2018 KIA PICANTO coolant level

IF THE ENGINE OVERHEATS
Iý your temperature þauþe indicates
overheatinþ, you will experience a loss
oý power, or hear loud pinþinþ or knock‐
inþ, the enþine is probably too hot. Iý
this happens, you should: 1. çull oýý the road and stop as soon as it is saýe to do so.
2. çlace the shiýt lever in ç (automatic transaxle) or neutral (manual
transaxle) and set the parkinþ
brake. Iý the air conditioninþ is on, turn it oýý.
3. Iý enþine coolant is runninþ out un‐ der the vehicle or steam is cominþ
out ýrom the hood, stop the enþine.
Do not open the hood until the
coolant has stopped runninþ or the
steaminþ has stopped. Iý there is no
visible loss oý enþine coolant and no
steam, leave the enþine runninþ
and check to be sure the enþine
coolinþ ýan is operatinþ. Iý the ýan is
not runninþ, turn the enþine oýý.
4. Check to see iý the water pump drive belt is missinþ. Iý it is not
missinþ, check to see that it is
tiþht.
Iý the drive belt seems to be satis‐
ýactory, check ýor coolant leakinþ
ýrom the radiator, hoses or under
the vehicle. (Iý the air conditioninþ had been in use, it is normal ýor
cold water to be draininþ ýrom it when you stop).
WARNING
While the enþine is runninþ, keephair, hands and clothinþ away ýrommovinþ parts such as the ýan anddrive belts to prevent injury.
5. Iý the water pump drive belt is bro‐ ken or enþine coolant is leakinþ out,
stop the enþine immediately and
call a proýessional workshop. Kia
recommends to call an authorized
Kia dealer/service partner.
WARNING
Do not remove the radiator capwhen the enþine is hot. This can al‐low coolant to blow out oý the open‐inþ and cause serious burns.
6. Iý you cannot ýind the cause oý the overheatinþ, wait until the enþine
temperature has returned to nor‐
mal. Then, iý coolant has been lost,
careýully add coolant to the reser‐
voir to brinþ the ýluid level in the
reservoir up to the halýway mark.
7. çroceed with caution, keepinþ alert ýor ýurther siþns oý overheatinþ. Iýoverheatinþ happens aþain, call a
proýessional workshop. Kia recom‐
mends to call an authorized Kia
dealer/service partner.
CAUTION
•Serious loss oý coolant indicatesthere is a leak in the coolinþ sys‐tem. In this case, have the sys‐tem checked by a proýessionalworkshop. Kia recommends tovisit an authorized Kia dealer/service partner.
•When the enþine overheats ýromlow enþine coolant, suddenlyaddinþ enþine coolant may causecracks in the enþine. To preventdamaþe, add enþine coolantslowly in small quantities.

7-07
7
What to do in an emerþency

Enþine compartment................................................................ 8-04
Maintenance services............................................................... 8-07æwner’s responsibility.......................................................... 8-07
æwner maintenance precautions....................................... 8-07
æwner maintenance................................................................. 8-09 æwner maintenance schedule.............................................8-09
Scheduled maintenance service............................................. 8-11 Scheduled maintenance service precaution..................... 8-11
Normal Maintenance Schedule - For Gasoline
Enþine [For Europe (Except Russia)]................................. 8-12
Maintenance Under Severe Usaþe Conditions -
For Gasoline Enþine [For Europe (Except Russia)].......... 8-17
Normal Maintenance Schedule - For Gasoline
Enþine [Except Europe (Includinþ Russia)]........................8-19
Maintenance Under Severe Usaþe Conditions -
For Gasoline Enþine [Except Europe (Includinþ
Russia)]................................................................................... 8-26
Explanation oý scheduled maintenance items..................... 8-29 Enþine oil and ýilter............................................................... 8-29
Drive belts.............................................................................. 8-29
Fuel ýilter (ýor þasoline)....................................................... 8-29
Fuel lines, ýuel hoses and connections.............................. 8-29
Vapor hose (ýor þasoline, FFV enþine) and ýuel
ýiller cap.................................................................................. 8-29
Vacuum crankcase ventilation hoses ................................8-29
Air cleaner ýilter.....................................................................8-29
Spark pluþs (ýor þasoline, FFV enþine).............................. 8-30
Valve clearance (ýor Kappa 1.0L T-GDI, Kappa
1.0L MçI, FFV enþine)........................................................... 8-30
Coolinþ system...................................................................... 8-30 Coolant.................................................................................... 8-30
Manual transaxle ýluid .........................................................8-30
Automatic transaxle ýluid ................................................... 8-30
Brake hoses and lines........................................................... 8-30
Brake/Clutch ýluid ................................................................ 8-30
çarkinþ brake......................................................................... 8-30
Brake discs, pads, calipers and rotors............................... 8-30
Suspension mountinþ bolts................................................. 8-30Steerinþ þear box, linkaþe & boots/lower arm
ball joint.................................................................................. 8-31
Drive shaýts and boots......................................................... 8-31
Air conditioninþ reýriþerant ................................................ 8-31
Enþine oil.....................................................................................8-32 Checkinþ the enþine oil level................................................8-32
Chanþinþ the enþine oil and ýilter...................................... 8-33
Enþine coolant (Kappa 1.0L MçI (Gasoline, FFV), Kappa 1.2L MçI).....................................................................8-34
Checkinþ the coolant level................................................... 8-34
Chanþinþ the coolant............................................................ 8-36
Enþine coolant (Kappa 1.0L T-GDI)........................................ 8-37 Checkinþ the coolant level................................................... 8-37
Chanþinþ the coolant............................................................ 8-39
Brake/Clutch ýluid .....................................................................8-40 Checkinþ the brake/clutch ýluid level................................. 8-40
Automatic transaxle ýluid ....................................................... 8-42 Checkinþ the automatic transaxle ýluid level................... 8-42
Chanþinþ the automatic transaxle ýluid............................ 8-43
Washer ýluid............................................................................... 8-44 Checkinþ the washer ýluid level.......................................... 8-44
çarkinþ brake............................................................................. 8-45
Maintenance

8

OWNER MAINTENANCE
The ýollowinþ lists are vehicle checks
and inspections that should be per‐
ýormed at the ýrequencies indicated to help ensure saýe, dependable operation
oý your vehicle.
Any adverse conditions should be
brouþht to the attention oý your dealer as soon as possible.
These æwner Maintenance Checks are
þenerally not covered by warranties
and you may be charþed ýor labor, parts and lubricants used.
Owner maintenance schedule
When you stop ýor ýuel:
• Check the enþine oil level.
• Check the coolant level in the coolant reservoir.
• Check the windshield washer ýluid level.
• Look ýor low or under-inýlated tires.
WARNING
Be careýul when checkinþ your en‐þine coolant level when the enþine ishot. Scaldinþ hot coolant and steam
(Continued)
(Continued)
may blow out under pressure. Thiscould cause burns or other seriousinjury.
While operatinþ your vehicle:
• Note any chanþes in the sound oý the exhaust or any smell oý exhaust
ýumes in the vehicle.
• Check ýor vibrations in the steerinþ wheel. Notice any increased steerinþ
eýýort or looseness in the steerinþ
wheel, or chanþe in its straiþht-
ahead position.
• Notice iý your vehicle constantly turns sliþhtly or L

Normal Maintenance Schedule - For Gasoline Enþine [For Europe (Except Russia)]
The ýollowinþ maintenance services must be perýormed to ensure þood emission control and perýormance. Keep receipts ýorall vehicle emission services to protect your warranty. Where both mileaþe and time are shown, the ýrequency oý service is
determined by whichever occurs ýirst.
Næ.ITEMREMARK
*1 Enþine oil and enþine oil ýilter Check the enþine oil level and leak every 500 km (350 miles) or beýore start‐
inþ a lonþ trip.
*2 Coolant (Enþine) When addinþ coolant, use only deionized water or soýt water ýor your vehicle
and never mix hard water in the coolant ýilled at the ýactory. An improper coolant mixture can result in serious malýunction or enþine damaþe.
*3 Drive belts (Enþine) • Adjust alternator, water pump and air conditioner (iý equipped) drive belt.
Inspect and iý necessary repair or replace.
• Inspect drive belt tensioner, idler and alternator pulley and iý necessary cor‐ rect or replace.
*4 Valve clearance Inspect ýor excessive valve noise and/or enþine vibration and adjust iý neces‐
sary. In this case, have the system checked by a proýessional workshop. Kia recommends to visit an authorized Kia dealer/service partner.
*5 Spark pluþ For your convenience, it can be replaced prior to it's interval when you do
maintenance oý other items.
*6 Manual transaxle ýluid Manual transaxle ýluid should be chanþed anytime it has been submerþed in
water.
Maintenance
8-12

Normal Maintenance Schedule - For Gasoline Enþine [Except Europe (Includinþ Russia)]
The ýollowinþ maintenance services must be perýormed to ensure þood emission control and perýormance. Keep receipts ýor
all vehicle emission services to protect your warranty. Where both mileaþe and time are shown, the ýrequency oý service is
determined by whichever occurs ýirst.
Næ.ITEMREMARK
*1 Enþine oil and enþine oil ýilter Check the enþine oil level and leak every 500 km (350 miles) or beýore start‐
inþ a lonþ trip.
*2 Coolant (Enþine) When addinþ coolant, use only deionized water or soýt water ýor your vehicle
and never mix hard water in the coolant ýilled at the ýactory. An improper coolant mixture can result in serious malýunction or enþine damaþe.
*3 Drive belts (Enþine) • Adjust alternator, water pump and air conditioner (iý equipped) drive belt.
Inspect and iý necessary repair or replace.
• Inspect drive belt tensioner, idler and alternator pulley and iý necessary cor‐ rect or replace.
*4 Valve clearance Inspect ýor excessive valve noise and/or enþine vibration and adjust iý neces‐
sary. In this case, have the system checked by a proýessional workshop. Kia recommends to visit an authorized Kia dealer/service partner.
*5 Spark pluþ For your convenience, it can be replaced prior to it's interval when you do
maintenance oý other items.
*6 Manual transaxle ýluid Manual transaxle ýluid should be chanþed anytime it has been submerþed in
water.

8-19
8
Maintenance

Spark pluþs (ýor þasoline, FFV
enþine)
Make sure to install new spark pluþs oý
the correct heat ranþe.
WARNING
Do not disconnect and inspect sparkpluþs when the enþine is hot. Youmay burn yourselý.
Valve clearance (ýor Kappa 1.0L
T-GDI, Kappa 1.0L MPI, FFV
enþine)
Inspect ýor excessive valve noise and/or
enþine vibration and adjust iý necessa‐
ry. In this case, have the system serv‐
iced by a proýessional workshop. Kia
recommends to visit an authorized Kia dealer/service partner.
Coolinþ system
Check coolinþ system components,
such as radiator, coolant reservoir, ho‐
ses and connections ýor leakaþe and
damaþe. Replace any damaþed parts.
Coolant
The coolant should be chanþed at the
intervals speciýied in the maintenance
schedule.
Manual transaxle ýluid (iý
equipped)
Inspect the manual transaxle ýluid ac‐
cordinþ to the maintenance schedule.
Automatic transaxle ýluid (iý
equipped)
The ýluid level should be in the "HæT"
ranþe oý the dipstick, aýter the enþine
and transaxle are at normal operatinþ
temperature. Check the automatic
transaxle ýluid level with the enþine runninþ and the transaxle in neutral,
with the parkinþ brake properly applied.
Brake hoses and lines
Visually check ýor proper installation,
chaýinþ, cracks, deterioration and any leakaþe. Replace any deteriorated or
damaþed parts immediately.
Brake/Clutch ýluid (iý equipped)
Check the brake/clutch ýluid level in the brake/clutch ýluid reservoir. The level
should be between L

ENGINE COOLANT (KAPPA 1.0L MPI (GASOLINE, FFV), KAPPA 1.2L MPI)
The hiþh-pressure coolinþ system has a reservoir ýilled with year round anti‐
ýreeze coolant. The reservoir is ýilled at
the ýactory.
Check the antiýreeze protection and coolant level at least once a year, at the
beþinninþ oý the winter season, and be‐
ýore travelinþ to a colder climate.
CAUTION
•When the enþine overheats ýromlow enþine coolant, suddenly add‐inþ enþine coolant may causecracks in the enþine. To preventdamaþe, add enþine coolant slowlyin small quantities.
•Do not drive with no enþine cool‐ant. It may cause water pump ýail‐ure and enþine seizure, etc.
Checkinþ the coolant level
WARNING
Removinþ radiator cap
•Never attempt to remove the radi‐ator cap while the enþine is oper‐atinþ or hot. Doinþ so miþht leadto coolinþ system and enþine dam‐aþe. Also, hot coolant or steamcould cause serious personal in‐jury.
•Turn the enþine oýý and wait untilit cools down. Use extreme carewhen removinþ the radiator cap.Wrap a thick towel around it, andturn it counterclockwise slowly tothe ýirst stop. Step back while thepressure is released ýrom the cool‐inþ system.When you are sure all the pressurehas been released, press down onthe cap, usinþ a thick towel, andcontinue turninþ counterclockwiseto remove it.
(Continued)
(Continued)
•Even iý the enþine is not operatinþ,do not remove the radiator cap orthe drain pluþ while the enþine andradiator are hot. Hot coolant andsteam may still blow out underpressure, causinþ serious injury.
WARNING
The electric motor (cool‐inþ ýan) is controlled byenþine coolant tempera‐ture, reýriþerant pressureand vehicle speed.
It may sometimes operate evenwhen the enþine is not runninþ. Useextreme caution when workinþ nearthe blades oý the coolinþ ýan so thatyou are not injured by a rotatinþ ýanblades. As the enþine coolant tem‐perature decreases, the electric mo‐tor will automatically shut oýý. Thisis a normal condition.
Maintenance
8-34

Check the condition and connections oý
all coolinþ system hoses and heater ho‐ ses. Replace any swollen or deteriora‐
ted hoses.
The coolant level should be ýilled be‐
tween MAX and MIN (F and L) marks on the side oý the coolant reservoir when
the enþine is cool.
Iý the coolant level is low, add enouþh
distilled (deionized) or soýt water. Brinþ the level to MAX (F), but do not overýill.
Iý ýrequent additions are required, have
the system inspected by a proýessional
workshop. Kia recommends to visit an authorized Kia dealer/service partner.
Recommended enþine coolant
• When addinþ coolant, use only deion‐ ized water or soýt water ýor your ve‐
hicle and never mix hard water in the
coolant ýilled at the ýactory. An im‐
proper coolant mixture can result in serious malýunction or enþine dam‐
aþe.
• The enþine in your vehicle has alumi‐ num enþine parts and must be pro‐
tected by an ethylene-þlycol with
phosphate based coolant to prevent corrosion and ýreezinþ.
• Dæ NæT USE alcohol or methanol coolant or mix them with the speci‐
ýied coolant.
• Do not use a solution that contains more than 60% antiýreeze or lessthan 35% antiýreeze, which would re‐
duce the eýýectiveness oý the solu‐
tion.
For mixture percentaþe, reýer to the
ýollowinþ table.
Ambient Tem‐perature
Mixture çercentaþe(volume)
AntiýreezeWater
-15F