2018 FIAT 500 engine overheat

KNOWING YOUR CAR
12
HOT ENGINE COOLANT
The warning light switches on when the ignition key is turned to MAR, but it should switch off after a few seconds.
The warning light or symbol on the display lights up when the engine is overheated, on some versions, together with a
dedicated message on the display.
❒ In normal driving conditions: stop the car, switch off the engine and check that the fluid level in the reservoir is not
below the MIN mark. In this case, wait for the engine to cool down, then slowly and carefully open the cap, top up with
coolant and check that the level is between the MIN and MAX marks on the reservoir itself. Also check visually for any
fluid leaks. Should the warning light turn on again at the next start-up, contact a Fiat Dealership.
❒ if the vehicle is used under demanding conditions (e.g. towing trailers uphill or fully loaded): slow down and, if the
light stays on, stop the car. Stop for two or three minutes with the engine running and slightly accelerated to facilitate
better coolant circulation, then turn the engine off. Check that the coolant level is correct as described above.
IMPORTANT Over demanding routes, it is advisable to keep the engine running and slightly accelerated for a few minutes
before turning it off.
On certain versions the dedicated message is displayed.uu
{{
“DUALDRIVE” ELECTRIC POWER STEERING FAULT
When the key is turned to MAR, the warning light switches on but it should switch off after a few seconds.
If the warning light stays on, on some versions along with a dedicated message on the display, you may not have steering
assistance and the effort required to operate the steering wheel could be notably increased; steering is, however, possible.
In this case, contact a Fiat Dealership.
If the warning light switches on while driving (on some versions, together with a dedicated message on the display) you may
not have steering assistance. Although it will still be possible to steer the vehicle, the effort needed to operate the steering
wheel could be increased: contact a Fiat Dealership as soon as possible.
IMPORTANT In some circumstances, factors independent of the electric power steering could cause the warning light on
the instrument panel to switch on. In this case, stop the car immediately (should it be in motion), stop the engine for about
20 seconds and then restart the engine. If the warning light stays on, contact a Fiat Dealership.
IMPORTANT After the battery is disconnected, the steering must be initialised. The warning light switches on to indicate
this. To carry out this procedure, simply turn the steering wheel all the way from one end to the other or drive in a straight
line for about a hundred metres.

23
RIGHT-HAND DIRECTION INDICATOR
The warning light switches on when the direction indicator control stalk is moved upwards or, together with the left
indicator, when the hazard warning light button is pressed.
“DUALDRIVE” ELECTRIC POWER STEERING ACTIVATION
The indication CITY switches on when the “Dualdrive” electric power steering system is activated by pressing the “CITY”
button on the dashboard. Press the button again to turn the CITY indication off. CITY
SPORT
ECO
DUALOGIC
GEARBOX
MESSAGES
11
MAIN BEAM HEADLIGHTS
The light comes on when the main beam headlights are turned on.
SPORT FUNCTION ON
The indication SPORT appears on the display when the “SPORT” function is selected by pressing the respective button on
the dashboard. The SPORT indication will switch off when the button is pressed again.
A dedicated screen instead of the “SPORT” indication is displayed on some versions.
ECO FUNCTION ON
The indication ECO appears on the display when the “ECO” function is selected by pressing the respective button on the
dashboard. The ECO indication will switch off when the button is pressed again.
A dedicated page instead of the “ECO” indication is displayed on some versions.
For versions equipped with “Dualogic” gearbox, the following messages can be displayed:
Reduce gear changes – Manual method unavailable – Automatic method unavailable – Clutch overheating – Depress
brake pedal – Depress brake pedal - Engine start delayed – Gear unavailable
Operation not admissible – Depress brake pedal and repeat operation – Shift to neutral.
DE
ENABLING CRUISE CONTROL
The indicator light turns on when cruise control is activated.
ENABLING THE SPEED LIMITER
The indicator light comes on when the speed limiter is activated.

IMPORTANT INFORMATION AND RECOMMENDATIONS
198
PERSONAL SAFETY
(CONTINUED)
Do not use the jack for loads higher than the one shown on its
label. Never start the engine with vehicle raised. If the vehicle is
raised more than necessary, everything can become more
unstable, with the risk of the vehicle dropping violently.
Thus, lift the vehicle only as needed in order to access the
spare tyre.
33) FIX&GO QUICK TYRE REPAIR KIT
•The information required by the applicable regulation is
indicated on the Fix&Go kit package label. Carefully read the
label on the cartridge before use, avoid improper use. The kit
should be used by adults and cannot be used by children.
IMPORTANT: Do not exceed 80 km/h. Avoid sudden
acceleration or braking. The kit provides a temporary repair,
therefore the tyre must be examined and repaired by a
specialist as soon as possible. Before using the kit, ensure that
the tyre is not excessively damaged and that the rim is in good
condition, otherwise do not use it and call roadside assistance.
Do not remove foreign bodies from the tyre. Do not let the
compressor turned on for more than 20 consecutive minutes -
overheating hazard.
34) CHANGING A BULB
•Modifications or repairs to the electric system that are not
carried out properly or do not take the system technical
specifications into account can cause malfunctions leading to
the risk of fire.
•Halogen bulbs contain pressurised gas, in the case of
breakage they may burst causing glass fragments to be
projected outwards.
•Due to the high power supply voltage, gas discharge bulbs
(Xenon) should only be replaced by specialised personnel:
danger of death! Contact a Fiat Dealership.35) REPLACING FUSES
•If the replaced fuse blows again, contact a Fiat Dealership.
•Never replace a fuse with metal wires or anything else.
•Never replace a fuse with another with a higher amp rating; RISK
OF FIRE.
•If a general fuse (MEGA-FUSE, MIDI-FUSE,
MAXI-FUSE) blows contact a Fiat Dealership.
•Before replacing a fuse, make sure that the ignition key has
been removed and that all the other services are switched off
and/or disengaged.
•Contact Fiat Dealership if a safety system (airbags, brakes),
engine system
(engine, gearbox) or steering system general protection fuse
blows.
36) BATTERY RECHARGING
•Battery fluid is poisonous and corrosive:
avoid contact with your skin and eyes. The battery should be
charged in a well ventilated place, away from naked flames or
possible sources of sparks: danger of explosion and fire.
•Do not attempt to charge a frozen battery: it must be thawed
first, otherwise it may explode.
If freezing has occurred, the battery should be checked by skilled
personnel to make sure that the internal elements are not
damaged and that the body is not cracked, with the risk of leaking
poisonous and corrosive acid.
37) TOWING THE CAR
•Before tightening the ring clean the threaded housing thoroughly.
Make sure that the ring is fully fastened in the housing before
towing the car.
(CONTINUES)

200
PERSONAL SAFETY
(CONTINUED)
42) INTERIORS
•Never use flammable products, such as petrol ether or rectified
petrol to clean the inside of the car. The electrostatic charges which
are generated by rubbing during the cleaning operation may cause
a fire.
•Do not keep aerosol cans in the vehicle: they might explode.
Aerosol cans must not be exposed to a temperature exceeding
50°C. When the vehicle is exposed to sunlight, the internal
temperature can greatly exceed this value.
43) TECHNICAL SPECIFICATIONS – FUEL SUPPLY
Modifications or repairs to the supply system that are not carried
out correctly or do not take the system technical specifications
into account can cause malfunctions leading to the risk of fire.
44) TECHNICAL SPECIFICATIONS – RIM PROTECTOR
TYRES
DO NOT fit wheel hub caps when using integral hub caps fixed
(with springs) to the steel rim and after sale tyres provided with
Rim Protector. Use of unsuitable tyres and wheel caps may cause
sudden decrease of tyre pressure.
45) LPG
•Note that in some countries (including Italy) there are legal
restrictions in force for parking/garaging motor vehicles fuelled by
gas that is denser than air; LPG comes under this category.
•Do not switch between the two operating modes (petrol/LPG)
whilst starting the engine.
•The LPG supply system is equipped with a “consumption”
function linked to the LED display of LPG level on the switch; this
function activates only after a consistent variation in fuel level has
been detected. •Running the battery with an excessively low liquid level will
damage the battery beyond repair and could even cause its
explosion.
•If the vehicle must remain unused for a long time at a very low
temperature, remove the battery and take it to a warm place, to
avoid freezing.
•When performing any operation on the battery or near it,
always protect your eyes with special goggles.
40) TYRES AND WHEELS
•Remember that the road holding qualities of your car also
depend on correct tyre pressures.
•If tyre pressure is too low, the tyre may overheat and be
severely damaged as a result.
•Do not switch tyres from the right hand side of the vehicle to the
left hand side, and vice versa.
•Never submit alloy rims to repainting treatments requiring the
use of temperatures exceeding 150°C.
The mechanical properties of the wheels could be impaired.
41) WINDSCREEN AND –REAR WINDOW WIPER
•Driving with worn windscreen/rear window wiper blades is a
serious hazard, because visibility is reduced in bad weather.
•If the window needs to be cleaned, make sure the device is
deactivated or the key is on STOP.
IMPORTANT INFORMATION AND RECOMMENDATIONS
(CONTINUES)

IMPORTANT INFORMATION AND RECOMMENDATIONS
204(CONTINUES)
• Warning light mwill blink for 60 seconds after starting or
during prolonged cranking to indicate a fault to the glow plug
heating system.
Use the car normally if the engine starts and go to a Fiat
Dealership as soon as possible.
• Never bump start the engine by pushing, towing or coasting
downhill. This could cause fuel to flow into the catalytic
converter and damage it beyond repair.
• Never use a fast battery-charger to start the engine as this could
damage the electronic systems of your vehicle, particularly the
ignition and engine fuel supply control units.
• Do not connect the cable to the negative terminal (–) of the flat
battery. The following spark could lead to battery explosion and
cause serious harm.
Only use the specific earth point; do not use
any other exposed metallic part.
• A quick burst on the accelerator before turning off the engine
serves absolutely no practical purpose; it wastes fuel and is
especially damaging to turbocharged engines.
14) USING THE GEARBOX: MANUAL AND DUALOGIC
• Do not drive with your hand resting on the gear lever as the
force exerted, even if slight, could lead over time to premature
wear of the gearbox internal components.
• If the gearbox is faulty, contact a Fiat Dealership as soon as
possible to have the system checked.
• Avoid keeping your hand placed on this lever in between
gear changes or Auto/Manual mode.
• Using the paddles incorrectly (paddles pushed towards the
dashboard) could break them.• In order to safeguard the efficiency of the clutch, do not use the
accelerator to keep the car still (for example:
stopped on a hill); the clutch could overheat and be damaged;
use the brake pedal and only operate the accelerator pedal when
you decide to set off.
• If the messages continue to be shown in the display, contact a
Fiat Dealership.
15) SNOW CHAINS
• Keep the vehicle’s speed down when snow chains are fitted;
never exceed 50 km/h.
• With snow chains, use the accelerator with extreme care to
prevent, or to limit as much as possible, slipping of the drive
wheels that could cause chain breakage, resulting in damage to
the car body or mechanical components.
• Avoid potholes, steps and pavements and avoid driving long
distances on roads not covered with snow to avoid damaging the
car and the roadbed.
16) POWER SOCKET
Only accessories with a maximum power of 180 W (maximum
absorption 15 A)
can be connected to the socket.
17) DIESEL FILTER
The presence of water in the supply circuit may cause severe
damage to the injection system and irregular engine operation.
If the warning light or the symbol
Eon the colour display turns
on, contact a Fiat Dealership as soon as possible to have the
system bled.
VEHICLE SAFETY
(CONTINUED)