2018 Peugeot 301 gearbox

124
Removing a wheel
Parking the vehicle
* position P for the automatic gearbox
Park the vehicle where it does not block
traffic: the ground must be level, stable
and non-slippery.
Apply the parking brake, switch off the
ignition and engage first gear* so as to
block the wheels.
Check that the parking brake warning
lamp comes on fixed in the instrument
panel.
The occupants must get out of the vehicle
and wait where they are safe.
Make sure that the jack is correctly
positioned at one of the vehicle's jacking
points.
Incorrect use of the jack could cause the
vehicle to collapse.
Never go underneath a vehicle raised
using a jack; use an axle stand.
Do not use a jack other than the one
supplied by the manufacturer.
Wheel with hub cap
When removing the wheel
, first remove
the hub cap using the wheelbrace by
pulling at the valve aperture.
When refitting the wheel , after tightening
the wheel bolts, refit the hub cap, starting
by placing its aperture in line with the
valve and then pushing it into place all
round its edge with the palm of your hand.
List of operations
F Remove each wheel bolt cover using the tool 3 (alloy wheels).
F

L
oosen the bolts using wheelbrace 1 o n l y. F

P
lace the foot of jack 2 on the ground and
ensure that it is directly below the front
A or rear B jacking point provided on the
underbody, whichever is closest to the
wheel to be changed.
In the event of a breakdown

136
Versions equipped with Stop & Start are
fitted with a 12 V lead-acid battery of
specific technology and specification.
Its replacement should be carried out
only by a PEUGEOT dealer or a qualified
workshop.
If your vehicle has an automatic gearbox,
never try to start the engine by pushing
the vehicle.
Access to the battery Starting using another
battery
When your vehicle's battery is discharged, the
engine can be started using a backup battery
(external or from another vehicle) and jump
leads or a battery booster.
Never try to start the engine by connecting
a battery charger.
Never use a 24
V or higher battery
b o o s t e r.
Check beforehand that the backup
battery has a nominal voltage of 12
V and
a capacity at least equal to that of the
discharged battery.
The two vehicles must not be in contact
with each other.
Switch off all the electrical consumers
on both vehicles (audio system, wipers,
lighting, etc.).
Make sure that the jump leads are not
close to moving parts of the engine (fan,
belts, etc.).
Do not disconnect the (+) terminal while
the engine is running. F

S
tart the engine of the vehicle with the
good battery and leave it running for a few
minutes.
F

O
perate the starter on the broken down
vehicle and let the engine turn.
If the engine does not start straight away,
switch off the ignition and wait a few moments
before trying again.
The battery is located under the bonnet.
To gain access to it:
F

O

pen the bonnet using the interior release
lever, then the exterior safety catch.
F

S

ecure the bonnet stay.
F

R

emove the plastic cover on the (+)
terminal. The battery (-) terminal is not accessible. A
remote earth point is located on the engine.
F
L
ift the plastic cover on the (+) terminal, if
your vehicle has one.
F

C
onnect the red cable to the positive
terminal (+) of flat battery A (at the metal
elbow) then to the positive terminal (+) of
backup battery B or the booster.
F

C
onnect one end of the green or black
cable to the negative terminal (-) of backup
battery B or the booster (or an earth point
on the other vehicle).
F

C
onnect the other end of the green or black
cable to earth point C on the broken down
vehicle.
In the event of a breakdown

139
Towing the vehicle
Procedure for having your vehicle towed.
Access to the tools
General recommendations
Obser ve the legislation in force in your
c o u nt r y.
Ensure that the weight of the towing
vehicle is higher than that of the towed
vehicle.
The driver must remain at the wheel of
the towed vehicle and must have a valid
driving licence.
When towing a vehicle with all four
wheels on the ground, always use an
approved towing arm; rope and straps are
prohibited.
The towing vehicle must move off gently.
When the vehicle is towed with its engine
off, there is no longer braking and steering
assistance.
In the following cases, you must always
call on a professional recovery ser vice:
-
v
ehicle broken down on a motor way or
fast road,
-
f

our-wheel drive vehicle,
-

w
hen it is not possible to put the
gearbox into neutral, unlock the
steering, or release the parking brake,
-

t
owing with only two wheels on the
ground,
-

w
here there is no approved towbar
available.Towing your vehicle
F On the front bumper, unclip the cover by pressing on its left side.
The towing eye is installed in the boot under
t h e f l o o r.
To gain access to it:
F

O

pen the boot.
F

L

ift the floor and remove it.
F

R

emove the towing eye from the holder. F

S
crew the towing eye in fully, until it reaches
a stop.
F

I
nstall the towbar.With a manual gearbox, place the gear
lever into neutral.
With an automatic gearbox, place the gear
selector into position N .
Failure to follow this instruction may cause
damage to some components (braking,
powertrain, etc.) and the absence of
braking assistance when the engine is
restarted.
8
In the event of a breakdown

142
Petrol engines and towed loads
EnginePureTech 82V T i 115
Gearboxes Manual 5-speed
(BVM5) Manual 5-speed
(BVM5) Automatic 6-speed
( E AT 6)
Code EB2FEC5F
Model code: DD, etc. HMZ6NFP0
NFP6NFPT
Capacity (cm
3) 1,1 9 91,5 87
Max power: CEE standard (kW) 6085
Fuel Unleaded 91 RON to 98 RONUnleaded 91 RON to 98 RON
Braked trailer (within the GTW limit)
on a 10% or 12% gradient (kg) 450
750
Unbraked trailer (kg) 450580
Recommended nose or ball joint weight (kg)
or trailer nose weight 55
55
Technical data

143
Diesel engines and towed loads
EngineHDi 92BlueHDi 100
Gearboxes Manual 5-speed
(BVM5) Manual 5-speed
(BVM5)
Code DV6DTEDDV6TEDDV6FD
Model code: DD, etc. 9HJC9HP0BHY6
Capacity (cm
3) 1,5 6 01,5 6 0
Max power: CEE standard (kW) 6873
Fuel DieselDiesel
Braked trailer (within the GTW limit)
on a 10% or 12% gradient (kg) 750
750
Unbraked trailer (kg) 580580
Recommended nose or ball joint weight (kg)
or trailer nose weight 55
55
9
Technical data

EEarth point, remote .......................................11 3
Economy mode ............................................. 10
7
Electronic brake force distribution (EBFD) ......60 - 61Emergency braking assistance (EBA) ............60
Emergency call ......................................... 58-59
Emissions control
...............................

.............12
Emissions control system, SCR
.....................16
Energy economy mode
................................. 10

7
Engine


........................................................ 11 -12
Engine, Diesel


......................... 12, 102, 118, 143
Engine, petrol
...............................

.102, 113, 142
Engine compartment
.................................... 11

3
Engine failure


............................................. 11 -12
Engine oil pressure


......................................... 11
Engines


.................................................. 141-143
Engine self-diagnostics


..................................12
Environment


.................................................... 31
ESC (electronic stability control)

....................60
FFilling the AdBlue tank .................................. 10 5
Filling the fuel tank ................................ 10 0 -102
Filter, air


........................................................ 11 6
Filter, Diesel fuel


........................................... 113
Filter, oil
................

......................................... 11 6
Filter, particle


......................................... 115 -11 6
Filter, passenger compartment


.....................11 6
Fitting a wheel
........................................ 124 -126
Fitting roof bars


............................................. 11 0
Fittings, interior
............................................... 48
F

lap, fuel filler

......................................... 10 0 -101
Fluid, engine coolant


....................................... 11
Foglamp, rear


............................... 17, 51-52, 130
Foglamps, front


............................ 18, 51-52, 129
Frequency (radio)


...................................... 24-25
Fuel ................................................................ 102
Fuel tank ........................................................ 101
Fusebox, dashboard


...............131-132, 13 4 -13 5
Fusebox, engine compartment .......131-132, 13 4 -13 5Fuses ....................................... 13 1-132, 13 4 -13 5
GGauge, fuel.................................................... 10 0
Gearbox, automatic .............84- 87, 89, 117, 136
Gearbox, electronic


.................................. 88-90
Gearbox, manual


..................84, 88 - 89, 89, 117
Gear lever, automatic gearbox


.................85 - 87
Gear lever, manual gearbox


...........................84
Gear shift indicator ~ Gear efficiency indicator


....................................... 88
Glove box
........................................................ 48
GPS


................................................................. 14
Guide-me-home lighting


.................................53
HHazard warning lamps ....................................58
Hazard warning lamps, automatic operation ..58
Headlamp adjustment


..................................... 54
Headlamps, automatic illumination


................53
Headlamps, dipped beam


.................18, 51, 128
Headlamps, halogen


..................................... 127
Headlamps, main beam


....................18, 51, 128
Head restraints, front
...................................... 38
Head restraints, rear
....................................... 39
Heating
............................... 4

1- 42, 44- 45, 47- 48
Horn ................................................................. 58
I
Ignition ....................................................... 83, 31
Immobiliser, electronic ..............................31, 81
Indicator lamps, operation
................................ 9
I

ndicators, direction

................................53, 127
Inflating tyres ................................................ 145
Inflating tyres (using the kit) ................... 11
8 -12 0
Input, auxiliary


............................................... 7, 5
Instrument panel


............................................... 8
Internet browser
.............................................. 18
I

SOFIX

............................................................ 76
Isofix mountings


........................................ 75, 77
JJack ............................................122-123, 26, 10
Jump starting ................................................ 13 6
KKey ............................................................ 17, 29
Key with remote control ......................2
9, 31, 81
Kit, hands-free
........................... 2

8 -29, 15 -16, 9
Kit, temporary puncture repair


...............11 8 -12 0
LLabels, identification ..................................... 145
Lamps, front .................................................. 127
Level, brake fluid
........................................... 115
Level, Diesel additive


.................................... 115
Level, engine coolant


.................................... 115
Level, engine oil
............................................ 114
Level, screenwash fluid

................................11

5
Levels and checks

..............................
...113 -115
Lighting, guide-me home


................................53
Lighting, interior
...............................

.........55-56
Loading


......................................................... 11 0
Alphabetical index