2019 CITROEN BERLINGO VAN engine coolant

11
Instrument panel
Speedometer
Analogue speedometer (mph or km/h).
Indicators with LCD text or
matrix instrument panel
1.Fuel gauge.
2. Engine coolant fluid temperature gauge.
Display screen
When travelling abroad, you may have
to change the distance units: the display
of road speed must be in the official
units (miles or km) for the country. The
change of units is done via the screen
configuration menu, with the vehicle
stationary.
With LCD symbols instrument panel
1.Engine coolant fluid temperature gauge.
2. Speed limiter or cruise control settings.
3. Digital speedometer (mph or km/h).
4. Gear efficiency indicator.
Gear with an automatic gearbox.
5. Fuel gauge.
6. Engine oil level indicator.
7. Ser vice indicator, then total distance
recorder (miles or km).
These functions are displayed
successively on switching on the ignition.
8. Trip distance recorder (miles or km).
1
Instruments

15
90°CMaximum coolant
temperature Fixed (warning lamp or
LED) and needle in the
red zone (depending
on version). The temperature of the cooling
system is too high.
Carry out (1), then wait until the engine has cooled
down before topping up the coolant, if necessary. If
the problem persists, carry out (2).
Battery charge Fixed. The battery charging circuit has
a fault (dirty or loose terminals,
slack or cut alternator belt, etc.). Clean and retighten the terminals. If the warning lamp
does not go off when the engine is started, carry out
(2).
Power steering Fixed. The power steering has a fault. Drive carefully at moderate speed, then carry out (3).
Seat belt not
fastened/
unfastened Fixed or flashing
accompanied by an
audible signal. A seat belt has not been
fastened or has been unfastened
(depending on version).
Door open Fixed, associated with
a message identifying
the access.
An audible signal
supplements the alert
if the speed is higher
than 6
mph (10 km/h).A door, the boot, the tailgate or
the tailgate screen is still open
(depending on version).
Close the access.
If your vehicle is equipped with a right-hand side-
hinged door, its opening will not
be indicated by this
warning lamp.
Warning/indicator lamp
StateCause Actions/Observations
Electric parking
brake Fixed.
The electric parking brake is
applied.
1
Instruments

29
F Press this button.
The ser vice information is displayed for a few
seconds, then disappears.
Instrument panel display screen
When stationary, use the left-hand dial on
the steering wheel or the " SET" button in
the instrument panel to navigate through the
menus to configure certain vehicle settings.
Operation of the dial:
-

P
ress: go to the Main menu , confirm the
selection.
-

R
otate (other than in a menu): scroll through
the list of active functions available.
-

R
otate (in a menu): move up or down in the
menu.
Distance recorders
The total and trip distances are displayed for
thirty seconds when the ignition is switched off,
when the driver's door is opened and when the
vehicle is locked or unlocked.
Total distance recorder
It measures the total distance travelled by the
vehicle since its first registration.
Trip distance recorder
It measures the distance travelled since it was
reset by the driver. Resetting the trip recorder
F

W
ith the ignition on, press the button until
dashes appear.
Engine coolant temperature
With the engine running, when the needle or
bar graph (depending on version) is:
-

i
n zone A , the temperature of the engine
coolant is correct,
1
Instruments

30
- in zone B, the temperature of the engine
coolant is too high; the maximum
temperature and central STOP warning
lamps come on, accompanied by an audible
signal and a warning message.
You must stop as soon as it is safe to do so.
Wait a few minutes before switching off the
engine.
Contact a CITROËN dealer or a qualified
workshop.
Checking
After driving for a few minutes, the temperature
and pressure in the cooling system increase.
To top up the level:
F

w
ait at least one hour for the engine to cool,
F

u
nscrew the cap by two turns to allow the
pressure to drop,
F

w
hen the pressure has dropped, remove the
cap,
F

t
op up the level to the "MA X" mark.
For more information on Checking levels ,
refer to the corresponding section.
Be aware of the risk of scalding when
topping up the coolant. Do not fill above
the maximum level (indicated on the
reservoir).
Engine oil level indicator
On versions fitted with an electric oil level
indicator, the state of the engine oil level is
displayed in the instrument panel for a few
seconds when the ignition is switched on, at
the same time as the ser vicing information.The level read will only be correct if
the vehicle is on level ground and the
engine has been stopped for more than
30


minutes.
Oil level correct
This is indicated by a message in the
instrument panel.
Low oil level
If the low oil level is confirmed by a check using
the dipstick, the level must be topped up to
avoid damage to the engine.
This is indicated by a message in the
instrument panel.
Oil level indicator fault
Dipstick
To locate the dipstick and the oil filler
cap for the Diesel engine , refer to the
corresponding section.
A = maximum; never
exceed this level.
B = minimum; top up
the level via the oil filler
hole, with the oil type
that is suitable for your
engine.
This is indicated by a message in the
instrument panel. Contact a CITROËN dealer
or a qualified workshop.
Instruments

121
Side wind
F Take into account the increased sensitivity to wind.
Cooling
Towing a trailer on a slope increases the
temperature of the coolant.
As the fan is electrically controlled, its cooling
capacity is not dependent on the engine speed.
F

T
o lower the engine speed, reduce your
speed.
The maximum towable load on an incline
depends on the gradient and the exterior
temperature.
In all cases, keep a check on the coolant
temperature.
F

I
f this warning lamp and the
STOP warning lamp come on,
stop the vehicle and switch off
the engine as soon as possible.
New vehicle
Do not pull a trailer before having driven at least
approximately 620


miles (1,000

kilometres).
Braking
Towing a trailer increases the braking distance.
To avoid overheating of the brakes, the use of
engine braking is recommended.
Ty r e s
F Check the tyre pressures of the towing vehicle and of the trailer, observing the
recommended pressures.
Lighting
F Check the electrical lighting and signalling on the trailer and the headlamp beam height
of your vehicle.
For more information on Headlamp
beam height adjustment , refer to the
corresponding section.
Certain driving or manoeuvring aid
functions are automatically disabled if an
approved towing system is used.
If the exterior temperature is high, it is
recommended that the engine be allowed
to idle for 1 to 2
minutes after the vehicle
comes to a stop, to facilitate its cooling.
Starting/switching off the
engine
Starting
The parking brake must be applied.
F

W

ith a manual gearbox, shift the gear lever
into neutral, fully depress the clutch pedal
and keep the pedal down until the engine
runs.
F

W

ith an automatic gearbox, place the
selector in position P and fully depress the
brake pedal.
Using the conventional key/the
remote control key
1. Stop position.
2. Ignition on position.
3. Starting position.
6
Driving

187
Opening
F Open the left-hand front door.
F
P
ull the release lever, located at the bottom
of the door aperture, towards you.
F

L
ift the safety catch and raise the bonnet. F

U
nclip the stay
from its housing
and place it in the
support slot to hold
the bonnet open.
Closing
F Take the stay out of the support slot.
F C lip the stay in its housing.
F

L
ower the bonnet and release it near the
end of its travel.
F

P
ull on the bonnet to check that it is fully
latched.
Because of the presence of electrical
equipment under the bonnet, it is
recommended that exposure to water
(rain, washing, etc.) be limited.
Engines
Petrol
Diesel
These engines are examples provided as a
guide.
The locations of the dipstick and engine oil filler
cap may vary.
1. Screenwash fluid reservoir.
2. Engine coolant reservoir.
3. Brake fluid reser voir.
4. Battery.
5. Fusebox.
6. A i r f i l t e r.
7. Engine oil dipstick.
8. Engine oil filler cap.
Checking levels
Check all of these levels regularly, in line with
the manufacturer's service schedule. Top them
up if necessary, unless other wise indicated.
If a level drops significantly, have the
corresponding system checked by a CITROËN
dealer or a qualified workshop.The Diesel circuit is under very high
pressure.
All work on this circuit must be carried out
only by a CITROËN dealer or a qualified
workshop.
The liquid must comply with the
manufacturer's recommendations and with
the vehicle's engine.
7
Practical information

189
After topping up the oil, the check when
switching on the ignition with the oil level
indicator in the instrument panel is not
valid during the 30 minutes after topping
up.
F

U
nscrew the oil filler cap to access the filler
opening.
F

A
dd oil in small quantities, avoiding any
spills on engine components (risk of fire).
F

W
ait a few minutes before checking the
level again using the dipstick.
F

A
dd more oil if necessary.
F

A
fter checking the level, carefully refit the oil
filler cap and the dipstick in its tube.
Brake fluid level
The brake fluid level should be close
to the "MA X" mark. If it is not, check
the brake pad wear.
Changing the fluid
Refer to the manufacturer's service schedule
for details of the inter val for this operation.
Fluid specification
This fluid must conform to the manufacturer's
recommendations.
Coolant level
Check the coolant level regularly.
It is normal to top up this fluid
between two services.
To avoid the risk of scalding when you need to
top up in an emergency, place a cloth around the
cap and unscrew the cap by two turns to allow
the pressure to drop.
Once the pressure has dropped, remove the cap
and top up to the required level.
The cooling fan may star t after
switching off the engine: take care
with articles and clothing that might be
caught by the fan blades.
Screenwash fluid level
Top up to the required level when
necessary.
Fluid specification
This fluid must conform to the manufacturer's
recommendations.
Engine oil change
In order to maintain the reliability of the engine
and emissions control system, never use
additives in the engine oil. The check and top-up must only be done with
the engine cold.
A low coolant level presents a risk of serious
damage to your engine.
The coolant level should be close to the "MA X"
mark but should never exceed it.
If the level is close to or below the "MIN" mark,
it is essential to top up.
When the engine is hot, the temperature of this
fluid is regulated by the fan.
In addition, as the cooling system is pressurised,
wait at least one hour after switching off the
engine before carrying out any work.
Tank capacity:
-
5 .3 litres for the "very cold climate" versions.
- 2 .2 litres for other versions.
Fluid specification
The screenwash fluid must be topped up with a
ready for use mix.
7
Practical information

228
DDAB (Digital Audio Broadcasting) - Digital radio ............................................................. 6-
7,
8,
24
D
ate (setting)

.................................................. 36,

17,


32
D

aytime running lamps

...............................81,

83,


2
07
Daytime running lamps, LED


..................................207
Deactivating the passenger airbag


..........104,

10
7-108
Deactivation of DSC (ESC)

.......................................95
D

eadlocking

................................................................ 41
Defrosting
............................................................ 54,


74
D

emisting

.................................................................... 74
Demisting, rear


.................................................... 53,

75
D

emisting, rear screen

........................................ 53,

75
D

iesel
................................................................ 222

-225
Dimensions


............................................................... 218
Dipstick


....................................................... 30,

18
8 -189
Direction indicators


.............................82
-
8
3,

20
8,

20
9
Display, head-up ............................................... 13 8 -13 9
Display screen, instrument panel


.....................29,

13
5
Doors, side-hinged


............................................... 4 0
-41
D

river’s attention warning .......................................165
Driving abroad


........................................................... 82
Dynamic stability control (DSC)


....................20,

9
4
-98
EEarth point, remote ................................................... 187
Economy mode ........................................................ 185
Electronic brake force distribution (EBFD)
...............94
Electronic stability control (ESC)

............25,


9
4,

9
6
-98
E

mergency braking assistance (EBA) ......................94
Emergency call


..................................................... 92
-
9
3
Emissions control system, SCR
.............................192
Energy economy mode


........................................... 185
Engine
............................................................... 22

0-225
Engine, Diesel


........................... 18,

17
9,

19
6,

222
-225
Engine, petrol .................................... 179,

18
7,

22
0-221
Engine compartment
................................................ 18

7
Engines


............................................................. 219 -225
Engine self-diagnosis
................................................. 17
Environment ......................................................... 44, 78
E SC (electronic stability control) ..............................94
Extended traffic sign recognition
............................. 14

2
FFatigue detection ..................................................... 165
Filling the AdBlue® tank ........................................... 193
Filling the fuel tank ........................................... 179 -181
Filter, air
................................................................... 19

0
Filter, Diesel fuel


....................................................... 187
Filter, oil


.................................................................... 19 0
Filter, particle


.............................................. 19,

19
0 -191
Filter, passenger compartment


............................... 19 0
Fitting a wheel

.................................................. 20

2-204
Fitting roof bars ................................................. 185 -18 6
Fittings, interior
.................................................... 63,


67
F

lap, fuel filler
................................................... 18

0 -181
Foglamp, rear


.............................................. 25,

81,


20
9
Foglamps, front


....................................... 81,

8
6
-87,


20
8
Foglamps, rear
........................................................... 81
F

olding the rear seats

..........................................58
-6
0
Frequency (radio)
................................................. 2

3
-24
F

uel


........................................................................\
... 179
Fuel tank
.................................................................. 18

0
Fusebox, engine compartment


................................ 213
Fuses


................................................................. 211-213
GGauge, fuel ....................................................... 18 0 -181
Gearbox, automatic ........................... 12
1,
13 0 -137,
19 1
Gearbox, electronic


.......................................... 13 5 -137
Gearbox, manual
....................... 13

0 -131,

13
5 -137,

19
1
Gear efficiency indicator


......................................... 13 5
Gear lever, automatic gearbox .........................131-13 5
Gear lever, manual gearbox .............................13 0 -131
Glove box
................................................................... 63
G

. P. S .

........................................................................\
.. 14
HHazard warning lamps ........................................70, 93
H azard warning lamps, automatic operation ...........93
Headlamp adjustment


............................................... 87
Headlamp beam height


............................................. 87
Headlamps, automatic dipping
............. 2

7,

8
4
-86,


16
4
Headlamps, automatic illumination


.....................83
-8

4
Headlamps, dipped beam


............................27,

81,


2
07
Headlamps, halogen
............................................... 20

5
Headlamps, main beam
............................... 2

7,

81,


2
07
Head restraints


.......................................................... 57
Head restraints, front ................................................. 62
Head restraints, rear


............................................ 58
-5

9
Head-up display


............................................... 13 8 -13 9
Heating
....................................................... 7

0
-71,


7
5
-
79
Heating, additional


......................................... 49,

7
6
-
78
Heating, programmable


.................................49,

7
6
-
78
Hill Assist Descent Control (HADC)
............26,

9
8 -10 0
Hill start assist


......................................................... 13 0
Horn
........................................................................\
... 93
IIdentification, vehicle............................................... 226
Ignition ........................................................ 124 -125,
29
I
gnition on
................................................................. 12

5
Immobiliser, electronic


................................42,

45,


1
26
Indicator, AdBlue
® range ............................................ 31
Indicator, coolant temperature ............................. 28-3
0
Indicator, engine oil level


........................................... 30
Indicator lamps, operation


............................. 15
-

16,

81
I

ndicator lamps, status

............................................... 15
Indicators, direction


................................................... 82
Inflating tyres


............................................................ 191
Inflating tyres (using the kit)
............................. 197-19 9
Instrument panel


......................................................... 11
Internet browser


......................................................... 21
ISOFIX
............................................................... 11

5 -11 6
Alphabetical index