2018 FIAT 500 brake fluid

157
1.3 MULTIJET 95 HP
EURO 5
A. Engine coolant fluid
B. Engine oil plug/filler
C. Brake fluid
D. Battery
E. Engine oil dipstick
F. Windscreen washer fluid
140DVDF0S079c
1.3 MULTIJET 78/95 HP
EURO 6
A. Engine coolant fluid
B. Engine oil plug/filler
C. Brake fluid
D. Battery
E. Engine oil dipstick
F. Windscreen washer fluid
141DVDF0S462c

SERVICING AND CARE
158
ENGINE COOLANT
39) 22) 23)
The coolant level must be checked
when the engine is cold and must
range between the
MIN and MAX marks on the reservoir.
A 50-50 mixture of PARAFLU
UPand
distilled water gives freeze protection
up to –35°C.
When the vehicle is used in particularly
harsh weather conditions, we
recommend using a 60% mixture of
PARAFLU
UPand 40% of demineralised
water.
CHECKING LEVELS
ENGINE OIL
39) 22) 26) 4)
Check the engine oil level a few
minutes (about five) after the engine
has stopped, with the car parked on
level ground.
The oil level must be within the MIN
and MAX marks on the dipstick.
NOTE
The dipstick is integrated in the engine
oil cap for 0.9 TwinAir 60 HP*, 65 HP,
80 HP*, 85 HP and 105 HP versions.
❒ The range between the MIN and
MAX marks corresponds to about 1
litre of oil.
❒ If the level of the oil is close to or
below the MIN mark, add oil via the
filler fitting until the MAX mark is
reached.
❒ The oil level must never exceed the
MAX mark.
❒ The maximum engine oil
consumption is usually 400 grams
every 1000 km.
* For versions/markets, where provided
WINDSCREEN/REAR
WINDOW WASHER
FLUID
39) 22)
Use a mixture of water and
PETRONAS DURANCE
SC35 fluid, in the following
concentrations:
❒ 30% PETRONAS DURANCE
SC35 and 70% water in summer.
❒ 50% PETRONAS DURANCE
SC35 and 50% water in winter.
BRAKE FLUID 39) 22)
The fluid level in the reservoir must not
exceed the MAX mark.
IMPORTANT Brake fluid is
hygroscopic (i.e. it absorbs moisture).
For this reason, if the vehicle is mainly
used in areas with a high degree of
atmospheric humidity, the fluid should
be replaced at more frequent intervals
than specified in the
“Scheduled Servicing Plan”.

177
Unladen weight (with all fluids,
fuel tank 90% full and
without optional equipment): 865 905 930/940  970/980  940 980
Payload
 including the driver: 475 445 440 415 440 415
Maximum
permitted loads
– front axle: 770 770 830 830 830 830
– rear axle: 640 640 640 640 640 640
– total: 1340 1350 1370/1380  1385/1395  1380 1395
Towable loads
with braked trailer: 800 800 800 800 800 800
trailer without brakes: 400 400 400 400 400 400
Maximum load on the tow hook
with braked trailer: 60 60 60 60 60 60
Weights (kg)
0.9 TwinAir
60 HP*- 65 HP0.9 TwinAir 105 HP
If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases, thus reducing the specified payload.
Loads not to be exceeded. The driver is responsible for arranging goods in the luggage compartment and/or load platform within the
maximum permitted loads.
Dualogic versions.
* For versions/markets, where provided
0.9 TwinAir 80 HP*- 85 HP
WEIGHTS

TECHNICAL DATA
178
Unladen weight (with all fluids,
fuel tank 90% full and
without optional equipment): 865/900  905/940  865 905 930/940  970/980 
Payload  including the driver: 480/450  450/420  480 450 440 415
Maximum
permitted loads
– front axle: 770 770 770 770 830 830
– rear axle: 640 640 640 640 640 640
– total: 1345/1350  1355/1360  1345 1355 1370/1380  1385/1395 
Towable loads
with braked trailer: 800 800 800 800 800 800
trailer without brakes: 400 400 400 400 400 400
Maximum load on the tow hook
with braked trailer: 60 60 60 60 60 60
Weights (kg)
1.2 8V 69 HP
If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases, thus reducing the specified payload.
Loads not to be exceeded. The driver is responsible for arranging goods in the luggage compartment and/or load platform within the
maximum permitted loads.
Dualogic versions.
* For versions/markets, where provided
1.4 16V 100 HP*1.2 8V 69 HP EVO2 S&S

179
Unladen weight (with all fluids,
fuel tank 90% full and
without optional equipment): 980 1020 865
Payload
including the driver: 440 415 480
Maximum permitted loads
– front axle: 830 830 770
– rear axle: 640 640 640
– total: 1420 1435 1345
Towable loads
with braked trailer: 800 800 –
trailer without brakes: 400 400 –
Maximum load on the tow hook
with braked trailer: 60 60 60
Weights (kg)1.3 16V 78 HP / 95 HP EURO 61.2 8V
69 HP LPG
If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases, thus reducing the specified payload.
Loads not to be exceeded. The driver is responsible for arranging goods in the luggage compartment and/or load platform within the
maximum permitted loads.
Dualogic versions.
* For versions/markets, where provided

TECHNICAL DATA
180
CAPACITIES21) 38) 11) 22) 3)
Fuel tank (litres): 35 35 35 35
Including a reserve of (litres): 5 5 5 5
Engine cooling system 4.85/
(litres): 5.2 5.3 5.2 4.4
Engine sump (litres): 2.8  2.8  2.5  2.75 
Engine sump and filter (litres): 3.2  3.2  2.8  2.90 
Gearbox/differential casing (litres): 1.65 1.65 1.65 1.65
Dualogic gearbox hydraulic
activation system (litres/kg): – 0.7/0.59 0.7/0.59 0.7/0.59

Hydraulic brake circuit (kg): 0.55 0.55 0.55 0.55
Hydraulic clutch controls
(RH drive versions): – – 0.100 0.100
Windscreen and rear window
washer fluid reservoir (litres): 2.5 2.5 2.5 2.5
* For versions/markets, where provided
** When the vehicle is used in particularly harsh weather conditions, we recommend using a 60% mixture of PARAFLUUPand 40% of
demineralised water.
LPG versions
Petrol versions
0.9
TwinAir
60 HP
*65 HP
0.9
TwinAir
80 HP
*85 HP
105 HP
1.2 8V
69 HP1.4 16V
100 HP*Prescribed fuels and
original lubricants
Unleaded petrol with R.O.N.
no lower than 95 (EN 228 specifications)
Mixture of distilled water and
PARAFLU
UPat 50% (**)
SELENIA K P.E.

SELENIA DIGITEK P.E. SELENIA MULTIPOWER GAS 5W-40 
TUTELA GEAR FORCE
TUTELA CS SPEED
Special oil with
“ATF DEXRON III” type additive
TUTELA TOP 4 or TUTELA TOP 4/S
Mixture of water and
PETRONAS DURANCE SC35

181
Fuel tank (litres): 35 35
Including a reserve of (litres): 5 5
Engine cooling system
(litres): 6.3 6.3
Engine sump (litres): 2.8 3.7
Engine sump and filter (litres): 3.0 3.9
Gearbox
casing/differential: 1.55 (kg) 1.55 (kg)
Hydraulic brake circuit (kg): 0.55 0.55
Hydraulic clutch controls
(RH drive versions): – –
Hydraulic clutch controls
(RH drive versions): 2.5 2.5
When the vehicle is used in particularly harsh weather conditions, we recommend using a 60% mixture of PARAFLUUPand 40% of
demineralised water.
Diesel versions1.3 16V Multijet
95 HP EURO 51.3 16V 78 HP / 95 HP
EURO 6Prescribed fuels and
original lubricants
Diesel for motor vehicles (EN590
specifications)
Mixture of distilled water and
PARAFLU
UPat 50% 
SELENIA WR P.E.
TUTELA TRANSMISSION GEARFORCE
TUTELA TOP 4 or TUTELA TOP 4/S
Mixture of water and
PETRONAS DURANCE SC35
Maximum refuelling capacity (including reserve): 30.5 litres of LPG
The figure already takes into account the 80% tank filling limit and the residual fluid required for priming; this figure
represents the maximum permitted capacity. There may be slight variations to this figure as a result of:
differences between the network pump supply pressures, pumps having different supply/locking features,
tank not completely run out of fuel.
LPG versions

183
Brake fluid
Diesel additive
Windscreen/rear
window washer
fluid
Applications
TUTELA TRANSMISSION
GEARFORCE
Contractual Technical
Reference No. F002.F10
TUTELA CS SPEED
Contractual Technical
Reference No. F005.F98
TUTELA ALL STAR
Contractual Technical
Reference No. F702.G07
TUTELA STAR 700
Contractual Technical
Reference No. F701.C07
TUTELA STAR 325
Contractual Technical
Reference No. F301.D03
TUTELA TOP 4
Contractual Technical
Reference N° F001.A93
or
TUTELA TOP 4/S
Contractual Technical
Reference N° F005.F15
TUTELA DIESEL ART Contractual
Technical Reference No. F601.L06
PETRONAS DURANCE SC 35
Contractual Technical
ReferenceNo. F001.D16Mechanical gearbox
and differential
Hydraulic actuation
system lubricant
Dualogic gearbox
Wheel side HP joints
Differential side HP joints
(excluding 1.4 16V
100 HP versions)
Differential side HP joints
(1.4 16V 100
HP versions)
Hydraulic brakes and
hydraulic clutch controls
To be mixed with diesel
25 cc per 10 litres
To be used diluted or
undiluted in windscreen
washer/wiper systems
UseFeaturesSpecificationsGenuine fluids and
lubricants
Oils and greases
for drivelineSAE 75W API GL4
grade synthetic lubricant
Specific fluid for electro-hydraulic
actuators
“ATF DEXRON III” type oil
Molybdenum disulphide grease,
for use at high temperatures.
N.L.G.I. consistency 1-2
Grease for constant velocity joints
with low friction coefficient.
N.L.G.I. consistency 0-1
Polyurea synthetic-based grease
suitable for high temperatures.
NL.G.I. consistency 2
Synthetic fluid for brake and clutch
systems. Exceeds specifications
F.M.V.S.S. no. 116 DOT 4,
ISO 4925 SAE J1704
Antifreeze additive for diesel,
with protective action for diesel engines
Mixture of alcohol, water and
surfactants CUNA NC 956-II9.55550-MZ6
9.55550-SA1
9.55580-GRAS II
9.55580-GRAS II
9.55580-GRAS II
9.55597
or
MS.90039
–
9.55522
or
MS.90043