level?
(P. 516)
Radiator/condenserThe radiator and condenser should be free from for-
eign objects. ( P. 515)
Washer fluidIs there sufficient washer fluid? (P. 520)

5057-3. Do-it-yourself maintenance
7
Maintenance and care
Do-it-yourself ser vice precautions
If you perform maintenance by yourself, be sure to follow the
correct procedure as given in these sections.
ItemsParts and tools
Battery condition
(  P. 518)• Warm water• Baking soda• Grease
• Conventional wrench (for terminal clamp bolts)
Brake fluid level
( P. 515)• FMVSS No.116 DOT 3 or SAE J1703 brake fluid
• Rag or paper towel
• Funnel (used only for adding brake fluid)
Engine coolant
level ( P. 513)
• “Toyota Super Long Life Coolant” or a similar high
quality ethylene glycol-based non-silicate, non-
amine, non-nitrite and non-borate coolant with long-
life hybrid organic acid technology
For the U.S.A.:
“Toyota Super Long Life Coolant” is pre-mixed with
50% coolant and 50% deionized water.
For Canada:
“Toyota Super Long Life Coolant” is pre-mixed with
55% coolant and 45% deionized water.
• Funnel (used only for adding coolant)
Engine oil level
(  P. 511)• “Toyota Genuine Motor Oil” or equivalent
• Rag or paper towel
• Funnel (used only for adding engine oil)
Fuses
( P. 542)• Fuse with same amperage rating as original
Light bulbs
( P. 545)
• Bulb with same number and wattage rating as origi-
nal
• Phillips-head screwdriver
• Flathead screwdriver• Wrench
Power steering
fluid level

(
P. 516)
• Automatic transmission fluid DEXRON® II or III
• Rag or paper towel
• Funnel (used only for adding power steering fluid)
Radiator and
condenser
(
P. 515)

Tire inflation
pressure
(  P. 530)• Tire pressure gauge
• Compressed air source
Washer fluid
( P. 520)• Water or washer fluid containing antifreeze (for win-
ter use)
• Funnel (used only for adding water or washer fluid)

5097-3. Do-it-yourself maintenance
7
Maintenance and care
Engine compartment
2TR-FE engine
Washer fluid tank (P. 520)
Radiator cap
Engine coolant reservoir ( P. 513)
Engine oil filler cap ( P. 512)
Power steering fluid reservoir ( P. 516) Engine oil level dipstick
( P. 5 1 1 )
Brake fluid reservoir ( P. 515)
Fuse box ( P. 542)
Battery ( P. 518)
Condenser ( P. 515)
Radiator ( P. 515)1
2
3
4
5
6
7
8
9
10
11

5107-3. Do-it-yourself maintenance
2GR-FKS engine
Washer fluid tank (P. 520)
Power steering fluid reservoir ( P. 516)
Radiator cap
Engine oil level dipstick ( P. 5 11 )
Engine coolant reservoir ( P. 513) Engine oil filler cap (
P. 512)
Brake fluid reservoir ( P. 515)
Fuse box ( P. 542)
Battery ( P. 518)
Condenser ( P. 515)
Radiator ( P. 515)1
2
3
4
5
6
7
8
9
10
11

5167-3. Do-it-yourself maintenance
■Brake fluid can absorb moisture from the air
Excess moisture in the brake fluid can cause a dangerous loss o f braking effi-
ciency. Use only newly opened brake fluid.
■
Fluid level
The fluid level should be within the appropriate range.
2TR-FE engine
Full (when cold)
Add fluid (when cold)
Full (when hot)
Add fluid (when hot)
Hot: Vehicle has been driven around 50 mph (80 km/h) for 20 minutes, or slightly longer in frigid temperatures. (Fluid
temperature, 104°F - 175°F [40°C - 80°C])
Cold: Engine has not been run for about 5 hours. (Room tem- perature, 32°F - 104°F [0°C - 40°C])
WARNING
■ When filling the reservoir
Take care as brake fluid can harm your hands and eyes and damage
painted surfaces.
If fluid gets on your hands or in your eyes, flush the affected area with clean
water immediately.
If you still experience discomfort, see a doctor.
NOTICE
■ If the fluid level is low or high
It is normal for the brake fluid level to go down slightly as the brake pads
wear out or when the fluid level in the accumulator is high.
If the reservoir needs frequent refilling, there may be a serious problem.
Power steering fluid
1
2
3
4

5177-3. Do-it-yourself maintenance
7
Maintenance and care
2GR-FKS engine
Full (when cold)
Add fluid (when cold)
Full (when hot)
Add fluid (when hot)
Hot: Vehicle has been driven around 50 mph (80 km/h) for 20 minutes, or slightly longer in frigid temperatures. (Fluid
temperature, 140°F - 175°F [60°C - 80°C])
Cold: Engine has not been run for about 5 hours. (Room tem- perature, 50°F - 85°F [10°C - 30°C])
■Checking the fluid level
Make sure to check the fluid type and prepare the necessary items.
Clean all dirt off the reservoir.
Remove the cap by turning it counterclockwise.
Wipe the dipstick clean.
Reinstall the cap and remove it again.
Check the fluid level.
1
2
3
4
Fluid type Automatic transmission fluid DEXRON® II or III
Items Rag or paper, clean funnel (only for adding fluid)
WARNING
■Checking the fluid level
Take care, as the reservoir may be hot.
NOTICE
■When adding fluid
Avoid overfilling, or the power steering may be damaged.
■ After replacing the reservoir cap
Check the steering box case, vane pump and hose connections for leaks or
damage.
1
2
3
4
5

6369-1. Specifications
*: Your Toyota vehicle is filled with “Toyota Genuine Transfer Gear oil LF” at
the factory. Use Toyota approved “Toyota Genuine Transfer Gear oil LF” or
an equivalent of matching quality to satisfy the above specific ation. Please
contact your Toyota dealer for further details.
*1: Minimum pedal clearance when depressed with a force of 110 lbf (490 N,
50 kgf) with the engine running.
*2: Parking brake lever travel when pulled up with a force of 44.9 lbf (200 N,
20.4 kgf).
Transfer (4WD models)
Oil capacity 1.1 qt. (1.0 L, 0.9 Imp.qt.)
Oil type*Toyota Genuine Transfer gear oil LF or
equivalent
Recommended oil viscosity SAE 75W
Brakes
Pedal clearance*1
Vehicles without off-road package:
4.4 in. (111 mm) Min.
Vehicles with off-road package:
3.6 in. (91 mm) Min.
Pedal free play0.04  0.24 in. (1  6 mm)
Brake pad wear limit 0.04 in. (1.0 mm)
Brake lining wear limit0.04 in. (1.0 mm)
Parking brake lever travel*25 — 7 clicks
Fluid type FMVSS No. 116 DOT 3 or SAE J1703
Chassis lubrication
Propeller shaft SpiderLithium base chassis grease, NLGI No.2
Steering
Free playLess than 1.2 in. (30 mm)
Power steering fluid typeAutomatic transmission fluid DEXRON® II or III

690Alphabetical index
Engine switch (ignition switch)............. 193, 196
Engine switch light
(ignition switch light) ............ 441
Event data recorder (EDR) ........ 10
Flat tire...................................... 597
Floor mats .................................. 24
Fluid Automatic transmission......... 635
Brake .................................... 636
Power steering ...................... 636
Washer ................................. 520
Fog lights ................................. 220 Replacing light bulbs............. 551
Switch ................................... 220
Wattage ................................ 639
Four-wheel drive system ........ 299
Front passenger occupant
classification system .............. 45
Front personal lights ............... 442
Front seats ............................... 131
Adjustment ............................ 131
Cleaning................................ 496
Correct driving posture ........... 26
Head restraints ..................... 136
Seat heaters ......................... 439
Front side marker lights Light switch ........................... 211
Replacing light bulbs............. 549
Wattage ................................ 639
Front turn signal lights Replacing light bulbs............. 550
Turn signal lever ................... 209
Wattage ................................ 639 Fuel ........................................... 630
Capacity................................ 630
Fuel gauge.............................. 90
Fuel pump shut off system ... 567
Information............................ 640
Refueling .............................. 224
Type...................................... 630
Warning light......................... 569
Warning message................. 579
Fuel consumption
Average fuel consumption ................. 95, 101
Current fuel
consumption ................. 95, 101
Fuel filler door ......................... 226
Fuel pump shut off system..... 567
Fuses ........................................ 542
Garage door opener ................ 479
Gas station information .......... 700
Gauges ....................................... 90
Glove box ................................. 445
Grocery bag hooks.................. 460
F
G